Subscribe to Our Youtube Channel
Related Manuals for FPG INLINE 3000 Series
Summary of Contents for FPG INLINE 3000 Series
- Page 1 MODELS IN-3B-SQ-06/09/12/15 PRODUCT MANUAL 26174 REV I MAY 2022 3000 SERIES SQUARE/BAIN MARIE WIDTHS: 600/900/1200/1500mm FIXED FRONT/SLIDING REAR DOORS FREESTANDING/IN-COUNTER/ON-COUNTER...
- Page 2 3000 SERIES SQUARE/BAIN MARIE Copyright © MAY 2022 Future Products Group Limited. All rights reserved. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of Future Products Group Ltd.
-
Page 3: Warnings
Warnings Operational This appliance is not intended for use by young children or infirm persons, Safety unless they have been adequately supervised by a responsible person, to ensure that they can use the appliance safely. Young children should be supervised, to ensure that they do not play with the appliance. -
Page 4: Table Of Contents
Caution ............................... 3 Mains Supply Cord ............................. 3 Hazardous Substances ..........................3 INTRODUCTION ......................... 7 Welcome ................................7 Future Products Group (FPG) ........................7 Guidance and Help ............................. 7 Warranty ................................7 Warranty Period ............................7 Liability Exceptions ............................. 8 Specific Exclusions ............................. - Page 5 CLEANING ........................12 Cautions ................................. 12 Power ............................... 12 Water ................................ 12 Exterior ................................12 Metal Surfaces ............................12 Glass ................................ 12 Sliding Doors ............................12 Interior................................13 Standard Configuration Cabinet Well ....................... 13 Dishes and Dividers..........................13 Open Back Configuration Cabinet Well ....................13 Routines .................................
- Page 6 3000 SERIES SQUARE/BAIN MARIE SPECIFICATIONS ......................20 Mechanical ..............................20 Electrical ................................. 20 Compliance ..............................21 Performance Aspects ..........................21 Improvements ..............................21 Ongoing Development ..........................21 ELECTRICAL CIRCUIT DIAGRAMS ................22 Model: IN 3B06-SQ ..........................22 Model: IN 3B09-SQ ..........................22 Model: IN 3B12-SQ ..........................
-
Page 7: Introduction
INTRODUCTION Welcome HEATED CABINETS - INTRODUCTION Future Welcome to the world of FPG! Our products are designed and engineered to Products give you the optimal performance that you deserve with innovative visual Group (FPG) merchandising appeal. We are confident that you will be delighted with your state of the art inline food service cabinet, and that it will become a valued appliance in your store. -
Page 8: Liability Exceptions
• Fair wear and tear. Assessment The liability under this warranty is dependent on an assessment by FPG, to determine the defect in workmanship or materials. Time Limit FPG does not guarantee that any service to be performed under this warranty will be carried out within any particular time limit. -
Page 9: Operation
OPERATION Cabinet Layout HEATED CABINETS - OPERATION 3000 Square The standard 3000 Square Series, Dry Well Bain-marie cabinet has a fixed Series Cabinets glass front and sliding glass rear doors. Models are available for On-Counter mounting, In-Counter mounting and Free Standing. -
Page 10: Preparation
3000 SERIES SQUARE/BAIN MARIE Preparation HEATED CABINETS - OPERATION Power Supply Ensure that power is connected to the cabinet, the overhead heat lamps will come on when the Main Switch is turned on. The well heating is controlled by the thermostat, and can be turned off by rotating the control knob fully anti-clockwise. -
Page 11: Trouble Shooting
TROUBLE SHOOTING FAULT POSSIBLE CAUSE REMEDY Door not in track Install door correctly in track Debris in track Clean door tracks (see cleaning) Doors are not sliding smoothly Apply food grade lubricant to Lack of lubricant door track The mains isolating switch on the wall, circuit breaker or Turn isolating switch circuit fuses are off at the power... -
Page 12: Cleaning
3000 SERIES SQUARE/BAIN MARIE CLEANING Cautions HEATED CABINETS - CLEANING Power ALWAYS TURN THE POWER SUPPLY OFF BEFORE CLEANING. Water THIS UNIT IS NOT WATERPROOF. DO NOT USE A WATER JET SPRAY TO CLEAN THE INTERIOR OR EXTERIOR OF THIS CABINET. Exterior HEATED CABINETS - CLEANING Metal Surfaces... -
Page 13: Interior
Interior HEATED CABINETS - CLEANING Standard To clean the Configuration cabinet well, Cabinet Well remove the doors and lift out the dishes and dividers. Sweep out or vacuum away any loose debris. This cabinet is a dry well unit, so the well is not waterproof. -
Page 14: Routines
3000 SERIES SQUARE/BAIN MARIE Routines HEATED CABINETS - CLEANING Schedules To maintain optimum performance, cleaning schedules must be regular and thorough. Inspection As part of the cleaning routine, the controls, mechanical parts and electrical wiring should be inspected for damage, deterioration or need of adjustment. Correction If any small faults are found, have them attended to promptly by a competent serviceman. -
Page 15: Installation
INSTALLATION Regulations HEATED CABINETS - INSTALLATION Compliance It is very important that your inline food cabinet is installed correctly and that the with Local operation is correct before use. Installation must comply with local electrical, Requirements health & safety and hygiene requirements. Setting Up HEATED CABINETS - INSTALLATION Unpacking... -
Page 16: Location
3000 SERIES SQUARE/BAIN MARIE Location HEATED CABINETS - INSTALLATION Ventilation The Bain-Marie cabinet is designed to meet the HACCP specification with free room air circulation. Access Access to the back of the cabinet is required for loading, cleaning and operation of the control panel. -
Page 17: Servicing
SERVICING Control Gear HEATED CABINETS - SERVICING Location The electrical control gear is located in the top of the cabinet. Remove the top plate to access the control gear. The chassis has a mains switch, a thermometer, a thermostat and a protective fuse. Lighting HEATED CABINETS - SERVICING Caution... -
Page 18: Heating
3000 SERIES SQUARE/BAIN MARIE Heating HEATED CABINETS - SERVICING Caution DO NOT attempt to replace heating elements without isolating the cabinet at the supply switch or by unplugging it from the mains supply. Element Remove the doors Replacement and base trays from the cabinet, to reveal the heating CAUTION:... -
Page 19: Door Seals
Door Seals HEATED CABINETS - SERVICING Seal The doors should be removed to allow the old seals to be removed and the new Replacement ones fitted. See the Cleaning section for details. Sliding Doors Each sliding door has a rubber seal between the door and the cabinet end panel. -
Page 20: Specifications
3000 SERIES SQUARE/BAIN MARIE SPECIFICATIONS Mechanical HEATED CABINETS - SPECIFICATIONS CABINET MODEL IN 3B06S IN 3B09S IN 3B12S IN 3B15S Height 778 mm 621 + 157 mm 778 mm 778 mm Width 600 mm 900 mm 1200 mm 1500 mm Depth 685 mm 685 mm... -
Page 21: Compliance
The cabinet is HACCP compliant, with the following performance: Aspects Cabinet Operating Temperature Test Conditions >65°C 22°C Ambient with 65% RH Improvements HEATED CABINETS - SPECIFICATIONS Ongoing FPG reserves the right to change specifications and construction, as part of Development ongoing product improvement. MODELS IN-3B-SQ-06/09/12/15... -
Page 22: Electrical Circuit Diagrams
3000 SERIES SQUARE/BAIN MARIE ELECTRICAL CIRCUIT DIAGRAMS Model: IN 3B06-SQ Inline 3000 Square Series, 600mm Bain-Marie Cabinet Model: IN 3B09-SQ Inline 3000 Square Series, 900mm Bain-Marie Cabinet © FUTURE PRODUCTS GROUP... -
Page 23: Model: In 3B12-Sq
Model: IN 3B12-SQ Inline 3000 Square Series, 1200mm Bain-Marie Cabinet Model: IN 3B15-SQ Inline 3000 Square Series, 1500mm Bain-Marie Cabinet MODELS IN-3B-SQ-06/09/12/15... -
Page 24: Spare Parts
When ordering spare parts, it is important to quote the Serial Number printed on Number the label fixed to the control panel. This will enable FPG to ensure that spare parts are fully compatible with your cabinet. To satisfy warranty conditions, and ensure optimum performance, use only FPG supplied spare parts. -
Page 25: Location Of Glass Parts
Location of In the following table, handed glass parts are labelled as viewed from the REAR Glass Parts of the cabinet. Part Description FPG Part No. Qlon centre door seal 12922 Slide-in rubber door seal 11424 Gastro Dish 65mm deep... -
Page 26: Mechanical Drawings
3000 SERIES SQUARE/BAIN MARIE MECHANICAL DRAWINGS Dimensions HEATED CABINETS - MECHANICAL DRAWINGS IN 3B06-SQ-FF Open-Back Configuration © FUTURE PRODUCTS GROUP... -
Page 27: In 3B09-Sq-Ff In Counter Mounting
IN 3B09-SQ-FF In Counter Mounting MODELS IN-3B-SQ-06/09/12/15... -
Page 28: In 3B12-Sq-Ff On Counter Mounting
3000 SERIES SQUARE/BAIN MARIE IN 3B12-SQ-FF On Counter Mounting © FUTURE PRODUCTS GROUP... -
Page 29: In 3B15-Sq-Ff On Counter Mounting
IN 3B15-SQ-FF On Counter Mounting MODELS IN-3B-SQ-06/09/12/15... - Page 30 3000 SERIES SQUARE/BAIN MARIE © FUTURE PRODUCTS GROUP...
- Page 31 MODELS IN-3B-SQ-06/09/12/15...
- Page 32 PRODUCT MANUAL 26174 REV I MAY 2022 In line with our policy to continually develop, improve and support our products, Future Products Group Ltd reserves the right to change specifications and design without notice. Have a question? Please email us at: sales@fpgworld.com or visit www.fpgworld.com...
Need help?
Do you have a question about the INLINE 3000 Series and is the answer not in the manual?
Questions and answers