Series 1100 high efficiency/combined intensity infra-red patio heater (17 pages)
Summary of Contents for Schwank 4002-CB
Page 1
MODELS: 4002-CB, 4005-CB INFRARED PORTABLE PATIO HEATER INSTALLATION / OWNER’S MANUAL WARNING Read and understand this installation and operation manual thoroughly prior to assembly, installation, operation or service to this appliance. FOR YOUR SAFETY: This heater must only be serviced by a trained gas service technician. Failure to comply could result in personal injury, death, fire and/or property damage.
This appliance is a transportable infrared patio, deck and garden heater for operation with LPG (Liquefied Petroleum Gas). The 4005-CB & 4002-CB burner is controlled and adjusted by the gas control knob located below the burner, and the gas supply is controlled by the valve on the portable propane gas cylinder.
3.1 GAS REQUIREMENTS AND LEAK TESTING: NEVER CONNECT AN UNREGULATED GAS SUPPLY TO THE HEATER. The propane connection hose supplied with the heater has a pressure regulator integrated into the hose . PRECAUTIONS: Periodically check the whole system for leaks or if the smell of gas is detected. ...
#2 or #3 tip Spray Bottle of Soapy Water or Paint Brush and soapy water (to check leaks) Heater Components Supplied: 4005-CB & 4002-CB Stainless Steel Hammered Black Finish finish Main burner head assembly unit 32” diameter single piece aluminum reflector ...
6. ASSEMBLY INSTRUCTIONS Attach Wheel Kit to Base: Assemble wheel brackets to base ‘L’ brackets using four #8 x 3/4” bolts and nuts (Note: Bolt heads face the wheel; Position wheel brackets with curve “up”) Align pairs of holes in each end of ‘L’ brackets to those in opposite sides of the base - fasten in place with #8 x 3/4”...
Page 9
ASSEMBLY..CONTINUED For LP connection: 1. Slide cylinder cover over post and let rest in upper position. 2. Slide gas hose up inside the post with LP regulator at bottom (regulator at lower end, inside cylinder cover) 3. Attach hose securely to burner 4.
7. CONNECTION AND TESTING PROPANE CYLINDER CONNECTION : Lift the cylinder cover up from the base of the heater Let cover rest on top of post supports in an angle position Install a full gas cylinder on to the heater base ...
8. A SAFE LOCATION FOR THE HEATER: Caution When objects are left under a heater in operation, such objects will be subject to radiant heat and could be damaged. The main application of this heater is to provide radiant heat comfort in the outdoors, at pool- side, spa areas, terraces, patios and work areas, etc.
9. OPERATION AND LIGHTING INSTRUCTIONS: Install ‘AAA” Battery into electronic igniter (as illustrated) by unscrewing the cap counter- ‘AAA’ Battery clockwise, insert battery with positive terminal facing “in”. Replace the cap. TO TURN ON: 1. From ‘OFF’ position, turn knob 90° counter-clockwise push and hold in. 2.
10. TROUBLE SHOOTING WARNING: THIS SECTION IS FOR CERTIFIED AND LICENSED GAS TECHNICIANS ONLY. IMPROPER ADJUSTMENT, ALTERATION, MAINTENANCE OR SERVICE PROCE- DURES, CAN CAUSE FIRE, PROPERTY DAMAGE SERIOUS INJURY, OR DEATH. IMPORTANT PROPANE NOTICE: Propane tanks equipped with the Q.C.C. {quick coupling connector} have an internal excess-flow valve safety feature to prevent propane from escaping at full pressure if a gas hose is severed.
11. STORAGE When heater is not in use for a prolonged period of time, remove gas cylinder. Verify that the gas valve is fully and tightly closed. Do not store the gas cylinder indoors. Store gas cylinder in a well ventilated area. For more compact storage and to avoid damage, the reflector may be removed 12.
LIMITED WARRANTY CERTIFICATE 4002-CB, 4005-CB FOR GAS-FIRED INFRA-RED PATIO HEATERS : 4001/2 (-J), 4N11/2 (-J) / 4401/2(-J), 44N1/2(-J) 4N/L51, 4N/L62 (-J) / 44N/L5, 44N/L6 (-J) SERIES The Manufacturer warrants that this product is free from defects in material or workmanship under normal use and service subject to the terms of this document.