Bajaj Pulsar 135 LS User Manual page 27

Periodic Maintenance / Lubrication Chart
Sr.
Operation
No.
33. Drive chain 'O' ring type (If applicable)
34. Drive chain remove, clean, insp. & lubricate (O/H)
35. Drive chain link lock
36. Wheel bearing (for non sealed bearings only)
37. Tyre tread wear (replace if worn out till TWI limit)
38. Front fork oil
39. Auto choke, Thermal sensor (If applicable)
40. TPS (If applicable)
41. RSA - Check gas pressure (If applicable)
42. Starter clutch bush kit (If applicable)
43. Clutch switch cleaning (If applicable)
44. General lubrication
45. Swing arm pivot pin lubrication
46. Engine foundation silent bush (If applicable)
C : Check, A : Adjust, CL : Clean, R : Replace, T : Tighten, L : Lubricate
Note : Parts / Lubricants to be replaced as per Periodic Maintenance and Lubrication Chart are mandatory and the same are chargeable to
customer.
RECOMMENDED FREQUENCY
Servicing 1st 2nd 3rd
Kms 750 5000 10000
L At every 500 Kms
CL, L CL, L
R R
C, L
C, R C, R
R
C, A C, A C, A C, A
C, A C, A C, A C, A
C, A
CL, R
CL CL
L L L L
L
R
4th 5th 6th 7th
15000 20000 25000 30000
CL, L CL, L At every 10000 Kms
R R Replace at every 10000 Kms
C, L At every 20000 Kms
C, R C, R C, R C, R At every 5000 kms i.e. at
every service after 2nd service
R Replace at every 20000 Kms
C, A C, A C, A C, A At every 5000 Kms
C, A C, A C, A C, A At every 5000 Kms
C, A At every 20000 Kms.
CL, R CL, R
CL CL
L L L L
L Lubricate at every 20000 Kms
R R Replace at every 15000 Kms
24