Buyers CC400 Installation Instructions

CC400 4" | CC600 6" | CC800 8" Conduit Carriers
Before you begin assembling the conduit carrier,
verify that you have received all the parts listed in
the bill of materials.
6
Tools Required:
• 3/8" Drill and 3/8" Drill Bit
• Tape Measure
• Silicon Sealant
• 8 Cap Fasteners (rivets/nuts and bolts)
• Drill Bit for Selected Fastener
1. Assemble the front and rear covers to a length of 4" or
6" PVC pipe. Apply a bead of silicon sealant (not supplied)
to the inside of the front and rear covers before sliding
them over the ends of the PVC pipe.
2. Secure the caps to the PVC pipe with either pop rivets
or screws (not supplied) in four places. Drill suitably sized
holes for your fastener through the cap and PVC pipe.
Drill the holes in the 2 o'clock, 4 o'clock, 8 o'clock and 10
o'clock positions.
3. Determine the position on your truck or van ladder rack
that you would like to mount your new conduit carrier. Drill
two 3/8" holes in each of the ladder rack cross rails for the
U-bolts and saddles. Center saddles as needed.
4. Assemble the conduit carrier assembly to the ladder
rack with the saddles, U-bolts, lock washers and nuts sup-
plied.
Installation Instructions
1
2
Bill of Materials
CC400 Conduit Kit for 4" PVC
3 ITEM
1
2
3
4
4
5
5
6
CC600 Conduit Kit for 6" PVC
ITEM
1
2
3
4
5
6
CC800 Conduit Kit for " PVC
ITEM
1
2
3
4
5
6
WARRANTY
Buyers Products Co. warrants all truck/trailer hardware manufac-
tured or distributed by it, to be free from defects in material and
workmanship for a period of one year from date of shipment. Parts
must be properly installed and used under normal conditions.
Any product which has been altered, including modification, mis-
use, accident or lack of maintenance will not be considered under
warranty. Normal wear is excluded. The sole responsibility of Buyers
Products Co. under this warranty is limited to repairing or replacing any
part or parts which are returned, prepaid, and are found to be defective
by Buyers Products Co. Authorization from Buyers Products Co. must
be obtained before returning any part. No charges for transportation
or labor performed on Buyers' products will be allowed under this
warranty.
www.buyersproducts.com
Phone (440) 974-8888
Fax 800-841-8003
PART NO. QTY. DESCRIPTION
3016367 1 Cap, Rear, 4"
3016371 2 U-Bolt 3/8-16 Thread
3016369 2 Saddle 4"
- 4 3/8 Lock Washer
- 5 3/8-16 Nut
3016383 1 Cap, Front, 4"
PART NO. QTY. DESCRIPTION
3016366 1 Cap, Rear, 6"
3016370 2 U-Bolt 3/8-16 Thread
3016368 2 Saddle 6"
- 4 3/8 Lock Washer
- 5 3/8-16 Nut
3016382 1 Cap, Front, 6"
PART NO. QTY. DESCRIPTION
3025858 1 Cap, Rear, 8"
3025859 2 U-Bolt 3/8-16 Thread
3025860 2 Saddle 8"
- 4 3/8 Lock Washer
- 5 3/8-16 Nut
3025864 1 Cap, Front, 8"
3016385 Rev. C