1. Manuals
  2. Brands
  3. Stanley Manuals
  4. Ranges
  5. Woodburning Range and
  6. Installation and operating instructions manual

Stanley Woodburning Range Installation And Operating Instructions Manual

Hide thumbs Also See for Woodburning Range:
Table of Contents

Advertisement

Quick Links

Woodburning Range

SAFETY NOTICE

PLEASE READ THIS ENTIRE MANUAL BEFORE YOU INSTALL AND USE YOUR NEW COOK STOVE.
FAILURE TO FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE,
BODILY INJURY OR EVEN DEATH. SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
IF THIS APPLIANCE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. FOR YOUR SAFE-
TY, FOLLOW THE INSTALLATION DIRECTIONS. CONTACT LOCAL BUILDING OR FIRE OFFICIALS
ABOUT RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS IN YOUR AREA.
THIS APPLIANCE MUST BE CONNECTED TO A LISTED, HIGH-TEMPERATURE RESIDENTIAL TYPE
AND BUILDING HEATING APPLIANCE CHIMNEY OR AN APPROVED MASONRY
CHIMNEY WITH FLUE LINER.
THE COMPLETE INSTALLATION MUST BE DONE IN ACCORDANCE WITH CURRENT STANDARDS AND
LOCAL CODES. IT SHOULD BE NOTED THAT THE REQUIREMENTS AND THESE PUBLICATIONS MAY
BE SUPERSEDED DURING THE LIFE OF THIS MANUAL.
THIS APPLIANCE IS HOT WHILE IN OPERATION AND RETAINS ITS HEAT FOR A LONG PERIOD OF
TIME AFTER USE. CHILDREN, AGED OR INFIRM PERSONS SHOULD BE SUPERVISED AT ALL TIMES
AND SHOULD NOT BE ALLOWED TO TOUCH THE HOT WORKING SURFACES WHILE IN USE OR UNTIL
THE APPLIANCE HAS THOROUGHLY COOLED.
MANUFACTURED BY: WATERFORD STANLEY (MARKETING) LTD., BILBERRY, WATERFORD,
IRELAND.
ASSEMBLY INSTALLATION AND OPERATING INSTRUCTIONS

Advertisement

Table of Contents
loading

Related Manuals for Stanley Woodburning Range

Summary of Contents for Stanley Woodburning Range

  • Page 1: Safety Notice

    TIME AFTER USE. CHILDREN, AGED OR INFIRM PERSONS SHOULD BE SUPERVISED AT ALL TIMES AND SHOULD NOT BE ALLOWED TO TOUCH THE HOT WORKING SURFACES WHILE IN USE OR UNTIL THE APPLIANCE HAS THOROUGHLY COOLED. MANUFACTURED BY: WATERFORD STANLEY (MARKETING) LTD., BILBERRY, WATERFORD, IRELAND. ASSEMBLY INSTALLATION AND OPERATING INSTRUCTIONS...

  • Page 3: Table Of Contents

    TABLE OF CONTENTS PAGE Assembly............. 2 Installation .

  • Page 4: Assembly

    ASSEMBLY Fig.1 Remove packing strip from the top of Fit the complete skirting under the front the range. Place the sheet steel back of the range inside the front legs using a plate to one side. Remove all loose screw and nut to secure it to each leg. components from the top of the range and firebox and the oven.
  • Page 5 (Part No. 88) to the splashback. Screw the complete assembly on to the cooker top (Part No. 18). The Waterford Stanley Woodburning Range is Fig.5 equipped for top flue connection. Should you wish to vent the range to the rear the following modifica-...

  • Page 6: Installation

    INSTALLATION When installing, operating and maintaining a solid fuel heater, respect basic standards of fire safety. Read these instructions carefully before commenc- ing the installation. Failure to do so may result in damage to persons and property. Consult your local municipal office, Fire Department and your insur- ance representative to determine what regulations are in force.

  • Page 7: Floor Protection

    FLOOR PROTECTION CHIMNEY TYPE CANADA When installing the Waterford Stanley Woodburning This Waterford Stanley Woodburning Range must Range on a combustible floor, a floor protector con- be connected to an Underwriters Laboratories of sisting of a layer of non-combustible material at least...

  • Page 8: Connecting To Masonry Chimney

    CHIMNEY CONNECTOR SYSTEMS, THIMBLES CONNECTING TO MASONRY CHIMNEY CLEARANCES FROM COMBUSTIBLE WALLS The connector to a masonry chimney must extend through the wall to the inner face or liner but not Minimum 3 1/2” (90mm) thick brick masonry beyond, and must be firmly cemented to masonry. wall framed into combustible wall with a min.

  • Page 9: Exploded View

    72. Oven Door Mineral Wool 50. Sham Cheek Top 73. Insulation 51. Name Plate 74. Thermometer 52. Bonnet Ring 75. Spindle Waterford Stanley 53. Hob Protecting Plate 76. Gasket 54. Plinth Jointing Clip 77. Back S.I. Woodburning Range 55. Bonnet 78.

  • Page 10: Masonry Fireplace

    Sheet steel chimney connector, min. 24 gauge in thickness, with a ventilated thimble, min. 24 gauge in thickness, having (50mm) two 1” (25mm) air channels, separated from combustibles by a min. of 6” (150mm) of Minimum clearances 2”(50mm) 1” (50mm) glass fibre insulation.

  • Page 11: Ventilation & Combustion Air Requirements

    The house is equipped with a well-sealed vapour barrier and tight fitting windows and/or has any powered devices that exhaust house air. There is excessive condensation on win- dows in the winter. A ventilation system is installed in the house. If these or other indications suggest that infiltration air is inadequate, additional combustion air should be provided from the outdoors.

  • Page 12: Maintenance

    Your prevent rust spots, so your Stanley will stay in good hardwood ashes will benefit the garden; they contain condition until you need it again.

  • Page 13: Disposal Of Ashes

    DISPOSAL OF ASHES I M P O R TA N T: UNDER NO CIRCUMSTA N C E S SHOULD ANY FLAMMABLE LIQUID, GASOLINE Ashes should be placed in a metal container with a KEROSENE, LIGHTER FLUID OR CHARCOAL- tight-fitting lid. The closed container of ashes should STARTERS BE USED TO LIGHT OR “FRESHEN be placed on a non-combustible floor or on the UP”...

  • Page 14: The Hotplate

    THE HOTPLATE CHIMNEY CLEANING Use the hotplate and the cooking-top of the range Inspect the chimney connector frequently. Tap the for boiling simmering, frying, grilling, braising, etc. connector with your finger when the pipe is cool. If Best results can be obtained by using flat bottomed you hear a dull echo, the pipe may need cleaning.

  • Page 15: Warming Shelf - Left Or Right Hand Location

    WARMING SHELF - LEFT OR RIGHT HAND LOCATION ASSEMBLY INSTRUCTIONS CONTENTS 1 /4 1 /4 Remove the ” (6mm) x ” (6mm) round Warming Shelf (1 off). 1 /4 head screws (2 off) from the hob and ” Bracket to Shelf (1 off). 1 /4 (6mm) x ”...

  • Page 16: Assembly Instructions - Warming Oven

    TIGHTEN ALL BOLTS. Your warming oven Dismantle, clean and remove flue pipe. is now ready for use. Fig. 20 Fig. 19 Waterford Stanley (Marketing) Ltd., Bilberry, Waterford, Ireland. Telephone: (051) 302300 Facsimile: (051) 302375 DP 030826 Rev:009...

Table of Contents