Table of Contents
Advertisement
ITEM / ARTICLE / ARTICULO # 16162
LP GAS GRILL
GRIL AU GAZ DE PI_TROLE LIQUI_FII_
PARRILLA A GAS PROPANO
MODEL / MODI_LE / MODELO # 720-0825
WARNING
TO reduce the risk of fire, burn hazard or other injury,
read the manual carefully and completely before
using your grill.
WARNING
FOR OUTDOOR USE ONLY.
__:__
i. WARNIN G
This grill is not intended to be
installed in or on recreational
vehicles and/or boats.
19000362A0
Visit our website
at www.nexgrill.com
Questions,
problems,
missing
parts? Before returning to your retailer, call our customer
service department
at 1- 800-913-8999,
7 a.m. - 5 p.m., PST, Monday - Friday
Advertisement
Table of Contents
Related Manuals for Nexgrill 720-0825
Summary of Contents for Nexgrill 720-0825
- Page 1 ITEM / ARTICLE / ARTICULO # 16162 LP GAS GRILL GRIL AU GAZ DE PI_TROLE LIQUI_FII_ PARRILLA A GAS PROPANO MODEL / MODI_LE / MODELO # 720-0825 WARNING WARNING FOR OUTDOOR USE ONLY. TO reduce the risk of fire, burn hazard or other injury, read the manual carefully and completely before using your grill.
-
Page 2: Table Of Contents
TABLEOFCONTENTS Safety Information ......................Package Contents List ....................... Preparation ........................Parts Diagram ........................Replacement Parts List ...................... Assembly Instructions ......................Installation Instructions ...................... Operating Instructions ......................Care and Maintenance ...................... Troubleshooting ......................... Warranty ..........................I_DANGER ..WARNING If you smell gas: 1. -
Page 3: Safety Information
SAFETY INFORMATION ._.i..._.._ WARNING Do not try lighting this appliance without first reading WARNING the "LIGHTING INSTRUCTIONS" section of this manual. WARNING - Hazards or unsafe practices which COULD result in severe personal injury or death. CAUTION - Hazards or unsafe practices which COULD result in minor personal injury. - Page 4 ..__i_:_ WARNING ..:.:..i_..WARNING Do not leave the grill unattended while cooking. Spiders and insects can nest inside the burners of the grill and disrupt gas flow..:.i.[ _WARNING Inspect the grill at least twice a year. Failure to properly place the burner over the orifice could cause a fire to occur behind and beneath the CAUTION valve panel, thereby damaging the grill and making...
- Page 5 Do not use indoors. TESTED IN ACCORDANCE WITH ANSI Z21.58a ..:..t.i., WARNING LATEST STANDARD and CGA 1.6a-2008 Do not try lighting this appliance without first STANDARD FOR OUTDOOR COOKING GAS reading the "LIGHTING INSTRUCTIONS" section APPLIANCES. THIS GRILL IS FOR OUTDOOR USE of this manual.
- Page 6 For proper lighting and performance of the burners, keep the burner ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must be mounted correctly for safe operation. Exercise caution when cleaning grill. To avoid steam burns, do not use a wet sponge or cloth to clean the grill while it is hot.
-
Page 7: Package Contents List
PACKAGE CONTENTS LIST A. Firebox Assembly ..1pc. C. Wheel B. Bottom Panel ..1pc. 2pcs. D. Side Burner Shelf & Control E. Left Side Shelf & Control F. Cart Leg, Front Left ..1pc. Panel ..1pc. Panel ..1pc. ___""'/ /' ÷... -
Page 8: Preparation
V. 1.5Volt"AA"SizeAlkaline W. Grease Box ..1pc. X. Grease Tray ..1pc. Battery ..1pc. Y. Gas tank barrier bar ..1pc. HARDWARE CONTENTS - Pre-installed as noted in instructions that follow. REF# Description 5/32-in. x 10-mm Truss Head Screw 33pcs. -
Page 9: Parts Diagram
PARTS DIAGRAM 25--... -
Page 10: Replacement Parts List
REPLACEMENT P ARTSLIST For replacement parts, call our customer service department at 1-800-913-8999, 7 a.m. - 5 p.m., PST, Monday- Friday. WARRANTY REF# DESCRIPTION WARRANTY REF# DESCRIPTION COVERAGE QTY COVERAGE Cart Frame Main Lid 2pcs Hood Buffer B 2pcs 31 Cart Leg Rear, Right Main Lid Screw 2pcs 32... -
Page 11: Assembly Instructions
ASSEMBLY INSTRUCTIONS Cart Assembly Fig. 1 Place the Cart Caster Insert (K) into the Cart Leg, Front Left (F) and Cart Leg, Back Left (G). As shown in Fig. 1. Loosen, but do not remove the screws that Fig. 2 are pre-assembled on the Cart Leg, Front Left (F) and Cart Leg, Back Left (G). - Page 12 Fig. 4 Bottom Panel Assembly Loosen, but do not remove the screws that are pre-assembled on the side of the Bottom Panel (B). Align the holes on the Cart Leg, Front Left (F) and Cart Leg, Back Left (G).Place the Cart Legs onto the screws that were loosened in the Bottom Panel (B).
- Page 13 Wheel Assembly Remove the nuts and washers which are Fig. 7 pre-assembled on the short axle, place the wheels (C) on the Axle attached to Cart Leg, Front Right (I) and Cart Leg, Back Right (J). As show in Fig. 7. Place washers closest to the wheel and then place and tighten the nuts on the axle that were...
- Page 14 Firebox Assembly Fig. 10 NOTE: We suggest two persons to lift the firebox during assembly. Be sure to remove all packaging material during assembly. Remove two screws which are pre-assembled on the Cart Leg Back Right (J) and Cart Leg Back Left (G).
- Page 15 Side Burner Shelf Assembly Fig. 12 Loosen but do not remove the screw which is pre-assembled on the cart leg. Remove the two screws that are attached to the Side Burner Shelf (D) frame and the two screws that are attached to the main control panel. Align the holes on Side Burner Shelf (D) with the loosened screws located on the cart leg.
- Page 16 Using a hex key, ensure the inset screw on the Fig. 15 knob is loosened, but not removed. Insert Side Burner Control Knob (M) onto the valve stem and tighten the inset screw with a hex key (FF). As shown in Fig. 15. Side Burner Installation From underneath the side burner remove...
- Page 17 Fig. 18 13. Electronic Igniter Battery Installation Unscrew the electronic igniter button and place the battery (V) into the housing with the positive terminal (+) facing outward. Replace the ignition button after the battery has been installed as shown in Fig. 18. Fig.
-
Page 18: Installation Instructions
16. Liquid Propane Tank Installation Fig. 21 Tank Bolt From rear of grill place the liquid propane tank into the Bottom Panel (B) hole and tighten the Tank Bolt to secure. As shown in Fig. 21..Always keep the LP cylinder 90 °... - Page 19 LIQUID PROPANE CYLINDER REQUIREMENTS (20-lb. Cylinder) A dented or rusty Liquid Propane Cylinder may be hazardous and should be checked by your supplier. Never use a cylinder with a damaged valve. The Liquid Propane Cylinder must be constructed marked in accordance with the specifications for Liquid Propane Cylinders by the United States...
- Page 20 DISCONNECTING THE LIQUID PROPANE CYLINDER Turn the grill burner valves "OFF" and make sure the grill is cool. Turn the Liquid Propane Cylinder valve "OFF" by turning clockwise until it stops. Detach the regulator assembly from the cylinder valve by turning the quick coupling nut counterclockwise.
-
Page 21: Operating Instructions
WARNING 1. Do not store spare Liquid Propane Cylinders under or near this appliance. 2. Never fill the cylinder beyond 80 percent capacity. 3. If the information above is not followed exactly, a fire, possibly causing serious injury or death, may Occur. - Page 22 Turn the control knob(s) to the "IGNITE / HIGH" setting, and preheat the grill for 15 minutes. The grill lid should be closed during the pre-heat period. Place the food on the grill and cook to the desired degree of preparation. If necessary, adjust the heat setting.
- Page 23 TO MATCH LIGHTTHEGRILL If a burner will not lightafterseveral a ttempts usingthe controlknobs, t he burnersmaybe lit witha match. WARNING CAUTION When lighting, keep your face and hands as far When using a match to light the grill make sure to away from the gr as poss b e.
-
Page 24: Care And Maintenance
CARE AND MAINTENANCE Stainless Steel There are many stainless steel cleaners available. Always use the mildest cleaning process first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface. To touch up noticeable scratches in the stainless steel, sand very lightly with dry 100 grit sand paper in the direction of the grain. -
Page 25: Troubleshooting
Checkfor properburnerflamecharacteristics. Burnerflamesshouldbeblueandstablewithnoyellowtips, Excessive noise,or liftingas shownin Fig.26. Thefollowing stepsshouldbefollowed for correcting the flamecharacteristics: 1. Turnthe control k nobsandLiquidPropane Cylinder v alves"OFF." 2. Allowthe grill andburners to cool. 3. If the flameis yellow(notenoughair),turnthe adjustment screwfoundat thefrontofthe burner counterclockwise. 4. If the flameis noisyor liftsawayfromthe burner(toomuchair),turnthe adjustment screw clockwise. - Page 26 Problems Possible Solutions Burnerblowsout. 1. Check for any burner defects. 2. Check for proper burner installation. 3. Make certain the fuel mixture is not too lean. 4. Make sure the gas supply is sufficient. 5. See if the LP tank is empty. Low heat, LP gas.
-
Page 27: Warranty
LIMITED WARRANTY (Model # 720-0825) The manufacturerwarrantsto the originalconsumer-purchaseronly that this product(Mode///720-0825)shall be free from defects in workmanshipand materialsafter correctassemblyand under normaland reasonablehomeuse for the periodsindicatedbelow beginningon the dateof purchase. The manufacturerreservesthe right to requirephotographicevidenceof damage,or that defectivepartsbe returned,postage and/orfreightpre-paidby the consumer,for reviewand examination.