Replacing The Air Filter Element And Cleaning The Check Hose - Yamaha VINO XC50W Owner's Manual

Air filter element and check hose, replacing and cleaning<IXE>
PERIODIC MAINTENANCE AND MINOR REPAIR
check the antifreeze content of
the coolant as soon as possible,
otherwise the effectiveness of the
coolant will be reduced.
1
w
2
Never attempt to remove the radiator
cap when the engine is hot.
3
4
NOTE:
If the engine overheats, see page 6-25
for further instructions.
5
6
Changing the coolant
w
7
Never attempt to remove the radiator
cap when the engine is hot.
8
The coolant must be changed at the in-
9
tervals specified in the periodic mainte-
nance and lubrication chart. Have a
Yamaha dealer change the coolant.
Replacing the air filter element
and cleaning the check hose
EWA10380
1
ZAUM00**
1. Air filter case cover
2. Air filter element
EAU33030
3. Air filter check hose
EWA10380
The air filter element should be replaced
at the intervals specified in the periodic
maintenance and lubrication chart. Re-
place the air filter element more fre-
quently if you are riding in unusually wet
or dusty areas. In addition, the air filter
check hose must be frequently checked
and cleaned if necessary.
To replace the air filter element
1. Remove the air filter case cover by
removing the screws.
EAUT1490
2. Pull the air filter element out.
3. Insert a new air filter element into
cC
2
8 8 8 8 8 Make sure that the air filter ele-
8 8 8 8 8 The engine should never be op-
3
4. Install the air filter case cover by
To clean the air filter check hose
1. Check the hose on the side of the
2. If dirt or water is visible, remove
6-12
the air filter case as shown.
ment is properly seated in the air
filter case.
erated without the air filter ele-
ment installed, otherwise the
piston(s) and/or cylinder(s) may
become excessively worn.
installing the screws.
air filter case for accumulated dirt
or water.
the hose, clean it, and then install
it.
ECA10480