Table Of Contents - Temptek CF Series Instruction Manual

CF Series Portable Chillers with CF-1 Instrument

TABLE OF CONTENTS

1.0 General
1.1 Introduction
1.2 Unit Location
1.3 Efficiency
1.4 Safety
1.5 Clean Air Act
1.6 Miscellaneous
2.0 Installation
2.1 General
2.2 To And From Process Connections
2.3 Water Supply Connection
2.4 Air-cooled condenser
2.5 Water-Cooled Condenser
2.6 Electrical Connection
3.0 Operations
3.1 General
3.2 Start Up/Operations Procedure
3.3 Instrument/Operation
3.4 Shut Down Procedure
4.0 Troubleshooting
4.1 Unit Will Not Start
4.2 Compressor Hums But Will Not Start
4.3 Shuts Off On High Pressure
4.4 Shuts Off On Low Pressure
4.5 Compressor Shuts Off On Internal Overload
4.6 Low Or No Process Pressure Or Water Flow
4.7 Cooling Capacity Inadequate
4.8 Sensor
4.9 Coolant Pump
4.10 Crankcase Heater
4.11 Chiller Controller
5.0 MAINTENANCE
5.1 Warranty Service Procedure
5.2 Periodic Preventative Maintenance
5.3 Special Maintenance
5.4 Solenoid Valve Service
5.5 Pump Seal Service
5.6 Checking The Refrigerant Charge
5.7 Proper Cleaning Procedure For Brazed Plate Evaporators
6.0 Components
6.1 Water System
6.2 Refrigeration System
525 East Stop 18 Road Greenwood, Indiana 46142
317-887-6352 Fax: 317-881-1277
Service Department Fax: 317-885-8683
Website: www.Temptek.com
Email: service@Temptek.com
7
8
8
8
9
9
9
13
14
14
15
15
17
18
21
22
23
26
30
31
32
32
32
33
34
34
34
35
35
35
35
37
38
38
39
40
42
45
45
47
48
48
Page: 4