DutchWest 2465 Installation And Operating Manual

Direct vent / natural vent gas heater
Table of Contents

Advertisement

INSTALLER/cONSUMER

SAFETY INFORMATION

pLEASE READ THIS MANUAL
BEFORE INSTALLING AND
USING AppLIANcE
WARNING!
IF THE INFORMATION IN THIS
MANUAL IS NOT FOLLOWED
ExAcTLY, A FIRE OR ExpLO-
SION MAY RESULT cAUSING
pROpERTY DAMAGE, pER-
SONAL INjURY OR LOSS OF
LIFE.
FOR YOUR SAFETY
Installation and service must
be performed by a qualified
installer, service agency or
the gas supplier.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electric switch;
do not use any phone in your
building.
• Immediately call your gas
supplier from your neighbor's
phone. Follow the gas suppliers
instructions.
• If you cannot reach your gas
supplier call the fire department.
DO NOT STORE OR USE
GASOLINE OR OTHER FLAM-
MABLE VAPORS AND LIQUIDS
IN THE VICINITY OF THIS OR
ANY OTHER APPLIANCE.
This appliance may be installed in
an after market permanently located
manufactured (mobile) home where not
prohibited by local codes.
This appliance is only for use with the
type of gas indicated on the rating plate.
This appliance is not convertible for use
with other gases unless a certified kit is
used.
Direct Vent / Natural
Vent Gas Heater
Models: 2465, 2466
Homeowner's Installation
and Operating Manual
INSTALLER: Leave this manual with the appliance.
cONSUMER: Retain this manual for future reference.
1935
Dutchwest
gas stove
cover
5/03
C E RT I F I E D
30001935 9/10 Rev. 14
R

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 2465 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for DutchWest 2465

  • Page 1: Safety Information

    Direct Vent / Natural WARNING! IF THE INFORMATION IN THIS Vent Gas Heater MANUAL IS NOT FOLLOWED ExAcTLY, A FIRE OR ExpLO- Models: 2465, 2466 SION MAY RESULT cAUSING pROpERTY DAMAGE, pER- SONAL INjURY OR LOSS OF LIFE. FOR YOUR SAFETY...
  • Page 2: Table Of Contents

    Table of contents pLEASE READ THE INSTALLATION & OpERATING INSTRUcTIONS BEFORE USING AppLIANcE. Thank you and congratulations on your purchase of a Dutchwest stove. IMpORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty.
  • Page 3: General Information

    WARNING: Do not operate the Room Heater with the The Dutchwest Direct Vent/Natural Vent Room Heater and its glass panel removed, cracked or broken. Replacement individual shut-off valve must be disconnected from the gas...
  • Page 4: Requirements For The Commonwealth Of Massachusetts

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Installation Requirements Requirements for the commonwealth of Inspection Massachusetts The state or local gas inspector of the side wall horizontally vented gas fueled equipment shall not All gas fitting and installation of this heater shall only be approve the installation unless, upon inspection, the done by a licensed gas fitter or licensed plumber.
  • Page 5: Instructions Stove Dimensions

    DV/NV dimensions The Dutchwest stove is shipped from the factory as a Direct Vent Gas Heater. This heater may be convert- 5/15/03 ed into a Natural Vent unit in the field. If a Natural Vent heater is desired, the Z31D00 FSDHAG Draft Hood must be directly installed to the top of the unit according to the installation instructions.
  • Page 6: Installation Requirements

    Locating the Stove rear skirt. In choosing a location for the stove, consider: The Dutchwest heater is approved for installation into • The location of outside walls; an alcove constructed of combustible materials to the dimensions and clearances shown on the next page.
  • Page 7: Parallel & Corner Installation

    Fig. 4 Corner installation, minimum corner clearances and ST129c flue centerline. Hearth Requirements Dutchwest The Dutchwest Heater must be installed on rigid floor- corner specs ing. When the heater is installed directly on any com- 5/15/03 djt bustible surface other than wood flooring, a metal or wood panel extending the full width and depth of the unit must be used as the hearth.
  • Page 8: Gas Specifications

    ANSI Z21.88b-2008 / cSA 2.33b-2008 Vented Gas Fireplace Heaters The installation of your Dutchwest stove must conform with local codes, or in the absence of lo- cal codes, with the National Fuel Gas code ANSI Z223.1/NFpA 54 - latest edition, or cSA B149.1 Installation code.
  • Page 9: Vertical Termination - Direct Vent Only

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Vent Termination clearances Vertical Termination - Direct Vent ONLY When planning the installation, consider the location A vertical vent system must terminate no less than 8’ of the vent terminal and clearances. Some of the most (.44m) and no more than 40’...
  • Page 10 Dutchwest Direct Vent / Natural Vent Gas Heater ® Venting Termination clearances Your stove is approved to be vented either through the There must not be any obstruction such as bushes, side wall, or vertical through the roof. garden sheds, fences, decks or utility buildings within 4”...
  • Page 11: General Venting Information - Termination Location

    Dutchwest Direct Vent / Natural Vent Gas Heater ® General Venting Information - Termination Location INSIDE CORNER DETAIL Fixed Operable Closed CFM145a AREA WHERE TERMINAL IS NOT PERMITTED VENT TERMINATION AIR SUPPLY INLET canadian Installations US Installations A = Clearance above grade, veranda, porch, 1”...
  • Page 12: Termination Clearances

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Termination Clearances Termination clearances for buildings with combustible and noncombustible exteriors. Inside Corner Alcove Applications* Outside Corner Combustible 6" (152 mm) Combustible 6" (152 mm) Noncombustible 2" (51 mm) Noncombustible 2" (51 mm)
  • Page 13: Venting Requirements And Options - Direct Vent Only

    Through the Wall Vent Kit 7TFSDVSK Approved Vent System components (1) 90-Degree Elbow (CG) The Dutchwest Heater must be vented to the outdoors (1) 4” Straight pipe (CG) through an adjacent exterior wall or through the roof. The (1) 48” Straight pipe (CG)
  • Page 14: Install The Optional Fan

    Dutchwest Direct Vent / Natural Vent Gas Heater ® • Remove retaining nut from shaft of rheostat. (if Install the Optional Fan preinstalled) If you are installing the optional convection Fan Kit • Insert the rheostat through the hole in the back #767 (FK6), continue here.
  • Page 15: Venting System Assembly - Direct Vent

    1” from the end. Insert the pipe over the stove flue collar, keeping the vertical seam oriented to the back The Dutchwest is approved for installation only with the of the stove. Also, be sure to align holes on the pipe vent components listed on Page 13.
  • Page 16: Install Vent Adapter Pipe (Simpson Dura-Vent Components)

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Side Wall Termination Assembly Install the Vent Adapter pipe 1. Locate the vent opening on the wall. Refer to Fig- (Simpson Dura-Vent components) ure 5, Page 7, to determine the opening centerline.
  • Page 17 Dutchwest Direct Vent / Natural Vent Gas Heater ® For DuraVent pipe only: Install vent pipe by align- ing the locking system together, sliding the pipes together and twisting clockwise. • Install 90° elbow. Twist lock as before. • Slide the wall plate over horizontal run before at- taching the horizontal run to the elbow.
  • Page 18: Vent Termination Below Grade

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Vent Termination Below Grade Recessed Wall Install Snorkel Kit #7FSDVSKS when it is not possible to meet the required vent termination clearances of 1” Firestop (305mm) above grade level. The snorkel kit will allow Finishing installation depth of down to 7”...
  • Page 19: Venting System Assembly - Natural Vent

    The enlarged ends of General Information the vent sections always face downward. The Dutchwest Heater is shipped from the factory as 9. Install the storm collar and seal around the joints. a Direct Vent Heater. It may be converted to a Natural (Fig.
  • Page 20: Install The Log Set

    Check the Rating Plate attached by a steel cable to the firebox, to confirm that you have the appropriate firebox for the type of fuel to be used. The Dutchwest may be converted from one gas to another using the appropri- LG141 ate Fuel Conversion Kit listed on Page 34.
  • Page 21: Burner Information

    7. Hold the burner at the right hand side and lift to clear the right burner leg. Then pull to the right to clear the The Dutchwest is shipped from the factory with the air injectors on the left hand side.
  • Page 22: Complete The Assembly

    Dutchwest Direct Vent / Natural Vent Gas Heater ® 8. The air shutter is located on the bottom of the burner Should color need further adjustment, repeat steps 1 to the left. (Fig. 37) Unfasten the two nuts holding - 1 for air shutter adjustment.
  • Page 23 Dutchwest Direct Vent / Natural Vent Gas Heater ® Thermostat connection (optional) Use only a thermostat rated for 500 millivolts. Check the table below for the appropriate gauge ther- mostat wire to use for the length of lead required in your installation.
  • Page 24: Operation

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Operation Flame & Temperature Adjustment Your First Fire For stoves equipped with HI/LO valves, flame adjust- Read these instructions carefully and familiarize your- ment is accomplished by rotating the HI/LO adjustment self with the burner controls.
  • Page 25: Lighting And Operating Instructions

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Lighting and Operating Instructions FOR YOUR SAFETY READ BEFORE LIGHTING WARNING:If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
  • Page 26: Troubleshooting - Honeywell #840 Gas Control System

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Troubleshooting / Honeywell #8420 Gas control System NOTE: Before troubleshooting the gas control system, be sure the external gas shutoff is in the “ON” position. WARNING: REMOVE THE GLASS pANEL BEFORE pERFORMING ANY GAS cONTROL SERVIcE WORK.
  • Page 27: Fuel Conversion Instructions

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Fuel conversion Instructions WARNING! This conversion kit shall be installed Remove Screws Rear Log Bracket by a qualified service agency in accordance with the manufacturer’s instructions and all applicable Pilot codes and requirements of the authority having jurisdiction.
  • Page 28 Dutchwest Direct Vent / Natural Vent Gas Heater ® Pilot Hood Pilot Bracket CO105a Fig. 53 Remove pilot hood. Allen Wrench Index Tab CO105a gas conversion FC107 Pilot Fig. 51 Remove mounting screws, pressure regulator tower 1/28/00 djt and spring and diaphragm assembly.
  • Page 29 Dutchwest Direct Vent / Natural Vent Gas Heater ® 1. Replace burner. Slide the burner in at an angle Left Burner Leg with left side lower than the right side. Slide the left side onto the injectors, making sure the burner leg Injector Shoulder remains at a 90°...
  • Page 30: Maintenance

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Maintenance Your Dutchwest Gas Heater will provide years of ser- cAUTION vice with minimal upkeep. The following procedures will help ensure that your stove continues to function TURN THE pILOT OFF BEFORE pAINTING. ALLOW THE HEATER TO cOOL cOMpLETELY BEFORE properly.
  • Page 31: Gasket Replacement

    To ensure that the stove is operating properly, check the flames periodically to confirms they match Figure 61. The Dutchwest Gas Heater uses a ‘tadpole’ type gasket The flames will be blue during the first 15-0 minutes of to seal between the glass panel and the frame. In time, operation, and will gradually turn to yellow after that.
  • Page 32: Wiring Diagram

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Wiring Diagrams POWER On/Off Switch Wiring CORD Chassis TP/TH Ground Millivolt Gas Valve Black ST14b Thermostat Optional Thermostat FAN JUNCTION BOX (Optional) Thermostat (Optional) Wiring Strain Relief St124b ON / OFF...
  • Page 33: Replacement Parts

    16a,b, 37a,b MHSC reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. 1935 Dutchwest Direct Vent / Natural Vent Gas Heater Dutchwest parts 5/16/03 djt Models 2465, 2466 Ref.
  • Page 34 Dutchwest Direct Vent / Natural Vent Gas Heater ® Dutchwest Direct Vent / Natural Vent Gas Heater Models 2465, 2466 (continued) Ref. Description Dutchwest Glass, DV5 1601691 Glass Frame Assembly - SDV30 3000017 Gasket, Glass - Med. Knit - RDV40 10370 13a.
  • Page 35: Optional Accessories

    Dutchwest Direct Vent / Natural Vent Gas Heater ® Optional Accessories Fan Kits Remote controls FK26 Fan The remote control allows you to turn the heater on or off from anywhere in the room. Refer to Page 3 for The FK6 fan helps distribute heated air from within wiring diagrams.
  • Page 36 Dutchwest Direct Vent / Natural Vent Gas Heater ® 30001935...
  • Page 37 Dutchwest Direct Vent / Natural Vent Gas Heater ® 30001935...
  • Page 38 Dutchwest Direct Vent / Natural Vent Gas Heater ® 30001935...
  • Page 39: Warranty

    • This warranty is void if: cONDITIONS AND LIMITATIONS a) The fireplace has been operated in atmospheres contaminated by • This new Dutchwest product must be installed by a competent, chlorine, fluorine, or other damaging chemicals. authorized, service contractor. A licensed technician, as prescribed b) The fireplace has been subjected to prolonged periods of damp- by the local jurisdiction must perform any installation/service work.
  • Page 40: Energuide

    Efficiency Ratings Model EnerGuide Ratings Fireplace Efficiency (%) 465 63.0 466 63.0 MHSc 149 Cleveland Drive • Paris, Kentucky 40361 www.mhsc.com...

This manual is also suitable for:

2466

Table of Contents

Save PDF