Table Of Contents - Heat & Glo XLR-N-AU Owner's Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
A. Congratulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
B. Limited Lifetime Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 6
1 Listing and Code Approvals
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
B. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . . 9
C. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 9
D. Non-Combustible Materials Specification. . . . . . . . . . . . . . 9
E. Combustible Materials Specification . . . . . . . . . . . . . . . . . 9
F. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
User Guide
2 Operating Instructions
A. Gas Fireplace Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
B. Your Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
C. Clear Space . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
D. Decorative Doors and Fronts . . . . . . . . . . . . . . . . . . . . . . 11
E. Decorative Media Options . . . . . . . . . . . . . . . . . . . . . . . . 11
F. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
G. Remote Controls, Wall Controls and Wall Switches . . . . . 11
H. Before Lighting Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . 11
I. Control Module Operation . . . . . . . . . . . . . . . . . . . . . . . . 12
J. Lighting Instructions (IPI) . . . . . . . . . . . . . . . . . . . . . . . . . 13
K. After Fireplace is Lit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
L. Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . 14
3 Maintenance and Service
A. Maintenance Tasks-Homeowner . . . . . . . . . . . . . . . . . . . 15
B. Maintenance Tasks-Qualified Service Technician . . . . . . 16
4 Getting Started
Installer Guide
A. Typical Appliance System. . . . . . . . . . . . . . . . . . . . . . . . . 17
B. Design and Installation Considerations . . . . . . . . . . . . . . 18
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . 18
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . 18
5 Framing and Clearances
A. Selecting Appliance Location . . . . . . . . . . . . . . . . . . . . . . 19
B. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 20
C. Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
D. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 21
4
Table of Contents
Heat & Glo • XLR-N-AU, XLR-PB-AU • 2198-906 Rev. M • 5/12
6 Termination Locations
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 22
7 Vent Information and Diagrams
A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
B. Vent Table Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
C. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
D. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
E. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
8 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 31
B. Wall Penetration Framing . . . . . . . . . . . . . . . . . . . . . . . . . 31
C. Install the Ceiling Firestop . . . . . . . . . . . . . . . . . . . . . . . . 32
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 33
9 Appliance Preparation
A. Top Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
B. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 35
C. Installing the Optional Heat-Zone®-240V Kit . . . . . . . . . . 35
10 Installing Vent Pipe (SLP Pipe)
A. Assemble Vent Sections. . . . . . . . . . . . . . . . . . . . . . . . . . 36
B. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 37
C. Secure The Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . 37
D. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 38
E. Install Decorative Ceiling Components . . . . . . . . . . . . . . 38
F. Install Metal Roof Flashing . . . . . . . . . . . . . . . . . . . . . . . . 39
G. Assemble and Install Storm Collar . . . . . . . . . . . . . . . . . . 39
H. Install Vertical Termination Cap . . . . . . . . . . . . . . . . . . . . 40
I. Install Decorative Wall Components . . . . . . . . . . . . . . . . 40
J. Heat Shield Requirements for Horizontal Termination . . . 40
K. Install Horizontal Termination Cap . . . . . . . . . . . . . . . . . . 41
11 Gas Information
A. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . 42
B. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

C. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 43
12 Electrical Information
A. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
B. IntelliFire Plus™ Ignition System Wiring . . . . . . . . . . . . . 44
C. Optional Accessories Requirements . . . . . . . . . . . . . . . . 44
D. Electrical Service and Repair . . . . . . . . . . . . . . . . . . . . . . 45
E. Junction Cord Information . . . . . . . . . . . . . . . . . . . . . . . . 45