Volvo 780 Owner's Manual page 84

1987 Volvo 780
Minor scratches can be repaired by using Volvo touch-up paint.
NOTE: When ordering touch-up paint from your Volvo dealer, use the paint code indicated on the
model plate. The plate is located on the panel above the right-side head lights.
Minor stone chips and scratches
Material:
Rust remover
Primer - brush-on type
Surface finish - brush-on type
Penknife or similar
Brush
Note: When touching up the car, it should be clean and dry. The surface temperature should be above
60°F (+15°C).
Scratches on the surfaces (where the paint has not been completely penetrated). Repairs can be made
directly after light scraping to remove dirt.
Deep scratches (down to the bare metal):
1 Scrape or sand the damaged surface lightly and bevel the edges of the scratch.
Apply the rust remover. (Avoid contact with eyes and skin!) Wait a few minutes then rinse carefully
with water and wipe dry.
2 Thoroughly mix the primer and apply it with a small brush.
file:///K|/ownersdocs/1987/1987_780/87780_06.htm (4 of 9)12/30/2006 7:56:30 AM