Table of Contents
Advertisement
Quick Links
USA
SERVICE OFFICE
Dometic Corp.
2320 Industrial Parkway
Elkhart, IN 46761
574-294-2511
CANADA
Dometic Dist.
866 Langs Dr.
Cambridge, Ontario
CANADA N3H 2N7
519-653-4390
For Service Center
Assistance Call:
800-544-4881
INSTALLATION &
OPERATING INSTRUCTIONS
Revision:
Form No. 3308755.010 2/05
(Replaces 3308755.003)
(French 3308756.018 )
©2005 Dometic Corporation
LaGrange, IN 46761
600312 PENGUIN
600315 PENGUIN
ROOF TOP AIR CONDITIONER
3106615 AIR DISTRIBUTION BOX KIT and
3107541 ANALOG RELAY KIT
WARNING
!
This manual must be read and un-
derstood before installation, adjust-
ment, service, or maintenance is per-
formed. This unit must be installed
by a qualified service technician.
Modification of this product can be
extremely hazardous and could re-
sult in personal injury or property
damage.
Important:
These instructions must stay with
unit. Owner read carefully.
PENGUIN AIR BOX INSTALLATION INSTRUCTORS FOR ANALOG CONTROLS
USED WITH
Lire et comprendre ce manuel avant
de procéder à l'installation, à des
réglages, de l'entretien ou des
réparations. L'installation de cet
appareil doit être effectuée par un
réparateur qualifié. Toute modifica-
tion de cet appareil peut être
extrêmement
entraîner
dommages matériels.
1
RECORD THIS UNIT INFORMATION FOR
FUTURE REFERENCE:
Model Number
Serial Number
Date Purchased
®
®
!
AVERTISSEMENT
AVERTISSEMENT
dangereuse
des
blessures
Model
600312.321
600315.321
600315.326
et
ou
Advertisement
Table of Contents
Related Manuals for Dometic Duo-Therm PENGUIN 600312
Summary of Contents for Dometic Duo-Therm PENGUIN 600312
- Page 1 Model INSTALLATION & 600312.321 OPERATING INSTRUCTIONS 600315.321 600315.326 Revision: Form No. 3308755.010 2/05 (Replaces 3308755.003) (French 3308756.018 ) Important: These instructions must stay with ©2005 Dometic Corporation unit. Owner read carefully. LaGrange, IN 46761...
-
Page 2: Safety Instructions
PENGUIN AIR BOX INSTALLATION INSTRUCTIONS FOR ANALOG CONTROLS 1. GENERAL INFORMATION SAFETY INSTRUCTIONS A. THIS AIR CONDITIONER IS DESIGNED FOR: This manual has safety information and instruc- 1. Installation on a recreational vehicle during the time tions to help users eliminate or reduce the risk of the vehicle is manufactured. - Page 3 PENGUIN AIR BOX INSTALLATION INSTRUCTORS FOR ANALOG CONTROLS...
-
Page 4: Installation Instructions
20” 2-1/2” The Dometic Corporation will not be liable for any damages or injury incurred due to failure in following these instructions. Installation must comply with the National Electrical 22”... -
Page 5: Roof Preparation
PENGUIN AIR BOX INSTALLATION INSTRUCTORS FOR ANALOG CONTROLS B. OPENING PREPARATION 3. ROOF PREPARATION 1. If the opening exceeds 14-3/8" x 14-3/8", it will be necessary to install spacers. Read all of the following instructions before beginning the 2. If the opening is less than 14-1/8" x 14-1/8", it must be installation. - Page 6 PENGUIN AIR BOX INSTALLATION INSTRUCTIONS FOR ANALOG CONTROLS 4. THERMOSTAT AND CABLE FIG. 6 Lift And Place Unit INSTALLATION Over Opening A. LOCATION The proper location of the thermostat is very important to insure that it will provide a comfortable RV tempera- Rear ture.
- Page 7 PENGUIN AIR BOX INSTALLATION INSTRUCTORS FOR ANALOG CONTROLS D. Check gasket alignment over roof opening and adjust if H. If your installation includes the optional Electric Heat Kit, necessary. Unit may be moved from below by lifting and install it at this time. Follow the instructions with the heat sliding.
- Page 8 PENGUIN AIR BOX INSTALLATION INSTRUCTIONS FOR ANALOG CONTROLS Type using a horseshoe welded snap clip. CAUTION a. Install on return bend located at left (curb side) side of evaporator coil as follows: If bolts are left loose there may not be an ad- b.
-
Page 9: Air Box Installation
PENGUIN AIR BOX INSTALLATION INSTRUCTORS FOR ANALOG CONTROLS B. CONNECTION OF 120 VOLT POWER SUPPLY FIG. 14 WARNING Disconnect 120 volt AC. Failure to follow these instructions could create a shock hazard causing death or severe personal injury. Install 1. Connect white to white; black to black; and green to Screws green or bare copper wire using appropriate sized twist connectors. - Page 10 PENGUIN AIR BOX INSTALLATION INSTRUCTIONS FOR ANALOG CONTROLS AIR BOX WIRING DIAGRAM 3107883.005 FIELD WIRING FIELD WIRING FIELD WIRING FIELD WIRING FACTORY WIRING FACTORY WIRING FACTORY WIRING FACTORY WIRING OPTIONAL REMOTE SENSOR REMOTE SENSOR BLU/WHT TO FURNACE TO FURNACE CABLE BLU/WHT +12VC -12VDC...