Page 1
10% de etanol (EIO). El uso de una gasolina que supere el 10% de etanol (EIO) anular_ la garantia del producto. Sears Brands Management Corporation, Hoffman Estates, IL 60179 U.S.A. Visit our Craftsman website:www.sears.com/craftsman *As rated by the engine manufacturer 448222...
For warranty coverage details to obtain free repair or replacement, call 1-800-659-5917 or visit the web site: www.craftsman.com In all cases above, if part repair or replacement is impossible, the riding equipment will be replaced free of charge with the same or an equivalent model.
_DANGER: This cutting machine is capable of amputating hands and feet and throwing objects. Failure to observe the following safety instructions could result in serious injury or death. _,WARNING: In order to prevent acciden- • Never direct discharged materialtoward tal starting when setting up, transporting, anyone.
li. SLOPE OPERATION • Keep children out of the mowing area and in the watchful care of a responsible Slopes are a major factor related to loss of adult other than the operator. control and tip-over accidents, which • Be alert and turn machine off if a child result...
Page 5
• Remove gas-powered equipment from • Nevertamperwithsafetydevices. Check the truck or trailer and refuel it on the their proper operation regularly. ground. Ifthis is not possible, then refuel • Keep machine free of grass, leaves, such equipment with a portable container, other debris...
Your tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to ensure...
Page 9
TO INSTALL MOWER Assemble front gauge wheel (W) to front of mower. 1. Set Parking Brake Lever (P)And Lower Attachment Lift Lever (N). • Depress clutch/brake pedal all the way down and hold. Pull parking brake lever (P) up and hold, release pressure from clutch/brake...
Page 10
4. Slide mower under tractor. • Pivot the integrated washer end of anti- sway bar (S) towards mower deck bracket Bring belt forward check belt for on right side of mower. Insert integrated proper routing in all mower pulley grooves. washer end of bar into hole in rear mower NOTE:...
Page 11
install Belt On Engine Clutch Pulley (M) • Disengage belt tension (K) from locking bracket (L). • Install belt onto engine clutch pulley (M). IMPORTANT: Check belt for proper rout- ing in all mower pulley grooves and under mandrel covers. C.
Page 12
_fCHECKLIST Before operate your tractor, wish to assure that receive best performance satisfaction from this Quality Product. Please review the following checklist: _" All assembly instructions have been completed. _" No remaining loose parts in carton. _" Battery is properly prepared and charged.
Page 13
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL HIGH CHOKE FAST SLOW IGNITION SWITCH .¢, ENGINE OFF REVERSE ENGINE ENGINE START PARKING BRAKE MOWER HEIGHT MOWER LIFT OPERATION SYSTEM (ROS)
Page 14
KNOW YOUR TRACTOR READ THIS MANUAL SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations various controls and adjustments. Save this manual for future reference. Our tractors conform to the applicable safety standards of the...
Page 15
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask worn over spectacles.
Page 16
MOVE FORWARD AND BACKWARD The cutting height range is approximately 1" to 4". heights are measured from the direction speed of movement ground to the blade tip with the engine not run- controlled by the forward and reverse drive ning. These heights are approximate and may pedals.
TO STOP MOWER BLADES TO OPERATE ON HILLS • Disengage attachment clutch control. _,WARNiNG: Do not drive up or down CAUTION: Do not operate the mower hills with slopes greater than 15° and do not drive across any slope. Use the slope without either the entire...
SERVICE REMINDER/HOURMETER CAUTION: Alcohol blended fuels (called Service reminder shows the total number gasohol or using ethanol or methanol) of hours the engine has run and flashes to attract moisture which leads to separation indicatethatthe engineor mowerneedsser- and formation of acids during storage. Acidic vicing.When serviceis required,the service gas can damagethe fuel system of an engine reminderwill flash for two hours.
Page 19
COLD WEATHER STARTING (50°F/10°C Disengage transmission placing and below) freewheel control in disengaged position (See "TO TRANSPORT" in this section When engine starts, slowly push choke of manual). control in until the engine begins to run Sitting in the tractor seat, start engine.
MOWING TIPS • Tire chains cannot be used when mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service Adjustments section of this manual. • The left hand side of mower...
MAINTENANCE BEFORE EVERY EVERY EVERY EVERY EVERY BEFORE SCHEDULE EACH SEASON STORAGE HOURS HOURS HOURS HOURS Check Brake Operation Check Tire Pressure aT Check Operator Presence & ROS Systems Check for Loose Fasteners Check/Replace Mower Blades Lubrication Chart Check Battery Level Clean Battery and Terminals Clean...
Page 22
TRACTOR CHECK REVERSE OPERATION (ROS) SYSTEM Always observe safety rules when per- • When the engine is running with the forming any maintenance. BRAKE OPERATION ignition switch in the engine "ON" posi- tion and the attachment clutch engaged, If tractor requires more than five (5) feet to any attempt...
NOTE: original equipment battery Change the oil after every 50 hours of op- your tractor is maintenance free. eration or at least once a year if the tractor attempt to open or remove caps or covers. is not used for 50 hours in one year.
ENGINEOiL FILTER CLEAN AIR SCREEN Replacethe engineoilfilter everyseason or Air screen must be kept free of dirt and chaff every other oil change if the tractor is used to prevent engine damage from overheating. more than 100 hours in one year. Clean with a wire brush or compressed airto AIR FILTER...
Page 25
CLEANING Pull back the lock collar of the nozzle adapter and push the adapter onto the • Clean engine, battery, seat, finish, etc. deck washout port at the left end of the of all foreign matter. mower deck. Release the lock collar to •...
Page 26
& WARNING: TO AVOID SERIOUS iNJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: Depress clutch/brake pedal fully and set parking brake. Place attachment clutch in "DISENGAGED" position. Turn ignition key to "STOP" and remove key. Make sure the blades and all moving parts have completely stopped.
Page 27
TO LEVEL MOWER If adjustment is necessary, see steps Make sure tires are properly inflated to the and 3 in Visual Adjustment instructions PSI shown on tires. Iftires are over or under above. inflated, it may affect the appearance of your Recheck measurements, adjust if neces-...
REPLACE MOWER DRIVE BELT NOTE: Observe entire motion drive belt and position of all belt guides and keepers. MOWER DRIVE BELT REMOVAL Disconnect clutch wire harness (A). Park tractor on a level surface. Engage Remove anti-rotation link (B) on right parking brake.
Page 29
TO CHECK BRAKE TO START ENGINE WITH A WEAK BAT- TERY If tractor requires more than five (5) feet to stop at highest speed in highest gear on a _,WARNING: Lead-acid batteries gener- level, dry concrete or paved surface, then ate explosive gases.
Page 30
REPLACING BATTERY REMOVE HOOD GRILL SEMBLY _WARNING: Do not short battery termi- Raise hood. nals by allowing a wrench or any other object Unsnap headlight wire connector. to contact both terminals at the same time. Stand in front of tractor. Grasp hood at Before...
Page 31
ENGINE Immediately prepare your tractor for storage at the end of the season or if the tractor will FUEL SYSTEM not be used for 30 days or more. IMPORTANT: It is important prevent WARNING: Never store the tractor with gum deposits from forming in essential fuel...
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM CAUSE CORRECTION Will not start Out of fuel. Fill fuel tank. See "TO START ENGINE" Engine not "CHOKED" properly. Operation section. Wait several minutes before Engine flooded. attempting to start.
Page 33
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM CAUSE CORRECTION Loss of power Cutting too much grass/too fast. Raise cutting height/reducespeed Throttle in "CHOKE" position. Adjust throttle control. Clean underside of mower Build-up of grass, leaves and trash under mower.
Page 34
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM CAUSE CORRECTION Poor grass Engine speed too slow. Place throttle control in "FAST" discharge position. Travel speed too fast. Shift to slower speed. Wet grass. Allow grass to dry before mowing. Mower deck not level.
NEED MORE HELP? You'll find the answer and more on managemyhomeocom - for free[ o Find this and all your other product manuals online. o Get answers from our team of home experts. o Get a personalized maintenance plan for your home. tools o Find information to help with home projects.
Page 36
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION I/v_- ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. down the face of slopes, never across the face. Do not mow ARNING: To avoid serious injury, operate your tractor up and slopes greater than 15 degrees.
Page 37
Ilame al 1-800-659-5917 6 visite el sitio web: www. craftsman.com En todos los casos anteriores, si el reemplazo es imposible, el equipo tractor ser_. sustituido sin cargo con el mismo modelo o uno equivalente.
Page 38
_PELIGRO: Esta Maquina cortadora es capaz de arnputar las rnanosy los pies y de lanzar objetos, si no se observan las instrucciones de seguridad siguientes se pueden producir lesiones graves o la rnuerte. • No maneje la m&quina si no tiene la trampa _DVERTENCIA: Siempre desconecte el alam- para cesped completa, la canaleta de descarga...
Page 39
• Escogeruna velocidadde marchabaja de • Tenet el maximo cuidado cuando se acerca modo quenoseanecesario pararse o cambiar a cantos ciegos, arbustos, _trboles u otros estando en unapendiente. objetos que pueden impedir la vista de niflos. • Nocortar lahierba mojada. L asruedas pueden IV.
Page 40
OPERAClONES DE SERVIClO GENERALES • Nunca hacer funcionar la m&quina en un &rea • Si se golpea un objeto ajeno, hay que pararse cerrada. e inspeccionar la m&quina. Reparar, si es necesario, antes de volver a poner en marcha. • Mantener todas las tuercas y pernos apretados para asegurarse de que trabaja en condiciones •...
LA REPARACION Velocidad de Marcha Congratulaciones por su buena compra. Recarrido Adelante: 0 - 5.2/8,4 nuevo producto Craftsman® est& diseSado (Mph/Kph): Atr&s: 0- 2.9/4,7 fabricado para funcionar de modo fiable muchos aSos. Pero como todos los productos, SistemadeCarga: 15 Amps @3600 RPM...
Page 43
Su tractor nuevo ha sido montado en la fabrica con la excepci6n de aquellas partes que no se han mon- tado por razones de envio. Para asegurarse que su tractor funcione en forma adecuada y segura todas las partes y los articulos de ferreteria que se monten tienen que set apretados en forma segura. Use las herramientas correctas, segOn sea necesario, para asegurarse de que esten apretados en forma segura.
Page 44
INSTALE LA SEGADORA Y LA CORREA DE TRANSMISION Accione la palanca del freno de estaciona- miento (P) y la palanca de levantamiento del accesorio inferior (N). Presione el pedal de embrague/freno completamente hasta abajo y mant@galo apretado. Tire y mantenga la palanca del freno de esta- H.
Page 45
• Deslice la cortadora de cesped debajo del • Haga oscilar el extremo con la arandela tractor hasta que se encuentre centrada integrada de la barra antibalanceo (S) hacia debajo del tractor. la escuadra de la plataforma de la cortadora de cesped en el lado derecho de la cortadora.
Page 46
Instale la correa en la polea del embrague del motor (M) • Desenganche la varilla tensora de la correa (K) de la escuadra de bloqueo (L). (Vea el diagrama completo en la pagina 1 .) • Instale la correa en la polea del embrague del motor (M) IMPORTANTE: Verifique...
Page 47
REVISION DEL SISTEMA DE FRENOS Una vez que usted haya aprendido a manejar su tractor, verifique que el freno funcione correcta- mente. Ver "PARA VERIFICAR Sl FUNCIONA BIEN EL FRENO" en el capitulo de servicio y ajustes de este manual. REVISION ,/LISTA Antes de operar y de disfrutar de su tractor nuevo,...
Page 48
Estos simbolos pueden aparecer sobre su tractor o en la literatura proporcionada con el producto. Aprenda y comprenda sus significados. MARCHA ATR,_S NEUTRO ALTO BAJO ESTRANGU- R,_,PIDO LENTO LACION (@) -@ MOTOR MOTOR MOTOR LEVANTAMIENTO FRENO ALTUFIA DE LA SISTEMA ENCENDIDO EN MARCHA DE LA SEGADORA...
Page 49
FAMILIARICESE CON SU TRACTOR LEA ESTE MANUAL Y LAS REGLAS DE SEGURIDAD ANTES DE OPERAR SU TRACTOR Compare las ilustraciones con su tractor para familiarizarse con las ubicaciones de los diversos controles y ajustes. Guarde este manual para referencia en el futuro. Nuestros tractores cumplen con los est&ndares de seguridad del American National Standard...
Page 50
La operaci6n de cualquier tractor puede hacer que salten objetos e×trahos dentro de sus ojos, Io que puede producir dahos graves en estos. Siempre use anteojos de seguridad o protecciones para los ojos mientras opere su tractor o cuando haga ajustes o reparaciones.
Page 51
MOVERSE HACIA ADELANTE Y HACIA La gama de la altura de corte es de aproxima- ATRA$ damente 1 a 4 pulgadas. Las alturas se miden desde el suelo a la punta de la cuchilla cuando La direcci6n y la velocidad de movimientos est_.n el motor no est&...
Page 52
1. Elijaa quealturacortar& elcesped pormedio Cuando el uso del ROS es m&s necesario, de la palanca elevadora. de vuelta a la Ilave de ignici6n en el sentido de las agujas del reloj hasta la posici6n "ON". 2. Hagaarrancar las cuchillas de la segadora enganchando el controldel embraguedel PARA OPERAR EN CERROS accesorio.
Page 53
PRECAUClON: Combustibles mezclados MECANISMO DE AVISO DE SERVICIO CRONOMETRO alcohol (conocidos como gasohol, o el uso de El mecanismo de aviso de servicio muestra etanol o metano!) pueden atraer la humedad, la que conduce a la separaci6n y formaci6n nOmero total de horas que ha estado en func- &cidos durante el almacenamiento.
Page 54
Los accesorios y el embrague de suelo ahora Para mayor seguridad, ubique el tractor en puede ser utilizados. Si el motor no acepta una superficie nivelada, despejada de cual- esta carga, vuelva a arrancar el motor para quiet objeto y abierta, con el motor apagado permitirle que se caliente por un minuto,...
Page 55
CONSEJOSPARASEGAR • No se pueden usar las cadenas para las Ilantas cuando la caja de la segadora est& adjunta al tractor. • La segadora debe estar nivelada en forma adecuada para obtener el mejor rendimiento al segar. Vea "PARA NIVELAR LA CAJA DE LA SEGADORA"...
PROGRAMA ANTES CADA CADA CADA CADA CADA ALMACENAMIENTO MANTENIMIENTO CADA USO TEMPORADA HORAS HORAS HORAS HORAS Revisar la operacion del freno Revisar la presion de las Ilantas Verifiez la commande de presence d'operateur et le sistema d ROS Revisar si hay sujetadores sueltos Afilar/cambiar las cuchillas...
Page 57
TRACTOR Cuando el motor est& en marcha con el inte- rruptor de Ilave del sistema de funcionamiento Siempre observe las reglas de seguridad cuando atr&s (ROS) en la posici6n "ON" y el embrague de mantenimiento. del accesorio conectado, cualquier tentativa del OPERAClON DEL FRENO operador de viajar marcha atr&s, NO apagar&...
Page 58
PARA LIMPIAR LA BATERiA Y LOS TERMI- Cambie el aceite despues de 50 horas de oper- NALES aci6n o pot Io menos una vez al aflo si el tractor se utiliza menos 50 horas el aflo. La corrosi6n y la mugre de la bateria y de los Revise el nivel del aceite del c&rter antes de ar- terminales pueden producir "escapes"...
FILTRO DEACEITEDELMOTOR LIMPIEZA DELA REJILLADEAIRE La rejillade airedebemantenerse sin mugrey Cambie el filtrodeaceitedelmotorcadatempo- pajaparaevitareldafloal motor debidoalsobre- radaovez por medio quecambie el aceite, s i el tractorse usam&sde 100horasen unaflo. calentamiento. Limpiela c onuncepillo dealambre o conairecomprimido p araremover l a mugrey lasfibrasdegomasecas,pegadas.
Page 60
LIMPIEZA Eche hacia atr&s la abrazadera de cierre del adaptador de la boquilla y empuje este en el • Limpie todo material extraflo del motor, la puerto de lavado de la cubierta en el extremo bateria, el asiento, el pulido, etc. izquierdo de la cubierta de la segadora.
Page 61
ADVERTENCIA:PARA EVITAR LESIONES SERIAS, ANTES DE DAR CUALQUIER SERVI. CIO O DE HACER AJUSTES: Presione el pedal del embrague/freno completamente y aplique el freno de estacionamiento. Ponga la palanca de control de movimiento en la posici6n de neutro. Ponga el embrague del accesorio en la posici6n desenganchado (DISENGAGED).
Page 62
PARA NIVELAR LA SEGADORA En caso que sea necesario realizar un ajuste, lea los pasos 2 y 3 de las instrucciones Aseg@ese de que los neum&ticos esten inflados a Regulaci6n visual que aparecen m&s arriba. la PSi que se indica en estos. Si est&n demasiado Vuelva a verificar las medidas y ajuste nueva- inflados o poco inflados, el cesped no le quedar&...
Page 63
PARA REEMPLAZAR LA CORREA DE LA NOTE: Observe toda la correa de impulsi6n de CUCHILLA DE LA SEGADORA movimiento y la posici6n de todas las guias y DESMONTAJE DE LA CORREA DE LA SEGA- guardacorreas. DORA Desconecte el arnes del cable del embrague (A). Quite la pieza de uni6n anti-rotaci6n Estacione el tractor en una superficie nive-...
Page 64
PARA HACER ARRANCAR EL MOTOR CON VERIFIQUE EL FRENO UNA BATERiA BAJA Si el tractor exige m&s de cinco (5) pies para pararse a una velocidad m&s alta en el cambio _kDVERTENCIA: Las baterias de &cido-plo- m&s alto en una superficie nivelada de hormig6n mo generan gases explosivos.
Page 65
PARA REMOVER EL CONJUNTO DEL CAPOTA REEMPLAZAR LA BATERIA Y DEL ENREJADO ,_ADVERTENCIA: No haga cortocircuito con los Levante el capota. terminales de la bateria al permitir que una Ilave Desabroche el conector del alambre de las de tuerca o cualquier otro objeto entre en contacto luces delanteras.
Page 66
MOTOR Inmediatamente prepare su tractor para el alma- cenamiento al final de la temporada o si el tractor SISTEMA DE COMBUSTIBLE no se va a usar pot 30 dias o m&s. IMPORTANTE: Es important evitar que se for- _ADVERTENCIA: Nunca almacene el tractor man depositos de goma en partes fundamen- tales del sistema de combus-tible...
Page 67
IDENTIFICACI6N DE PROBLEMAS: Yea la secci6n apropiada en el manual a menos que este dirigido a un centro de servicio Sears. PROBLEMA CAUSA CORRECCK_N Sin combustible. Llene et estanque de combustible. arral3ca Motor sin Ia"ESTRANGULACION" Vea"PARA HACER ARRANCAR EL MO- TOR"...
Page 68
IDENTIFICACION DE PROBLEMAS: Yea la secci6n apropiada en el manual a menos que este dirigido a un centro de servicio Sears. PROBLEMA CAUSA CORRECCI6N P_rdida de Agua en el combustible. Vaciar etestanquede combustibtey et carbu- fuerza rador, vuetva a tlenar et estanque con gaso- lina nueva y cambie etfiltro de combustible.
Page 69
IDENTIFICACKDN DE PROBLEMAS: Yea la secci6n apropiada en el manual a menos que este dirigido a un centro de servicio Sears. PROBLEMA CAUSA CORRECCK3N de lantera(s) Bombilla(s) 0 IAmpara(s) quemada(s). Cambie la bombilla(s) 0 I_.mpara(s). no funciona= Interruptor de la luz fallado. Revise/cambie el interruptor de la luz.
Page 71
GUiA SUGERIDA PARA IViEDIR LAS PENDIENTES CON LA VISTA PARA UNA OPERACI6N SEGURA SOLAMENTE ANDE CUESTA ARRIBA O CUESTA ABAJO Y NO ATRAVlESE EL CERRO 15GRADOS MAX. ADVERTENCIA: Para evitar daSos graves, haga funcionar su tractor arriba y abajo de las pendientes, nunca transversalmente con respecto aias pendientes.
Page 72
NEED MORE HELP. YOU']_ _md the answer and more on managemyhomeocom - for free! . Fredtbs and aLL your other product manualsonLine . Get answersfrom our team of homeexperts. ° Get a personalizedmaintenanceplan for your home• . Findinformation and tools to help with homeprojects. manage home b_o°_ht...