Volvo 780 Owner's Manual page 86

1987 Volvo 780
touching up is as follows:
Remove paint flakes.
Sand the damaged surface and wash it clean with thinner.
Apply the rust remover. (avoid contact with skin!). Wait a few minutes and then rinse carefully with
water and wipe dry.
Shake the spray can for at least 1 minute. Spray on the primer. Move the spray can slowly and evenly
back and forth over the spot, about 8-12 inches (20-30 cm) from the surface. Protect the surrounding
surfaces with suitable paper.
NOTE:
Spray painting should be done in a well ventilated and dust-free area.
When the primer has dried apply the surface enamel in the same way. Spray on several times and
allow the paint to dry a minute or so between each application.
pg. 84 Washing
Washing the car
The car should be washed at regular intervals since dirt, dust, insects and tar spots adhere to the paint
and may cause damage.
When washing the car, do not expose it to direct sunlight. Use lukewarm water to soften the dirt before
you wash with a sponge, and plenty of water, to avoid scratching.
A detergent can be used to facilitate the softening of dirt and oil. A water-soluble grease solvent may be
used in cases of sticky dirt. However, use a wash place equipped with a drainage separator. Dry the car
with a clean chamois and remember to clean the drain holes in the doors and rocker panels.
Tar spots can be removed with kerosene or tar remover after the car has been washed.
After washing, lubricate the electrically-operated antenna mast with a cloth soaked in oil.
A stiff-bristle brush and lukewarm soapy water can be used to clean the wiper blades. Frequent cleaning
improves visibility considerably.
Note:
file:///K|/ownersdocs/1987/1987_780/87780_06.htm (6 of 9)12/30/2006 7:56:30 AM