Table of Contents
Advertisement
Quick Links
Safety • Assembly • Operation • Tips & Techniques • Maintenance • Troubleshooting • Parts Lists • Warranty
OPERATOR'S MANUAL
4x2 Utility Vehicle — Models 435A & 435D
IMPORTANT
READ SAFETY RULES AND INSTRUCTIONS CAREFULLY BEFORE OPERATION
Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-
covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).
If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required by law
(Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester
for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131 Cleveland,
Ohio 44136-0019.
CUB CADET LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019
FORM NO. 769-01878A
PRINTED IN U.S.A.
2/3/2006
Advertisement
Table of Contents
Related Manuals for Cub Cadet 435A
Summary of Contents for Cub Cadet 435A
- Page 1 Safety • Assembly • Operation • Tips & Techniques • Maintenance • Troubleshooting • Parts Lists • Warranty OPERATOR’S MANUAL 4x2 Utility Vehicle — Models 435A & 435D IMPORTANT READ SAFETY RULES AND INSTRUCTIONS CAREFULLY BEFORE OPERATION Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush- covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).
-
Page 2: Table Of Contents
If you have difficulty assembling this product or have any questions regarding the controls, operation or maintenance of this unit, contact the retailer from which you purchased this vehicle. To find a Cub Cadet Dealer nearest you choose from the options below: 1. - Page 3 Labels To order any of these labels, contact your nearest Cub Cadet service dealer or call 1-877-282-8684.
-
Page 4: Safe Operation Practices
WARNING: Engine Exhaust, some of its constituents, and certain vehicle compo- nents contain or emit chemicals known to State of California to cause cancer and birth defects or other reproductive harm. DANGER: This vehicle is designed to be operated according to the rules for safe operation in this Safe manual. - Page 5 Do Not: c. Do not allow rear wheels to hang over the edge of a drop-off when raising cargo box. The load in the cargo 1. Do not travel near drop-offs, ditches or embankments. The box may shift causing the vehicle to tip over backwards. vehicle could suddenly turn over if a wheel is over the edge of a cliff, ditch, or if an edge caves in.
-
Page 6: Know Your Utility Vehicle
Know Your Utility Vehicle NOTE: Reference to right or left hand side of the utility vehicle is observed from the operating position. KnowYour Utility Vehicle Parking Brake Differential Choke Latch Lock Switch Knob Figure 1 WARNING Brake Pedal Read this operator’s manual, safety labels, and operating instructions on the vehicle before operating. -
Page 7: Hour Meter
Rear Power Outlet Switch (Optional) KnowYour Utility Vehicle Cargo Box Electric Gear Lights Lift Switch (Optional) The gear lights are located on the right side of the dash panel. See Figure 3. Once a gear is selected, a gear light, or a combination of gear lights, will illuminate. If the vehicle has not shifted properly, or there is a shifting issue, the lights will flash for 5 seconds and an audible Figure 3... - Page 8 in serious personal injury or death. locked position prior to operation and do not try to adjust the seat position while operating the vehicle. Fuel Shut Off Valve Cargo Box The fuel shut off valve is located under the seat and it is strapped onto the fuel tank.
-
Page 9: Operating Your Utility Vehicle
Operating Your Utility Vehicle WARNING: This is an off-road utility vehicle and it should not be operated on public highways. Know and comply with all laws and regulations governing the use of off-highway vehicles in your area. IMPORTANT: Before starting the engine read this manual and the Kohler Engine manual thoroughly to understand Operation all instructions. - Page 10 4. Release brake pedal and apply pressure to the Manual Lift accelerator pedal. 1. Park the vehicle safely on level ground and set parking 5. Release accelerator and apply brake pedal evenly brake. and firmly to slow down or stop. 2.
- Page 11 Towing Loads Dumping Load From Cargo Box WARNING: To help prevent personal injury due to loss of control or tipping, 1. Back up the vehicle to the dump site and apply always tow a load slowly enough to parking brake. maintain control.
-
Page 12: Servicing Your Utility Vehicle
Clean Battery and Terminals Lubrication 1. Remove battery from vehicle. Always remove negative Front Axle Lubrication cable first when disconnecting. 1. Lubricate one grease fitting on each axle with 2 or 3 2. Wash battery with solution of four tablespoons of shots of grease every 50 hours. -
Page 13: Rear Wheels
If the vehicle has not been put into use for an extended NOTE: For high loads 8-10 psi is recommended for all period of time, charge the battery with an automotive type tires. The recommended tire pressure while using the 12-volt charger for a minimum of one hour at six amps. -
Page 14: Drive Belt
5. Check O-ring on drain plug and replace if missing or in poor condition. 6. Install and tighten drain plug. IMPORTANT: Dirt and debris in oil may cause damage to transaxle. Clean area around opening before removing Servicing Your oil cap. 7. -
Page 15: Adjusting Brake
Adjusting Brake To adjust the brakes: 1. Stop the vehicle on a level surface. 2. Turn the ignition key to the STOP position and remove Brake Switch the key. Servicing Your Actuator Bolts 3. Make sure the parking brake is released and the Utility Vehicle vehicle is in neutral. -
Page 16: Service Chart
Bed Lift Adapter Kit 39A-127-100 or log onto Universal Spreader Mounting Bracket 39A-130-100 www.cubcadet.com NOTE: Some of these accessories may come already equipped on your vehicle. If they are not equipped, they may be ordered through your local Cub Cadet service dealer. -
Page 17: Specifications
Headlights Two, 37.5 Watt Halogen accessories, contact Brake Type 7” Self-Adjusting Drum (Rear Only) Wiring Automotive- your local Cub Cadet Style Fused Control System Parking Brake Foot Operated Suspension Front - Fully Independent A-Arms dealer. To locate the Steering Rack & Pinion... -
Page 18: Shift Fault Codes
ELECTRONIC SHIFT MODULE – FAULT CODE LIST If your unit does not shift properly, the ESM will let you know there is a problem using the following table of fault codes. Once you select a gear, the instrument panel will illuminate a gear light, or a combination of gear lights. These lights can be used to determine if the vehicle shifted properly, or if there is a shifting issue. - Page 19 FAULT CODES DEFINED Code 1: “REVERSE” and “NEUTRAL” lights flash Action A - Vehicle is in “FORWARD” and operator attempts a shift to “NEUTRAL” • This lets the operator know the vehicle was supposed to go to neutral, but probably ended up in reverse. The vacuum actuator probably shifted the transmission into reverse because the signal to stop at neutral ELECTRONIC was not present.
-
Page 20: Troubleshooting
Loose or corroded electrical connections. Stale or improper fuel. or corrections, Choke not being used or adjusted incorrectly. contact your nearest Cub Cadet service Faulty spark plug. Engine misses dealer or call Stale or dirty fuel. under load 1-877-282-8684. - Page 21 Low battery output. minor adjustments Sulfated or worn-out battery. or corrections, Engine oil too heavy. contact your nearest Loose or corroded connections. Cub Cadet service dealer or call Blown fuse. Entire electrical system 1-877-282-8684. Loose or corroded connections. does not work Sulfated or worn-out battery.
-
Page 22: Warranty
CADET DEALER. To locate the dealer in your area, please check for features of the product shall void this Warranty. You assume the a listing in the Yellow Pages or contact Cub Cadet LLC at P.O. Box risk and liability for loss, damage, or injury to you and your property... - Page 23 MANUFACTURER’S LIMITED WARRANTY FOR The limited warranty set forth below is given by Cub Cadet LLC with e. Replacement parts that are not genuine Cub Cadet parts. respect to new merchandise purchased and used in the United States, its f. Service completed by someone other than an authorized service possessions and territories.
- Page 24 Cub Cadet LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019; Phone: 1-877-282-8684...