Material Safety Data Sheet - Oki B4545 MFP Safety And Warranty Manual

Material Safety Data Sheet

#58378401
Black Toner: P/N 52116101
For more information, contact Oki Data at: 2000 Bishops Gate
Boulevard, Mount Laurel, NJ 08054-4620.
Emergency Information: call 1-800-654-3282; US and Canada
only.
Emergency First Aid Procedures ________
Toner inhaled.
Remove person to fresh air immediately. If symptoms occur,
seek medical attention.
Toner swallowed (ingested)
Rinse out mouth with water. Give one or two glasses of water to
drink. If symptoms occur, seek medical attention.
Toner gets in the eyes.
Immediately flush eyes with large quantities of cool water for
15 minutes, keeping the eyelids open with fingers. If symptoms
occur, seek medical attention.
Toner gets on the skin.
Wash toner off the skin with plenty of cool water and soap. If
necessary, seek medical attention.
Note: Small amounts of toner on skin or clothing can easily be
removed with soap and cold water. Hot water makes
toner harder to remove.
Hazardous Ingredients _______________
Carbon Black (1-10% by weight): Group 2B Possible
Carcinogen
CAS#: 1333-86-4.
OSHA PEL: 3.5 mg/m
3
ACGIH TLV: 3.5 mg/m
3
Other Ingredients
Polyester Resin (>90% by weight)
CAS#: Trade Secret.
Polyolefin Wax (1-10% by weight)
CAS#: Trade Secret.
Organic Pigment (1-10% by weight)
CAS#: Trade Secret.
Amorphous Silica (<1% by weight)
CAS#: 7631-86-9.
Physical Data_______________________
Physical State: Solid.
Melting/Freezing Point: About 125°C (275°F).
Boiling Point: Not applicable.
PH: Not applicable.
Vapor Pressure: Not applicable.
Vapor Density (Air=1): Not available.
Evaporation Rate (Butyl Acetate=1): Not available.
Specific Gravity (H O=1): 1.2 at 20°C (68°F).
2
Solubility in Water: Insoluble in water.
Solubility in Solvents: Not available.
Coefficient of water/oil Distribution: Not applicable.
Appearance and Odor: Black powder, almost odorless.
Odor Threshold: Not available.
Fire and Explosion Hazard Data _________
Minimal fire hazard. Large quantities may cause risk of dust
explosion.
Flash Point (Method Used): Not applicable.
Flammable Limits
Lower Explosive Limit: Not available.
Upper Explosive Limit: Not available.
Auto-Ignition Temperature: Not available.
Explosion Data
Sensitivity to Mechanical Impact: Not available.
Sensitivity to Static Discharge: Not available.
Extinguishing Media: In CO
chemical. Avoid full water jet.
Special Fire Fighting Procedures: Wear self-contained
breathing apparatus.
Hazardous Combustion Products: Carbon monoxide,
carbon dioxide and smoke.
Toxicological Properties _______________
Routes of Entry: Inhalation, Ingestion, Eyes, Skin.
Effects of Acute Exposure
LD : Ingestion (oral) = >5000 mg/kg [Rat].
50
LD : Dermal = >2000 mg/kg [Rat].
50
LC : > 0.74 mg/ [Rat].
50
Effects of Chronic Exposure
In a two-year inhalation study of chronic toxicity and
carcinogenicity using a typical toner in rats, there were no
lung changes at all in the lowest exposure level (1 mg/m
the most relevant level to potential human exposures. A
minimal to mild degree of fibrosis was noted in 22% of the
animals at the middle exposjre level (4 mg/m
moderate degree of fibrosis was observed in 92% of the rats
at the highest exposure oevel (16 mg/m
observed in the higher exposure groups are interpreted in
terms of "lung overloading," a series of generic responses to
the presence of large quantities of respirable, insoluble and
relatively benign dusts retained for extended time periods in
the lungs. Lung tumor frequence was unchanged among rats
exposed to toner at the three exposure levels, and for
air-only control rats.
Exposure Limits: Not available.
Irritancy
Eye Irritation: Non irritant (Rabbit)
Skin Irritant: Non Irritant (Rabbit)
Sensitivity: Not available.
Carcinogenicity
IARC: Carbon Black, Group 2B, "Possible Carcinogen."
NTP: No components are listed.
OSHA: Carbon black is designated hazardous according to
OSHA 29 CFR 1910.1200.
Reproductive Toxicity: Not available.
Teratogenicity: Not available.
Mutagenicity: Negative (Ames test).
Name of Toxicoligically Synergistic Products: Not
available.
7: English
, water spray, foam and dry
2
), and a mild to
3
). The lung changes
3
),
3