Table of Contents
Advertisement
TRO
POINTS
PROBLEM
Will not start
Hardto start
Engine wilt notturn over
Engine clicksbut will not
start
Lose of power
iii
Excessivevibration
CAUSE
1.
Out of fuels
2.
Engine not =CHOKED = properly,
3,
Engine flooded,
4.
Bad spark plugs
5.
Dirty air fiiter.
6o Dirt'=/fuelfilter.
7.
Water In fuel,
8. Looseor damagedwiring.
9. Carburetor o utofadjustmenL
10. Enginevalvesoutofadjustment,
1.
Dirty air filter.
2.
Bad spark plug,
3,
Weak or dead battery,
4,
Dirty'fuel filter.
5,
_mle or dirty fuel,
6,
Loose or damaged wiring,
7,
Carburetor out of adjustment.
8.
Engine w{ves out of adjustment,
1. Clutch/brake pedalno_depressed.
2. Attachment c lutchIs engaged.
3. Weak or deadbattery.
4.
Blownfuse.
5. Corrodedbattery terrninais_
6.
Loose or damagedw[dngo
7,
Faultyignition switch°
8.
Faultysolenoidor starter,
9.
Faultyoperator presenceswitch(as).
1. Weak ordead betters/.
2. Corroded battery terminals.
3o Loose or damsgedwiring.
4.
Faultysolenoid or starter°
1. Cuffingtoomuchgrass/too fast,
2. Throttlein "CHOKE"position.
3_ Build-upofgrass,leavesand trashundermower.
4. D_rty air filter.
5. Low eli level/dirtyoIL
6. Faultysparkplug.
7o Dfrtyfuel filter.
8. Stale or dirty fuel
9. Waterin fuel.
10. Sparkplugwire loose.
tl.
Dirtyengineair screen/fins.
12. Dlrtylclogged m uffler.
13. Looseor damagedwidng.
14o Carburetor o utof adjustment.
15o Enginevalvesoutof adjustment.
1.
Worn, bent or loose blade.
2,
Bent blade mandrel,
3,
Loose/damaged part(s).
CORRECTION
1. Fitlfuel tank.
2. See "TO START ENGINE"in OpereUon section.
3. Walt severalminutes beforeatlempUng to staff,.
4. Replacesparkplug.
5. Clean/replaceair filter.
e.
Replacefuelfilter.
7. Drainfuel tankand carburetor, refilltankwithfresh
gasolineand replacefuelfilter.
8, Check all wiring.
9. ContactSears Service Center/Depatlment.
10, ContactSears Service Center/Department,
1. Clean/replaceair filter.
2. Replacesparkplug.
3. Rechargeor replacebattery.
4. Replacefue! filter.
5. Drainfuel tank andrefillwithfreshgasoline.
6. Check all w_dng.
7. ContactSeats Service CenteriDeperbnent`
8° ContactSears ServiceCenter/Depertment`
I.
DepressclutcWbmke pedal.
2. Disengageattachmentclutch.
3_ Rechargeor replacebattery.
4. Replacefuse°
5, Clean battery terminals.
6. Checkall widng,
7. Chectdreplace ignition switch,
8. Check/replace solenoid or starter.
9. Contact Seers Service Center/Department.
1. Rechargeor replacebattery.
2. Clean battery terminals.
3. CheckeJiwiring.
4. Check/replace solenoid or stinters
I.
Set in =HigherCut" position/reduce speed.
2. Adjustthrottlecontrol.
3. Clean underside of mowerhousing.
4. Clean/replace air filter.
5. Checkell levaVchange oil.
6. Clean andregapor changesparkplug.
7. Replacefuel filter.
8, Drainfuel tank andre;illwith fresh gasoline.
9, Drainfueltank andcarburetor, r efitltankwithfresh
gasolineand replacefuel fitter.
10. Connectand tightensparkplugwire.
11_ Clean engineair screen/fine.
12.
Clean!replacemuffler.
13. Checkall wiring.
14. ContactSears ServiceCenter/Depe,_nant`
15_ ContactSears Servtce Center/Depe.rbnent`
1.
Replace blades Tighten blade boil
2.
Replace blade mandrel.
3,
Tighten loose part(s), Replace damaged parts°
25
Advertisement
Table of Contents
