Quadra-Fire Isle Royale 823-0170-MBK Owner's Manual
  1. Manuals
  2. Brands
  3. Quadra-Fire Manuals
  4. Wood stove
  5. Isle Royale 823-0170-MBK
  6. Owner's manual
Quadra-Fire Isle Royale 823-0170-MBK Owner's Manual

Quadra-Fire Isle Royale 823-0170-MBK Owner's Manual

Non-catalytic, top-load, wood heater installation and operation
Hide thumbs Also See for Isle Royale 823-0170-MBK:
Table of Contents

Advertisement

Quick Links

Download this manual
•
If the information in thes e
ins tructions is not followed
property damage, pers onal inj ury,
or death.
• Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
• Do not overfire - If heater or chimney
connector glows, you are overfiring.
Overfiring will void your warranty.
• Comply with all minimum clearances to
combustibles as specified. Failure to comply
may cause house fire.
F ire Ris k .
For use with solid wood fuel only.
Other fuels may overfire and generate
poisonous gases (i.e. carbon monoxide).
Installation and service of this appliance should
be performed by qualified personnel. Hearth &
Home Technologies recommends NFI certified
professionals, or technicians supervised by an
NFI certified professional.
www.quadrafire.com
Non- Catalytic, Top- load, Wood Heater
Owner' s Manual
Ins tallation and Operation
DO NOT DISCARD THIS MANUAL
• Read, understand and
Important operating
a n d m a i n t e n a n c e
instructions included.
WARNING
WARNING
Is le Royale
Models :
8 2 3 - 0 1 7 0 - MB K
8 2 3 - 0 2 9 0 - P MH
CAUTION
follow these instructions
for safe installation and
operation.
Hot glas s will caus e b urns .
•
Do not touch glass until it is cooled
•
NEVER allow children to touch glass
•
Keep children away
•
CAREFULLY SUPERVISE children in same room
as fireplace.
•
Alert children and adults to hazards of high
temperatures.
High temperatures may ignite clothing or other
•
Keep clothing, furniture, draperies and other
flammable materials away.
To obtain a French translation of this manual, please
contact your dealer or visit www.quadrafire.com
Pour obtenir une traduction fran aise de ce manuel,
s'il vous pla t contacter votre revendeur ou visitez
www.quadrafire.com
250-5763F
R
O-T L
Tested and
Listed by
C
OMNI-Test Laboratories, Inc.
• Leave this manual with
party responsible for
use and operation.
WARNING
HOT SURF ACES!
Glass and other surfaces are
hot during operation AND
cool down.
NOTE
Portland
Oregon USA
US
March 21, 2013

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Isle Royale 823-0170-MBK and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Quadra-Fire Isle Royale 823-0170-MBK

Summary of Contents for Quadra-Fire Isle Royale 823-0170-MBK

  • Page 1 Is le Royale Non- Catalytic, Top- load, Wood Heater Owner’ s Manual O-T L Portland Tested and Ins tallation and Operation Oregon USA Listed by Models : OMNI-Test Laboratories, Inc. 8 2 3 - 0 1 7 0 - MB K 8 2 3 - 0 2 9 0 - P MH CAUTION DO NOT DISCARD THIS MANUAL...
  • Page 2 Is le Royale Wood Stov e and Welcome to the Quadra-Fire Family of our stoves, inserts and fireplaces. And yet we are old- H earth & H ome T echnologies welcomes you to our tradi- fashioned when it comes to craftsmanship. E ach unit is tion of ex c e llence! In choosing a Q uadra- F ire appliance, meticulously fabricated and gold and nick e l surfaces are you have our assurance of commitment to q uality, durabil-...

  • Page 3: Table Of Contents

    Is le Royale Wood Stov e Safety Alert K ey: • D ANG E R! Indicates a haz a rdous situation which, if not avoided will result in death or serious injury. • W ARNING ! Indicates a haz a rdous situation which, if not avoided could result in death or serious injury. • CAU TION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

  • Page 4: Section 1 : Lis Ting And Code Approv Als

    Is le Royale Wood Stov e Lis ting and Code Approv als Model: Isle Royale 2 .9 grams per hour Lab oratory: OMNI Test Laboratories, Inc. 7 6 .5 % Report No & Date: 0 6 1 - S- 1 8 - 2 B TU Output: 1 1 ,5 0 0 to 4 6 ,0 0 0 Type:...

  • Page 5: Section 2 : G Etting Started

    Is le Royale Wood Stov e G etting Started B . F ire Safety A. Des ign, Ins tallation & Location Cons ider ations C onsideration must be given to: To provide reasonable fire safety, the following should be given serious consideration: •...

  • Page 6: Negative P Ressure

    Is le Royale Wood Stov e C. Negativ e P res s ure T o minimiz e the affects of negative air pressure the following Draft is the pressure difference needed to vent appliances must be considered: successfully. C onsiderations for successful draft include: •...

  • Page 7: F Lue Draft C Onsiderations

    Is le Royale Wood Stov e F . Tools And Supplies Needed D. F lue Draft Cons iderations Location of the appliance and chimney will affect perfor- B efore beginning the installation be sure that the following mance. As shown in F igure 6 . 1 on page 6 the chimney tools and building supplies are available.

  • Page 8: T Ypical Stove System

    Is le Royale Wood Stov e H. Typical Stov e Sys tems Spark A rresto r Cap F irecl ay F l u e Liner Co ncrete Cap Stove system with masonry chimney With A ir Space consists of: R af ter •...

  • Page 9: Section 3 : Dimens Ions

    Is le Royale Wood Stov e Dimens ions and Clearances A. Appliance Dimens ions 29" (737mm) NOTE: F lue Collar s iz e is 6 inch ( 1 5 2 mm) diameter ( ID) 30" (762mm) 28-3/4" (730mm) F igure 9 . 1 - F ront View 22-3/4"...

  • Page 10: C Learances To C Ombustibles

    Is le Royale Wood Stov e B . Clearances To Comb us tib les ( UL And ULC) 8 in. max Ceiling 26-7/16 in. (672mm) MINIMUM CLEARANCES TO COMBUSTIBLE MATERIALS In Inches & (Millimeters) NOTE: “A”, “C” and “F” Dimensions are to the inside diameter of the flue collar. FOR TOP VENT INSTALLATIONS: SINGLE WALL PIPE 18 (457)

  • Page 11: Section 4 : Ins Tallation Cons Ideration

    Is le Royale Wood Stov e Ins tallation Cons iderations In Canada, similar floor protection must be provided 18 A. Hearth P rotection Req uirements inches ( 4 5 7 mm) in front and 8 inches ( 2 0 3 mm) from the F LOOR P ROTECTION : F loor protector must be non - sides and rear of the stove.

  • Page 12: Reversible F Lue C Ollar

    Is le Royale Wood Stov e B . Rev ers ib le F lue Collar The flue collar is reversible for either a top or rear venting installation. The unit is shipped with the flue collar in the top vent position. Conv erting Collar F or Rear Vent Ins tallation 1 .

  • Page 13: Outside Air

    Is le Royale Wood Stov e C. Outs ide Air K it Ins tallation D. Ins tallation Of Optional B lower T he blower is shipped fully assembled and ready Included in K it: 1 flex flange; 2 cable ties; oustide air termi- for installation.

  • Page 14: Section 5 : Chimney Req Uirements

    Is le Royale Wood Stov e Chimney Req uirements A. Venting Components B . Chimney Sys tems Chimney Connector: P refab ricated Metal Chimney It is also known as flue pipe or stove pipe. The chimney • Must be minimum 6 inch (152mm) diameter (ID) high connector joins the stove to the chimney.
  • Page 15 Is le Royale Wood Stov e Thimb le Site constructed for masonry chimney installation: ceiling Components 13.5” below ceiling to top • A minimum length of 12 inches [305mm] (longer for of opening Wall or top of opening is a min.of thick e r walls) of solid insulated factory- built chimney 4.5”...
  • Page 16 Is le Royale Wood Stov e Mas onry Chimney Liner Min. Chimney Clearance to Wall Spacer and Min. Clearance F or optimal performance, masonry chimneys used to vent Combustibles - 2 inch (51mm) 2 inch (51mm) this appliance should be: 1 inch (25mm) Air 1.

  • Page 17: Ins Talling Chimney Components

    Is le Royale Wood Stov e C. Ins talling Chimney Components Mas onry Chimney Liner ( Cont' d) Chimney Connector Wo o d Stu d 2 in. Single wall connector or stove pipe. ( 5 1 mm) T his must be at least 2 4 gauge mild steel or 2 6 gauge blue Cl earance f ro m chimney w al l steel.

  • Page 18: Chimney Termination Req Uirements

    Is le Royale Wood Stov e D. Chimney Termination Req uirements NOTE: F ollow manufacturer’ s instructions for clearance, securing • Chimney performance may vary. flashing and terminating the chimney. • Trees, buildings, roof lines and wind conditions affect • performance.

  • Page 19: Section 6 : Mob Ile Home

    Is le Royale Wood Stov e Mob ile Home Ins tallation You mus t us e a Q uadra- F ire Outs ide Air K it P art 8 3 1 - 1 7 8 0 for ins tallation in a mob ile home. 1.

  • Page 20: Section 7 : Appliance Set- Up

    Is le Royale Wood Stov e Appliance Set- Up B . Adj us ting The B lower Speed Control A. Door Handle As s emb ly If Necessary Included in K it: 1 lock nut, 1 porcelain handle, 1 screw NOTE: W hen the speed control is turned clock wise, it will adapter, 1 gold or nick l e handle, 1 sq uare k e y, 4 spacing...

  • Page 21: Section 8 : Operating Ins Tructions

    Is le Royale Wood Stov e Operating Ins tructions B . Wood Selection and Storage A. Ov er- F iring Your Appliance WARNING WARNING F IRE RISK . F ire Ris k • DO NOT BURN GARBAGE OR FLAMMABLE Do not over-fire. FLUIDS SUCH AS GASOLINE, NAPTHA OR Over-firing may ignite creosote or will damage ENGINE OIL.

  • Page 22: B Urning P Rocess

    Is le Royale Wood Stov e Mois ture C. B urning P roces s The majority of the problems appliance owners experience In recent years there has been an increasing concern about are caused by trying to burn wet, unseasoned wood. air q uality.

  • Page 23: C Ombustible / Non- C Ombustile M Aterials

    Is le Royale Wood Stov e E. Air Controls The Primary Air Slide Control located under the ashlip ad- justs the burn rates. F igure 2 3 . 1 . Start- Up Air Sys tem The combustion air enters at the rear of the firebox through 3 .

  • Page 24: Operating The Top Loading Option

    Is le Royale Wood Stov e G . Heat Output Settings F . Operating The Top Loading Option NOTICE : SHI P P IN G B OLTS MUST B E REMOVED emis s ions , follow thes e operating procedures : P RIOR TO REMOVING G RIDDLE.

  • Page 25: Building A Fire

    Is le Royale Wood Stov e I. B uilding A F ire WARNING Before lighting your first fire make certain that the F ire Ris k . baffle is correctly positioned. It should be resting • DO NOT BURN GARBAGE OR FLAMMABLE against the rear support. FLUIDS SUCH AS GASOLINE, NAPTHA OR E NG INE O Il. There are many ways to build a fire. The basic principle • Do NO T burn treated wood or wood with salt ( driftwood) .

  • Page 26: B Lower O Perating Instructions

    Is le Royale Wood Stov e M. Clear Space J . Optional B lower Operating Ins tructions • Do NOT place combustible objects within 4 ft (1.2 m) of the front of fireplace. F igure 2 6 . 1 . 1 .

  • Page 27: Maintaining & Serv Icing Appliance

    Is le Royale Wood Stov e Maintaining & Serv icing Your Appliance 2 . As h Remov al Sys tem ( ARS) Operating and Cleaning A. G eneral Maintenance • W eek l y when in constant operation or as needed.
  • Page 28 Is le Royale Wood Stov e 3 . Dis pos al of As hes 5 . G las s Cleaning • As desired • W hen ash is within 1 - 3 /4 in. ( 4 4 mm) of firebox •...

  • Page 29: Appliance Inspection - Routine

    Is le Royale Wood Stov e D. G las s Replacement B . Appliance Ins pection - Routine Ensure that the fire is out and the appliance is cool • F req uency: E very 2 months at the same time the chim- to the touch.

  • Page 30: Q Uick Reference M Aintenance G Uide .3

    Is le Royale Wood Stov e Start the first inspection after the first 2 months of use, E. Q uick Reference Maintenance G uide or if performance changes, and adjust your schedule accordingly. M aintenance is req uired for safe operation CAU TION! Allow the appliance to completely cool and must be performed to maintain your warranty.

  • Page 31: Section 1 0 : Troub Les Hooting

    Is le Royale Wood Stov e Troub les hooting G uide W ith proper installation, operation, and maintenance your woodstove will provide years of trouble- free service. If you do experience a problem, this troubleshooting guide will assist you or a qualified service person in the diagnosis of a problem and the corrective action to be tak e n.

  • Page 32: Exploded Drawings

    Is le Royale Serv ice P arts Non- Catalytic, Top- Load, B eginning Manufacturing Date: Sept. 2 0 0 0 Wood Stov e Ending Manufacturing Date: Activ e 8 2 3 - 0 1 7 0 ( Matte B lac k ) 8 2 3 - 0 2 9 0 ( P orcelain Mahogany ) Retired Units 8 2 3 - 0 1 8 0 ( P orcelain B lac k ) ( Oct 2 0 0 0 thru Apr 2 0 0 2 )

  • Page 33: Service Parts & Accessories

    Is le Royale Serv ice P arts B eginning Manufacturing Date: Sept. 2 0 0 0 B . Serv ice P arts and Acces s ories Ending Manufacturing Date: Activ e IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stock ed parts for your appliance please provide model number and serial number.
  • Page 34 Is le Royale Serv ice P arts B eginning Manufacturing Date: Sept. 2 0 0 0 Ending Manufacturing Date: Activ e IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stock ed parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authoriz e d dealer.
  • Page 35 Is le Royale Serv ice P arts B eginning Manufacturing Date: Sept. 2 0 0 0 Ending Manufacturing Date: Activ e IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stock ed parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authoriz e d dealer.
  • Page 36 Is le Royale Serv ice P arts B eginning Manufacturing Date: Sept. 2 0 0 0 Ending Manufacturing Date: Activ e IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement Stock ed parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authoriz e d dealer.

  • Page 37: Service & Maintenance Log

    Is le Royale Wood Stov e C. Serv ice And Maintenance Log Date of Serv ice P erformed B y Des cription of Serv ice M arch 2 1 , 2 0 1 3 2 5 0 - 5 7 6 3 F P age 3 7...

  • Page 38: Warranty P Olicy

    Is le Royale Wood Stov e D. Warranty P olicy P age 3 8 2 5 0 - 5 7 6 3 F M arch 2 1 , 2 0 1 3...
  • Page 39 Is le Royale Wood Stov e M arch 2 1 , 2 0 1 3 2 5 0 - 5 7 6 3 F P age 3 9...

  • Page 40: Contact Information

    CONTACT INFORMATION: Hearth & Home Technologies 1 4 4 5 North Highway Colv ille, WA 9 9 1 1 4 Div is ion of HNI INDUSTRIES P leas e contact your Q uadra- F ire dealer with any q ues tions or concerns . F or the numb er of your neares t Q uadra- F ire dealer, call 1 - 8 0 0 - 9 2 6 - 4 3 5 6 or log on to CAUTION...

This manual is also suitable for:

Isle royale 823-0290-pmh

Table of Contents