Table of Contents
Advertisement
Quick Links
Operator's Manual
4x2 Utility Vehicle
Model 414
IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning:
This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-
covered, brush-covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting
applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.
In the State of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have
similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized
service dealer or contact the service department.
CUB CADET LLC P.O. BOX 361131 CLEVELAND, OHIO 44136-0019
769-01129.fm
PRINTED IN U.S.A.
FORM NO.
(2/04)
Advertisement
Table of Contents
Related Manuals for Cub Cadet 414
Summary of Contents for Cub Cadet 414
- Page 1 Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department. CUB CADET LLC P.O. BOX 361131 CLEVELAND, OHIO 44136-0019 769-01129.fm PRINTED IN U.S.A.
-
Page 2: Table Of Contents
Customer Dealer Referral Line or an authorized service dealer. Copy the model number here: Copy the serial number here: CUB CADET LLC P. O. BOX 361131 www.cubcadet.com CLEVELAND, OH 44136... -
Page 3: Important Safe Operation Practices
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate or service this vehicle. When you see this symbol - heed its warning. -
Page 4: Slope Operation
Children 25. Do not start or operate vehicle in an inside area, unless it is adequately ventilated. Engine exhaust 1. Tragic accidents can occur if the operator is not contains carbon monoxide fumes, which are very alert to the presence of children. Children are often poisonous and can be deadly. - Page 5 3. Do not operate vehicle with cargo box in raised c. When practical, remove gas-powered position. equipment from the truck or trailer and refuel 4. Do not operate vehicle with cargo box latch it on the ground. If this is not possible, then unlatched.
- Page 6 AVOID INJURY WHEN USING CARGO BOX LIFT CARGO BOX Read and understand operator's manual for lifting, loading Always re-latch cargo box latch upon and unloading instructions. manually lowering cargo box. Stop vehicle on level ground and set parking brake before operating lift. Do not operate or load vehicle with cargo When using optional electric lift stay in seat and keep hands box latch unlatched.
-
Page 7: Know Your Utility Vehicle
SECTION 2: KNOW YOUR UTILITY VEHICLE NOTE: Reference to right or left hand side of the utility vehicle is observed from the operating position. Figure 1 Brake Pedal Read this operator’s manual, safety labels, and operating instructions on the vehicle before operating. The brake pedal is located on the left side of the floor Compare the illustrations in this manual with your unit beneath the dash panel. -
Page 8: Ignition Switch
Horn Switch • To engage the parking brake, push brake pedal (Optional) down firmly, pull out on the parking brake latch, and The horn switch is located on the right side of the dash release foot from brake pedal. Brake pedal will stay panel. -
Page 9: Hour Meter
Hour Meter Adjustable Seat Lever The hour meter is located in the center of the warning The adjustable seat lever is located beneath the light cluster. It reads the elapsed time engine has run. driver’s seat on the front side and it is used to move the See Figure 6. -
Page 10: Operating Your Utility Vehicle
SECTION 3: OPERATING YOUR UTILITY VEHICLE Starting Engine WARNING: This is an off-road utility vehicle and it should not be operated on public • Sit in the operator’s seat and place key switch in highways. Know and comply with all laws and STOP position. - Page 11 Operating The Headlights • Lift cargo box. To turn the utility vehicle’s headlights on: • Start the engine following the instructions earlier in this section. • Turn the key one notch counterclockwise into the On/Lights position of the ignition switch. Refer to Figure 4.
-
Page 12: Servicing Your Utility Vehicle
Towing Loads If dumping by electric lift, stop immediately IMPORTANT: if actuator clutch slippage occurs. Lower cargo box completely and remove excess load by hand before WARNING: To help prevent personal injury dumping. due to loss of control or tipping, always tow a load slowly enough to maintain control. - Page 13 • Connect negative (-) jumper cable to booster battery negative (-) post (C). • Connect the other end (D) of negative (-) jumper cable to a metal part of the disabled machine frame away from battery. • Start the engine of the disabled machine and run machine for several minutes.
-
Page 14: Tire Pressure
Fuses Front Wheels • Stop the vehicle on a level surface and apply • Raise hood to get access to under the dash panel. parking brake. • Remove the appropriate electrical fuse and replace • Turn the ignition key to the STOP position and with proper amperage fuse. -
Page 15: Drive Belt
• Remove oil cap and add approximately 22 oz of 80- satisfactory brake performance is obtained and 90 Weight Oil. equalizer is level. See Figure 19. • Install oil cap, and lower and latch cargo box. Equalizer Bracket Drive Belt Brake WARNING: Fingers or loose clothing can get Adjustment Nut... -
Page 16: Service Chart
Cleaning • Lubricate grease points. • Replace fuel filter if needed. See engine manual. The body panels are scratch and impact resistant • Change engine oil and filter. See engine manual. automotive quality ABS plastic. The use of standard car •... -
Page 17: Accessories
SECTION 6: ACCESSORIES NOTE: Some of these accessories may come already equipped on your vehicle. If they are not equipped, they Description Model Number may be ordered through your local Cub Cadet service Electric Bed Lift 39A-126-100 dealer. Manual Bed Lift... -
Page 18: Troubleshooting
Engine operated too long at slow engine speed. NOTE: For repairs beyond minor adjustments or corrections, contact your nearest Cub Cadet service dealer or call 1-877-282-8684. If you would like to order a Service Manual, please call the Publications Department at 800-800-... - Page 19 ELECTRONIC SHIFT MODULE – FAULT CODE LIST If your unit does not shift properly, the ESM will let you know there is a problem using the following table of fault codes. Once you select a gear, the instrument panel will illuminate a gear light, or a combination of gear lights.
- Page 20 FAULT CODES DEFINED Code 1: “REVERSE” and “NEUTRAL” lights flash Action A - Vehicle is in “FORWARD” and operator attempts a shift to “NEUTRAL” • This lets the operator know the vehicle was supposed to go to neutral, but probably ended up in reverse. The vacuum actuator probably shifted the transmission into reverse because the signal to stop at neutral was not present.
- Page 21 NOTES...
- Page 22 NOTES...
-
Page 23: Commercial Warranty
CUB CADET CORPORATION MANUFACTURER’S ONE YEAR LIMITED WARRANTY (COMMERCIAL USE) The limited warranty set forth below is given by CUB CADET CUB CADET does not extend any warranty for LLC (“CUB CADET”) with respect to new merchandise products sold or exported outside of the United... -
Page 24: Residential Warranty
MANUFACTURER’S LIMITED WARRANTY FOR: (RESIDENTIAL USE) The limited warranty set forth below is given by Cub Cadet possessions and territories, except those sold through LLC with respect to new merchandise purchased and used in Cub Cadet’s authorized channels of export the United States, its possessions and territories.
Need help?
Do you have a question about the 414 and is the answer not in the manual?
Questions and answers