Related Manuals for genz GC48V-038-T-C
Summary of Contents for genz GC48V-038-T-C
- Page 1 Product Manual Lithium Ferro Phosphate (LFP) Battery 48V 38Ah End Terminal (Telco style) Plastic Cased Battery Model Number: GC48V-038-T-C...
-
Page 2: Table Of Contents
..............................12 ROUBLESHOOTING WARRANTY & SERVICE INFORMATION ....................... 13 ..............................13 ECORD OF URCHASE ............................13 EFORE ALLING FOR ERVICE ............................... 13 ARRANTY OR ERVICE Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 2 of 15... -
Page 3: Introduction
All rights of this User Manual (“Manual”), including but not limited to the content, information, and figures are solely owned and reserved by genZ Energy PTY LTD. (“genZ Energy”). The Manual can only be applied to the operation or the use of this product. Any disposition, duplication, dissemination, reproduction, modification, translation, extraction, or usage of this manual in whole or in part is prohibited without the prior written permission of genZ Energy. -
Page 4: Safety Guidelines
Battery replacement should be performed by competent service personnel only. This battery contains no user serviceable parts inside and is sealed. Safety Data Sheet (SDS) Refer to the SDS that was supplied with this battery. Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 4 of 15... -
Page 5: Specifications
See genz.com.au Terminal (Brass) M8 hole Over-voltage cut-off Approximately 58.6V Under-voltage cut-off Approximately 40V Battery Management Over-temperature cut-off 65°C System (Fully Automatic) Cell Balancing Passive Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 5 of 15... -
Page 6: Battery Overview
(-) is black. They are also marked with the + and the – symbols. The battery is supplied with two M8 bolts, split washers and flat washers. Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 6 of 15... -
Page 7: Terminals , Positive And Negative Installation
Unlike deep-cycle flooded/wet lead acid batteries which release small amounts of gas during usage, particularly during the charge cycle, genZ LFP batteries do not release these harmful and potentially explosive gases. However, some form of ventilation should be considered when determining installation placement. -
Page 8: Installation Of Batteries In Parallel
This will help balance the current flow. Installation of Batteries in Series These Batteries are NOT designed for connecting in series. Connecting in series will void your warranty. Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 8 of 15... -
Page 9: Installation Procedure
To prevent corrosion, after tightening the M8 bolt, apply a thin coat of quality terminal protector. Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 9 of 15... -
Page 10: Charging The Battery
This will ensure long life for your battery as well as providing a fully charged battery for when it is required. Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 10 of 15... -
Page 11: Storage
This ‘loss of capacity’ can normally be corrected by cycling the battery (discharging to approximately 50% depth of discharge) and then charging for at least three discharge/charge cycles. Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 11 of 15... -
Page 12: Battery Maintenance
Battery Maintenance General Maintenance The GC48V-038-T-C battery is essentially ‘maintenance free’ and no attempt should be made to open the plastic case. Doing so will void any warranty and may result in a dangerous short circuit. However, depending on the environment and type of use the LFP battery has, the following is recommended: 1. -
Page 13: Warranty & Service Information
In the unlikely event that you believe the battery is faulty, contact the place of purchase or the dealer/distributor first. If you cannot reach your dealer, or if they cannot resolve the issue please visit the genZ web site at www.genz.com.au for contact details for technical support. Please ensure that you have the following information available: Where and when the battery was purchased. - Page 14 LFP Battery 48V 38Ah (Telco) Product Manual Notes: Serial Number: Model Number: Place of Purchase: Date of Purchase: Owner: Issued for Use Revision Page All rights reserved genZ 2023 22/Sep/2023 1.6KJF 14 of 15...
- Page 15 Energy Pty Ltd Phone: 1300 979 760 Malaga WA Australia 6090 Email: info@genz.com.au Web: www.genz.com.au...
Need help?
Do you have a question about the GC48V-038-T-C and is the answer not in the manual?
Questions and answers