Volvo 780 Owner's Manual page 77

1987 Volvo 780
pg. 75 Service diagnosis
This section contains information which can be of help in the event of a breakdown.
Only those faults which can be rectified with the vehicle's tool kit are listed.
The engine does not start or is difficult to start
The instructions for starting the engine have not been followed.
Follow the instructions in section "Starting the engine".
The battery is poorly charged or dead
Start the vehicle by using an auxiliary battery.
Recharge the battery.
Find out why the battery is poorly charged.
Poor contact in the electrical system
Check all leads to spark plugs, coil, distributor, battery and starter motor.
No fuel reaching engine
Check that there is fuel in the tank.
Check that none of the hoses in the fuel system are loose.
Check that the fuses for the fuel pump are not faulty, fuses No. 1 and 11.
Faulty ignition system
Check spark plugs, electrode gap should be 0.028" (0.7 mm), and wipe clean.
Check distributor cap for cracks and wipe clean on inside.
Check that all electric leads in the ignition system are clean and correctly connected.
Misfiring and erratic engine operation
Faulty ignition system
Check spark plugs, electrode gap should be 0.028" (0.7 mm), and wipe clean.
Check distributor cap for cracks and wipe clean on inside.
Check that all electric leads in the ignition system are clean and correctly connected.
Ice in injection system
Park the vehicle in a warm garage and add a fuel line de-icer to the fuel system.
Blocked air filter/fuel filter
file:///K|/ownersdocs/1987/1987_780/87780_05.htm (17 of 20)12/30/2006 7:56:29 AM