6. tnslaIling the Slide-Out Chassis into Cabinet:
(please seek assistance for this procedure)
•
Carefully slide Ihe air conditioner back into
the cabinet., (in window)
Note: Ground wire must be re-installed before
completing next step.
•
Reinstall (slide-out-chassis)
security screws
removed earlier from the (lower left/right) side o!
the cabinet. Fig 7
•
Expand the shutter frames (fully) on each side
and secure the top of the shutter frame to the
window sash using one 314" screw & fiat washer
on each side,, Fig 23
•
tnsla[i a shutter clamp on each side of the
(lower) shulter frame and secure to window sill
using one 3/4" screw & flat washer on each side.
Fig 23
7, Reinstalling Front Grill (All Models) :
Before re-installing the front grill back on the
cabinet, you must re-connect the (male]lernale)
eleclrieat wire harness between the front grill
control panel and the main (cabinet} unit.
(FigSa) Make sure the eleclrica/connection
is
firmly and securely attached.,
•
Position the front panel on the cabinet starting at
the tap.,The Iront panel lock tabs must be
inserted inlo the retaining slots in the cabinet
•
Repeat this procedure on all sides, making sure
the fresh air ventilation lever arm and power cord
are property installed back to their original
posil_en on Ihe front grill
•
Secure the trent grill to the cabinet using the
phillips screws removed earlier Fig's. 3 & 4
•
Re-inslall the air fitter.
•
Cut the second foam seal to lit lhe opening
between the lop inside and outside window
See Fig 24
•
Someinstaf[ations may require additional sealing
around the windowand air conditioner Check for
any air leaks and seal where necessary,
•
Under very humid conditions, water removal may
be excessive enough to ovedtow from the rear of
the un[I or increase noise levels ol the air
condilioner If thisoccurs, you may want to attach a
secIJen of (garden) drain bose (not Included) to
the drain plug located at the rear e! Ihe unit, this
will permitcandensalion to run off mare
conveniently. See Fig. 25.
[
//
Fig.7
Shutter
_
2rid F_em
Seal
Fig, ;Z4
_
Drain Hose
(nolincluded)
Fig.25