Download Print this page

Maytag MDG-50 Installation Manual

American dryer mdg-50 corporation installation manual
Hide thumbs Also See for MDG-50:

Advertisement

Quick Links

Installation Manual
WARNING: For your safety the
information in this manual must be
followed to minimize the risk of fire or
explosion or to prevent property damage,
personal injury or death.
Do not store or use gasoline or other flammable
vapor and liquids in the vicinity of this or any
other appliance.
WHAT DO YOU DO IF YOU SMELL GAS
* Do not try to light any appliance.
* Do not touch any electrical switch; do not use
any phone in your building.
* Clear the room, building or area of all
occupants.
* Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
* If you cannot reach your gas supplier, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
122298SL/cj
MDG-50
AVERTISSEMENT: Assurez-vous de bien
suivre les instructions données dans cette
notice pour réduire au minimum le risque
d'incendie ou d'explosion ou pour éviter tout
dommage matériel, toute blessure ou la mort.
Ne pas entreposer ni utiliser d'essence ni
d'autres vapeurs ou liquides inflammables dans
le voisinage de cet appareil ou de tout autre
appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
* Ne pas tenter d'allumer d'appareil.
* Ne touchez à aucun interrupteur. Ne pas
vous servir des téléphones se trouvant dans
le bâtiment où vous vous trouvez.
* Évacuez la pièce, le bâtiment ou la zone.
* Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
* Si vous ne pouvez rejoindre le fournisseur
de gaz, appelez le service des incendies.
L'installation et l'entretien doivent être assurés
par un installateur ou un service d'entretien
qualifié ou par le fournisseur de gaz.
For replacement parts, contact the distributor from which the dryer
was purchased or contact:
403 West Fourth St North
Newton, Iowa 50208
Maytag Co.
(515) 787-7000
Part No. 113067

Advertisement

loading

Summary of Contents for Maytag MDG-50

  • Page 1 Installation and service must be performed by a qualified installer, service agency or the gas supplier. 122298SL/cj MDG-50 AVERTISSEMENT: Assurez-vous de bien suivre les instructions données dans cette notice pour réduire au minimum le risque d’incendie ou d’explosion ou pour éviter tout dommage matériel, toute blessure ou la mort.
  • Page 2: Pour Votre Sécurité

    403 West Fourth St North Newton, Iowa 50208 (515) 787-7000 “IMPORTANT NOTE TO PURCHASER” POUR VOTRE SÉCURITÉ Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de yout autre appareil. MDG-50...
  • Page 3: For Your Safety

    YOU MUST DISCONNECT and LOCKOUT THE ELECTRIC SUPPLY and THE GAS SUPPLY BEFORE ANY COVERS or GUARDS ARE REMOVED FROM THE MACHINE TO ALLOW ACCESS FOR CLEANING, ADJUSTING, INSTALLATION, or TESTING OF ANY EQUIPMENT per OSHA (Occupational Safety and Health Administration) STAN- DARDS.
  • Page 4 The dryer must never be operated with any of the back guards, outer tops, or service panels removed. PERSONAL INJURY or FIRE COULD RESULT. DRYER MUST NEVER BE OPERATED WITHOUT THE LINT FILTER and SCREEN IN PLACE, EVEN IF AN EXTERNAL LINT COLLECTION SYSTEM IS USED. PLEASE OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment and specified in the installation and operator's manual included with the dryer.
  • Page 5 Table of Contents SECTION I IMPORTANT INFORMATION ... 3 A. Receiving and Handling ... 3 B. Safety Precautions ... 4 SECTION II SPECIFICATIONS ... 6 A. Specifications ... 6 SECTION III INSTALLATION PROCEDURES ... 8 A. Unpacking and Setting Up ... 8 B.
  • Page 6 SECTION VI ROUTINE MAINTENANCE ... 35 A. Cleaning ... 35 B. Adjustments ... 36 C. Lubrication ... 36 SECTION VII TROUBLESHOOTING ... 37 Microprocessor (Computer) Models ... 37 Dual Timer Models ... 43 SECTION VIII TECHNICAL INFORMATION ... 46 A. Data Label ... 46 SECTION IX REVERSING TIMER SPIN/DWELL ADJUSTMENTS ...
  • Page 10 MAXIMUM CAPACITY (D BASKET (T ) DIAMETER UMBLER BASKET (T ) DEPTH UMBLER BASKET (T ) MOTOR UMBLER DOOR OPENING (D IAMETER BASKET (T ) VOLUME UMBLER DRYERS PER 20’/40’ CONTAINER DRYERS PER 45’/48’ TRUCK VOLTAGE AVAILABLE APPROX. WEIGHT (U APPROX.
  • Page 12 in Canada, the installation must conform to applicable Canadian Standards: CAN/ CGA-B149.1-M91 (Natural Gas) or CAN/CGA-B149.2-M91 (L.P. Gas) or LATEST EDITION (for General Installation and Gas Plumbing) or Canadian Electrical Codes Parts 1 & 2 CSA C22.1-1990 or LATEST EDI- TION (for Electrical Connections).
  • Page 13 in Canada, the installation must conform to applicable Canadian Standards: CAN/CGA-B149.1- M91 (Natural Gas) or CAN/CGA-B149.2-M91 (L.P. Gas) or LATEST EDITION (for General Installation and Gas Plumbing) or Canadian Electrical Codes Parts 1 & 2 CSA C22.1-1990 or LATEST EDITION (for Electrical Connections)
  • Page 17 SINGLE DRYER VENTING...
  • Page 19 MULTIPLE DRYER (Common) VENTING...
  • Page 22 in Canada, the installation must conform to applicable Canadian Standards: CAN/CGA- B149.1-M91 (Natural Gas) or CAN/CGA-B149.2-M91 (L.P. Gas) or LATEST EDITION (for General Installation and Gas Plumbing) or Canadian Electrical Codes Parts 1 & 2 CSA C22.1-1990 or LATEST EDITION (for Electrical Connections)
  • Page 25 ø ø...
  • Page 26 M DG-50 (G H[DFW YROWDJH...
  • Page 28 Shaded areas are stated in metric equivalents * Measured at outlet side of gas valve pressure tap when gas valve is on. MODEL kcal/hr Per Hour NUMBER Rating Rating MDG-50 130,000 32,760 YPE OF Natural 8.7 mb 14.92 - 29.9 mb YPE OF Natural Liquid Propane (L.P.)
  • Page 35 OPL M...
  • Page 36: Shut Down Instructions

    K. SHUT DOWN INSTRUCTIONS...
  • Page 38 SECTION V...
  • Page 52 TIMING LEGEND SPIN TIME Adjustment Position Number Time in Seconds* DWELL (STOP) TIME Adjustment Position Number Time in Seconds* * Values shown are +/- 1-second. 10.2...