Table of Contents Important Safety Instructions ..1 Generic Names for Chemicals ... 78 Common Water Chemistry Questions ..79 Preparing for Your New Portable Spa . 2 Do’s and Don’ts .
WARNING: Do not use drugs or alcohol before or during CAUTION: Maintain water chemistry in accordance with the use of a spa or hot tub to avoid unconsciousness and manufacturer’s instructions. possible drowning. SAVE THESE INSTRUCTIONS. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
It is always best location of your spa. to design special installations so that the spa can still be moved, or lifted off the ground. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Opening the Front Door Panel for Electrical Hookup following electrical connections must performed by a licensed electrical contractor. Unscrew and remove the two corner panels on each side of the spa’s front door. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
For example: A normal 50 amp or electrical inspector. GFCI with four #6 AWG copper wires that run over 100 feet would require you to go to four #4 AWG copper wires. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Wiring Requirement/50 Hz See the Cal Spas Pre-Delivery Guide for more information on spa placement for service access and electrical service. www.calspas.com/manuals 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Make sure drain valve closed capped. (See page 86 for a description of drain valves.) Never run the spa with the gate valves closed or without water circulating for long periods of time. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 10
Soft water makes it impossible to maintain the proper water chemistry and may cause the water to foam, which will ultimately harm the finish of the spa and void your warranty. You may fill your spa with well water 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
You will know this has happened when after you have filled and started the spa, the pump does not seem to function. You will hear the pump operating, but no water will be moving. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
When air is bled out, tighten the nut. Turn on power to the spa and press the JETS button. If there is still air trapped in the pump, repeat steps 2 through 5 until the pump primes. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 15
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 16
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 20
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 26
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 33
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 44
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 42281_A 11-19-15 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
TP600/TP400 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 46
2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 47
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 48
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 52
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 54
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 55
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 56
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 57
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 58
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 60
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 61
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 62
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 63
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 64
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 66
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 67
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 69
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group. 40940_J 10-08-13 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Rotating the face of an adjustable jet to the right (clockwise) will increase the amount of water flow through the jet. (See example shown here.) Neck jets adjust in the opposite directions (counterclockwise to increase, clockwise to decrease). 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
LIGHT button, the LED lights patterns provide you with multiple options to suit almost any may start flashing. This is another normal operational lighting preference. pattern option. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
When water from the hydro streamer sprays the bottom of the cover, it will collect and run to the edge of the spa and drip over the top. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Chloramines are compounds formed when chlorine combines with nitrogen from body oils, perspiration, etc. Chloramines can cause eye irritation as well as having a strong odor. Unlike bromamines, chloramines are weaker, slower sanitizers. To remove chloramines, see the description of shock below. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Test strips are a convenient testing method The reagent test kit is a commonly used by spa owners. method which provides a high level of accuracy but is more expensive and more difficult to use. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
When the Total Alkalinity is within the recommended range, proceed to the next step. equipment Ideal CH balance balance Add a calcium 2019 Portable Spa CH too low hardness increaser LTR20191035, Rev. E Causes equipment www.calspas.com corrosion pH too high Add a pH Too alkaline, causes decreaser...
It is important to check the pH on a regular (weekly) basis. The pH will be affected by the bather load, the addition of new water, the addition of various chemicals, and the type of sanitizer used. When the pH is within the recommended range, proceed to sanitation. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
You have more control over the bromine level baseline and maintain it regularly. by adding bromine as needed. For more discussion on this, see page 79, “Common Water Chemistry Questions”. Starting with fresh water: 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
We recommend you clean your filter at least once a month, possibly every two weeks depending on how frequently you use your spa, and replace it once a year or as necessary. See page 87 for instructions on removing and cleaning the filter. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
N/A To decrease calcium hardness, drain several gallons of water from the spa and refill using a mixture of 75% hard water and 25% soft water, or use a stain and scale inhibitor. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
DON’T use a sanitizer which is not designed for spas. • DON’T use household bleach (liquid sodium hypochlorite). • DON’T broadcast or sprinkle the chemicals onto the water surface. This method may cause chemically-induced spa surface blistering (chemical abuse). 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
When the diverter valve is in the center position, there is not enough suction from the pump in order to inject ozone into the spa. The ozonator will generate ozone, but it will not be injected into the water. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Adjust total alkalinity and pH – if scale requires total alkalinity and pH too high removal, drain the spa, scrub off the scale, refill the Scale spa and balance the water Use a stain and scale inhibitor 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Bromide residuals will be significantly reduced if phosphate levels are high. If phosphates are detected, purchase a phosphate remover and follow the directions accordingly. Any phosphates in your spa will reduce bromine levels. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Depending on the amount usage, circulation Shocking your tub is recommended after heavy bather load. time, and type of spa, each spa owner’s setting will be different. Intelligent Controller Codes for the Bromine Generator 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
OUT JETS. To replace any jet, place it in the fitting and turn it clockwise until it snaps in and can be rotated freely about half a turn. Do not overtighten the jet. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
4. Drain the spa. Turn the valve on the hose-bib fixture to open the drain. When the spa has drained completely, turn the valve on the hose-bib fixture, remove garden hose, and replace the cap. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Soak the filter for a minimum of 24 hours. Spray the filter with a water hose. Spray each pleat carefully. Reinstall the filter. Do not overtighten. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
When you return, check and adjust the pH and shock the water. If you will not be using your spa for longer than 14 days and a spa maintenance service is not available, we strongly recommend you drain or winterize your spa. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
(For Android users, the systems will pair automatically - no code is needed.) Once your device is paired and connected, all sounds from your device will be played through the sound system, including system sounds and telephone. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
3” Micro Flow Directional Patio+ PLUCS2295061S Inground Spas MMP 3” Mini Multi-Massage PLUCS2295171S Patio Patio+ Inground Spas Note: All Cal Spa models use a combination of screw-in and snap-in jet inserts where removable jets are used. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 93
2” Neck Jet Directional PLU29923-014-000 Patio Patio+ Inground Spas PST 5” Power Storm Wagon Wheel Patio PLUCS2295191S Patio+ Inground Spas If you need jet bodies, go to www.quickspaparts. refer Replacement Parts Catalog, which downloaded from www.calspas.com/replacementparts. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 94
Velocity 5VTX LED Jet Platinum Platinum+ Symbol: 5VTX Part #: PLU29950-011-100 Size: 5”D x 5.5”L Escape Escape+ Platinum Platinum+ Velocity Directional Blue Jet Symbol: 5D Part #: PLU29950-012-400 Size: 5”D x 5.5”L Escape Escape+ Platinum Platinum+ 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 95
Size: 5”D x 5.5”L Escape Part #: PLU29950-071-100 Escape+ Platinum Size: 5”D x 5.5”L Escape Platinum+ Escape+ Platinum Platinum+ If you need jet bodies, go to www.quickspaparts. refer Replacement Parts Catalog, which downloaded from www.calspas.com/replacementparts. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 96
Part #: PLU29940-112-100 Size: 3”D x 3.25”L Escape Size: 4”D x 4.5”L Escape Escape+ Escape+ Platinum Platinum Platinum+ Platinum+ If you need jet bodies, go to www.quickspaparts. refer Replacement Parts Catalog, which downloaded from www.calspas.com/replacementparts. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 97
Velocity Massage-7 LED Jet Velocity Roto Blue Jet Symbol: 3M Symbol: 2R Part #: PLU29930-142-100 Part #: PLU29920-022-400 Escape Size: 3”D x 3.25”L Escape Size: 2”D x 3”L Escape+ Escape+ Platinum Platinum Platinum+ Platinum+ 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 98
Symbol: 2D Part #: PLU29920-012-100 Size: 2”D x 3”L Escape Escape+ Air X Therapy Ring Platinum PLU23512-331-100 Platinum+ If you need jet bodies, go to www.quickspaparts. refer Replacement Parts Catalog, which downloaded from www.calspas.com/replacementparts. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 99
Part #: PLU25056-202-100 Size: 2.5” x 5”L Velocity Air Control Blue Velocity Symbol: A 2” Diverter Valve LED Part #: PLU25059-202-400 Symbol: D2 Size: 3.125” x 5”L Part #: PLU25058-202-100 Size: 4.5” x 7.75”L 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 100
(for On-Off Valve) Velocity Part #: PLU21701739 1” Diverter Valve Wall Fitting LED Part #: PLU25030-089-200 Velocity Air Control Wall Fitting LED Part #: PLU25090-089-200 Velocity 2” Diverter Valve Wall Fitting LED Part #: PLU25048-089-200 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Drain Super Hi Flo Suction 2½” Black (640-3581LGV) PLU21400146 ACC01800026 Low Profile Drain ¾” Black (640-0511) PLU21400401 If you need jet bodies, go to www.quickspaparts. refer Replacement Parts Catalog, which downloaded from www.calspas.com/replacementparts. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 102
Cascade II Waterfall 75 SQ. Ft. Black textured with valve and logo 12 -3/8” ‘14 2” CV, 4 PLU21800825TEX SCALLOP (less Cascade II Waterfall cartridge) Curved Black Textured with Valve and Logo 12-3/8” ‘14 PLU21800828 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
4-LED light manual. To order replacement panels for your spa, visit string www.quickspaparts.com. LIT16100332 1 to 3 ext. cord LIT16100335 1 to 1 port ext. cord LIT16100338 Interior light with logic (7 LED) LIT16100333 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Basic Troubleshooting The troubleshooting guidance provided here is intended to cover the most common problems a spa owner may encounter. For more in-depth troubleshooting, go to www.calspas.com/troubleshooting. Symptom Possible Solutions Problems starting up Pump won't prime See priming instructions on page 9.
Page 106
Air may be leaking into the suction line. Contact your dealer for assistance. Debris may be inside the pump. Contact your dealer for assistance. Noise may be a sign of damage. Contact your dealer for service. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Reduce the length of your filter cycles. Visit your local dealer for additional guidance. Since Thermal Creep only occurs in well-insulated hot tubs, it is not indicative of something that is wrong with your spa or its equipment. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
The spa cover delivered with the spa is warranted for one year for Escape Plus and Veranda spas, 90 days for Patio, Patio Plus, Escape, and Special Edition spas.
This Limited Warranty gives you specific legal rights. You may also have other rights that vary from state to state. Some states do not allow limitations on how long an implied warranty lasts, so this limitation may not apply to you. 2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 110
2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 111
2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 112
2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 113
2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 114
2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
Page 115
2019 Portable Spa LTR20191035, Rev. E www.calspas.com...
By taking just a few quick minutes to register, you can enjoy product alerts, more efficient support, and quicker service. Go to www.calspas.com/warranty. Fill in your information and click “Send Warranty Info” Locating the product serial number: The serial number of your spa is located on a metal plate attached to the inside of the door for the equipment area.
Need help?
Do you have a question about the Veranda and is the answer not in the manual?
Questions and answers