Trouble Shooting Guide - Bayou Classic SP10 Owner's Manual

TROUBLE SHOOTING GUIDE FOR Model #SP1 Jet Cooker
SYMPTOM
Cooker lights but the flame
remains very small
Repeated from page 22
Cooker will not light
Repeated from page 22
Burner will not light
and burner tube is clean
Hissing or gurgling sounds
coming through gas train
from tank to burner
Do not use this appliance if gas
leaks cannot be stopped and
corrected.
Flame has gone out
CAUSE
Rapid gas flow from propane
tank activates EXCESS FLOW
safety device
Orifice Hole in Jet Tube is not
facing straight up
Orifice hole is blocked
Not enough gas flow from
propane tank
Low gas level in propane tank,
or tank is empty
Faulty regulator hose assembly
Damaged hose
Gas leak
Low gas level in propane tank,
or tank is empty
Too much wind
Blockage in jet tube
31
POSSIBLE SOLUTION
Repeat lighting instructions and
be certain to S-L-O-W-L-Y open
cylinder valve one full turn, then
S-L-O-W-L-Y open regulator valve
to light cooker
Using a wrench, turn brass cap
until orifice hole is facing up
Using a wire, insert into orifice
hole to remove blockage debris
Open propane tank valve all
the way
Check gas level in propane tank,
re-fill or exchange tank
Contact 1-800-864-6194;
Model M5HPR-1
Perform soapy water test to check
for cracks in hose.
See pages 13-14; Model M5HPR-1
Perform soapy water test to check
all connections - See pages 13-14
Check gas level in propane tank
Check wind direction and set
cooker away from windy areas
Clean and check burner for
spiders, insect nests and debris