Table of Contents
Advertisement
TAbLE OF CONTENTS
Packaging .........................................Page 2
Introduction ......................................Page 2
General Information ..........................Page 2
Massachusetts and New York
Requirements ................................Page 4
Cold Climate Insulation .....................Page 5
Manufactured Home Requirements ..Page 5
Location ............................................Page 5
Vent Termination Clearances ............Page 6
Appliance and Vent Clearances ........Page 7
Detailed Installation Steps ................Page 8
Typical Installation Sequence ...........Page 8
Step 1. Framing ..............................Page 8
Framing Specifications ......................Page 9
Fireplace Specifications .....................Page 10
Step 2. Routing Gas Line ................Page 11
Step 3. Install the Venting System..Page 12
Step 4. Field Wiring ........................Page 13
Step 5. Optional Forced Air Blower .Page 14
Step 6. Connecting Gas Line ..........Page 14
Step 9. Install Grate, Vermiculite
Panels ...............................Page 21
Step 11. Burner Adjustment .............Page 22
Step 12. Vent Operation Test and Safety
Limit Switch Operation ..................Page 23
Step 13. Hood Installation ................Page 24
Finishing Requirements ....................Page 24
Gas Conversion Kits .........................page 26
please read and understand these
instructions before beginning your
installation.
2
pACKAGING LIST
The assembled vented gas fireplace is pack-
aged with:
1 - One log set located in firebox area.
2 - One envelope containing the literature pack-
age which consists of the care and operation
manual, installation instructions, safety in
operation warning labels and warranty;
envelope is located in the control area.
3 - One hood located behind the top panel.
4 - One bag of decorative volcanic stone located
in the control area.
5 - One bag of glowing embers (rockwool)
located in the control area.
INTROdUCTION
The Millivolt appliances have a millivolt gas
control valve with piezo ignition system. If any
optional accessories which require electrical
power are being installed, the electrical power
must be provided at the time of appliance
installation.
The Electronic appliances have an electronic
intermittent pilot ignition system. External
electrical power is required to operate these
units.
Use Only These Approved Vent Components
- These vented gas fireplaces are designed for
residential applications. They must be installed
with approved Type-B, double wall vent pipe
systems and a listed vent termination routed
to the outside atmosphere. Use only the proper
size listed below.
Required pipe diameter:
mpb-3328 series: Requires 4 in. (102 mm)
mpb-3530 series: Requires 5 in. (127 mm)
mpb-4035 series: Requires 5 in. (127 mm)
mpb-4540 series: Requires 6 in. (152 mm)
GENERAL INFORmATION
WARNING
b-Vent appliances are not
designed to operate in negatively
pressured environments (pres-
sure within the home is less than
pressures outside). Significant
negatively pressured environ-
ments caused by weather, home
design, or other devices may
impact the operation of these
appliances.
Negative pres-
sures may result in poor flame
appearance, sooting, damage to
property and/or severe personal
injury. do not operate these
appliances in negatively pres-
sured environments.
WARNING
Young children should be care-
fully supervised when they are
in the same room as the appli-
ance. Toddlers, young children
and others may be susceptible
to accidental contact burns. A
physical barrier is recommended
if there are at risk individuals in
the house. To restrict access to
a fireplace or stove, install an
adjustable safety gate to keep
toddlers, young children and
other at risk individuals out of
the room and away from hot
surfaces.
AVERTISSEmENT
Les jeunes enfants devraient être
surveillés étroitement lorsqu'ils
se trouvent dans la même pièce
que l'appareil. Les tout petits,
les jeunes enfants ou les adultes
peuvent subir des brûlures s'ils
viennent en contact avec la sur-
face chaude. Il est recommandé
d'installer une barrière physique
si des personnes à risques habi-
tent la maison. pour empêcher
l'accès à un foyer ou à un poêle,
installez une barrière de sécu-
rité; cette mesure empêchera les
tout petits, les jeunes enfants et
toute autre personne à risque
d'avoir accès à la pièce et aux
surfaces chaudes.
Children and adults should be alerted to the
hazards of high surface temperature and
should stay away to avoid burns or clothing
ignition.
Les enfants et les adultes devraient être infor-
més des dangers que posent les températures
de surface élevées et se tenir à distance afin
d'éviter des brûlures ou que leurs vêtements
ne s'enflamment.
dO NOT ATTEmpT TO ALTER OR mOdIFY
THE CONSTRUCTION OF THE AppLIANCE OR
ITS COmpONENTS. ANY mOdIFICATION OR
ALTERATION mAY VOId THE WARRANTY, CER-
TIFICATION ANd LISTINGS OF THIS UNIT.
Advertisement
Table of Contents
