Page 1
Ultra-Portable Oil- Operating Instructions Fired Radiant Heater Model #: HH-70-SS-A CONSUMER: Retain this manual for future reference. IMPORTANT: Read and understand all of the directions in this manual before assembling, starting, or servicing the heater. Improper use of this heater can cause serious injury. Keep this manual for future reference.
Ultra-Portable Oil- Fired Radiant Heater Warnings..............2 Safety Information..........2-3 Specifications ............3 This is a kerosene, direct-fired, forced air heater. It is Features ..............4 primarily intended for use for temporary heating of buildings Theory of Operation ..........5 under construction, alteration or repair.
- Operate heater in a manner that will not directly expose severe burns may result. it to water, rain or dripping water. Specifications Model # HH-70-SS-A Rating BTU/Hr 70,000 Volts / Hz AC 120V / 60 Hz Fuel Consumption (Gal/Hr)
NEVER LEAVE HEATER Ultra-Portable Oil- UNATTENDED WHILE BURN- ING, OR WHILE CONNECTED Fired Radiant Heater TO A POWER SOURCE. Features Handle Shell Ring Shell Heat Plate Lamp Safety Operating Switch Guard Back Cover Electrical Outlet Cooling Fan Outlet Housing Cover Power Cord Fuel Gauge Fuel Tank...
It is always a good idea to fire the heater outdoors for the first time. This will allow any oils used in the manufacturing process to be burned off in a safe environment. This initial burn should last at least 10 minutes. HH-70-SS-A Attaching the handle...
(2,800 sq. cm) for each 100,000 BTU/Hr. of 3. Be sure to follow all starting procedure precautions. heater output. Provide a larger opening if more heaters are being used. As an example, an HH-70-SS-A heater will Electrical Outlet require:...
NEVER LEAVE HEATER Ultra-Portable Oil- UNATTENDED WHILE BURN- ING, OR WHILE CONNECTED Fired Radiant Heater TO A POWER SOURCE. Maintenance (Continued) Spark Plug - Clean and re-gap every 600 hours of operation, or replace as needed. Fan Blades - After removing the Spark Plug, clean the terminals with Never service heater while hot or still WARNING a wire brush.
NEVER LEAVE HEATER Ultra-Portable Oil- UNATTENDED WHILE BURN- ING, OR WHILE CONNECTED Fired Radiant Heater TO A POWER SOURCE. Exploded Drawing Part Breakdown Figure 11. Exploded View: HH-70-SS-A Replacement Parts Item # Description HH-70-SS-A FUEL TANK ASSEMBLY 75-001-0350 OIL FILTER ASSEMBLY...
NEVER LEAVE HEATER Ultra-Portable Oil- UNATTENDED WHILE BURN- ING, OR WHILE CONNECTED Fired Radiant Heater TO A POWER SOURCE. Replacement Parts Item # Description HH-70-SS-A IGNITOR 75-025-0120 MAIN PCB ASSEMBLY 75-025-0400 TIP OVER SENSOR 75-051-0200 TIP OVER SENSOR WIRE ASSENBLY 75-051-0260...
Ultra-Portable Oil- UNATTENDED WHILE BURN- ING, OR WHILE CONNECTED Fired Radiant Heater TO A POWER SOURCE. Wiring Diagrams Figure 12. Wiring Diagram for model HH-70-SS-A (subject to change without notice) Page 10 Pinnacle Products International, Inc. Ultra-Portable Kerosene User’s Manual...
NEVER LEAVE HEATER Ultra-Portable Oil- UNATTENDED WHILE BURN- ING, OR WHILE CONNECTED Fired Radiant Heater TO A POWER SOURCE. Trouble Shooting Guide Problem Possible Cause Solution Heater fires, but shuts down after a 1. Dirty Fuel Filter. 1. Clean/replace Fuel Filter (Page 6). short period of time.
NEVER LEAVE HEATER Ultra-Portable Oil- UNATTENDED WHILE BURN- ING, OR WHILE CONNECTED Fired Radiant Heater TO A POWER SOURCE. LIMITED 1-YEAR WARRANTY AFTER THE PERIOD OF THE ONE (1) YEAR EXPRESS WARRANTY EXPIRES, Pinnacle Products International, Pinnacle Products International, Inc. warrants this Inc.