Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for IBEX Westermo Ibex-RT-330-5G Series
- Page 1 Ibex-RT-330-5G Series EN 50155 5G Router...
-
Page 2: Table Of Contents
4.5. Cooling ................22 4.6. Replacement of Product ............24 5. Specifications ................25 5.1. Interface Specifications ............25 5.2. Type Tests and Environmental Conditions ......... 30 6. Abbreviations and Terms ............... 32 7. Revision Notes ................35 Ibex-RT-330-5G Series... -
Page 3: General Information
Please visit the product web page for more information. Upon request, the applicable source code will be provided. A nominal fee may be charged to cover shipping and media. Please direct any source code request to your normal sales or support channel. Ibex-RT-330-5G Series... -
Page 4: Safety And Regulations
No personal injury Minor damage to the order to avoid misuse of product the product, confusion or misunderstanding NOTICE Used for highlighting general, No personal injury Minor damage to the but important information product NOTE Table 1. Warning levels Ibex-RT-330-5G Series... -
Page 5: Safety Information
The product must be installed and operated by qualified service personnel and installed into an apparatus cabinet or similar, where access is restricted to service personnel only. For Ibex products, outdoor installation is allowed. Before energising and connecting communication cables to the product, ensure a protective earthing conductor is first connected to the protective earthing terminal (only valid for metallic housings). - Page 6 CABLE TEMPERATURE RATING FOR FIELD TERMINAL WIRES There may be a requirement on the minimum temperature rating of the cable to be connected to the field wiring terminals, see chapter Interface Specifications. Ibex-RT-330-5G Series...
-
Page 7: Care Recommendations
By ensuring the product is disposed of correctly, you will help to reduce hazardous substances and prevent potential negative consequences to both the environment and human health, which could be caused by inappropriate disposal. Figure 1. WEEE symbol for treatment of product disposal Ibex-RT-330-5G Series... -
Page 8: Compliance Information
Any changes or modifications shall be approved by the party responsible for compliance. If not, users could void the user's authority to operate the equipment. Country code and antenna gain need to be set properly for correct functionality in the installed country. Ibex-RT-330-5G Series... -
Page 9: Agency Approvals And Standards Compliance
Terrestrial Radio Access (E-UTRA) • 3GPP LTE Advanced standard • 3GPP Release 16 - 5G NSA/SA Safety • IEC EN 61010-1, Safety Requirements for electrical equipment for measurement, control, and laboratory use • EN 45545-2, Fire protection on railway vehicles Ibex-RT-330-5G Series... -
Page 10: Simplified Declaration Of Conformity
Hereby, Westermo declares that this product is in compliance with applicable EU directives and UK legislations. The full declaration of conformity and other detailed information is available at www.westermo.com/support/product-support. Figure 2. The European Conformity and the UK Conformity Assessment markings Ibex-RT-330-5G Series... -
Page 11: Product Description
3. Product Description 3.1. Product Description The Ibex-RT-330-5G a mobile 5G router for onboard usage in trains, trams, locomotives, mining vehicle and bus applications. It makes full use of the 5G cellular networks. The device utilizes a high performance GNSS receiver with concurrent reception of up to 4 GNSS signals from GPS, Galileo, GLONASS or BeiDou systems. -
Page 12: Available Models
Gigabit Ethernet ports X1 and X2 SIM card slot Protective earth terminal Power input DC Frontside label Warning symbol for surface temperatures above +60°C Antenna ports A1 - A5 LED indicators Table 3. Location of interface ports and LED indicators Ibex-RT-330-5G Series... -
Page 13: Front Side Label
3.3.2. Front Side Label Ibex-RT-xxx-xx EU Power: 24VDC, 0.6A 3623-075001 00001089 2012 Description Remarks Article number Example of article number Serial number Example of serial number Manufacturing date The Date Format is: YYWW YY = Manufacturing Year WW = Manufacturing Week... -
Page 14: Interface Ports View
3.3.3. Interface Ports View GNSS Power Ethernet Description Description Antennas 1000Base-T Grounding point Power Table 5. Interface ports view Ibex-RT-330-5G Series... -
Page 15: Connector Information
Carefully move the drawer out of the frame. Place the SIM cards into the sockets in slot 1 and/or slot 2 with the contacts facing down. Let chamfered corners align according markings on the drawer. Ibex-RT-330-5G Series... - Page 16 NOTE The sim cards must be fully inserted into the sockets until the mechanical stop. NOTE The product supports two SIM cards with the restriction that only one SIM card is active. Ibex-RT-330-5G Series...
-
Page 17: Ethernet Ports
The antenna connectors are identified on the product with . A1 to A4 are used for 5G communication. It is recommended to use all 4 antenna ports. A5 is used for the included GNSS receiver. The antenna port must be connected to an external GNSS antenna. Ibex-RT-330-5G Series... -
Page 18: Led Indicators
Error status Ethernet status for X1 port Ethernet status for X2 port Table 9. LED indicators NOTE Refer to management guide for detailed LED status indication. 3.6. Dimensions Dimensions are stated in mm and are regardless of variants. Ibex-RT-330-5G Series... - Page 19 195.4 19.7 22.7 111.4 Figure 6. Dimensional drawing Ibex-RT-330-5G Series...
-
Page 20: Installation
To reset the product into factory default settings, a reset adapter is needed which is plugged into one of the Ethernet ports X1 or X2 during startup. Art. no. Description 3623-0799 Factory Reset Plug, X-coded Factory reset procedure Plug the factory reset adapter to one of the Ethernet interfaces. Ibex-RT-330-5G Series... -
Page 21: Earth Connection
When connecting the power cable, ensure that the pins are connected correctly before tightening the power cable to the unit. NOTE This product has no replaceable fuse and should be connected via an external fuse for protection. Ibex-RT-330-5G Series... -
Page 22: Cooling
Figure 9. Installation with natural convection airflow airflow When operating the product at high ambient temperatures, it is recommended to mount the product to a metallic base plate to improve the heat dissipation. The base plate increases the surface to spread the heat. Ibex-RT-330-5G Series... - Page 23 Figure 10. Improved heat transfer based on fixing plate and natural convection NOTICE Limited air flow is rising the product temperature and may lower the upper limit of the operating temperature range. NOTICE Temperature is dependent on the operational parameters, like RF output power, amount of traffic. Ibex-RT-330-5G Series...
-
Page 24: Replacement Of Product
Be aware that the surface of this product may become hot. When it is operated at high temperatures, the external surface may exceed Touch Temperature Limit according to the product's relevant electrical safety standard. This product complies with Touch Temperature Limits throughout its operational temperature range. Ibex-RT-330-5G Series... -
Page 25: Specifications
Data rate 10 Mbit/s, 100 Mbit/s, 1000 Mbit/s, manual or auto Duplex Full or half, manual or auto Transmission range Up to 100 m with CAT5e cable or better Cabling Shielded cable CAT5e or better is recommended Conductive chassis Ibex-RT-330-5G Series... - Page 26 TNVs. NOTICE To avoid damages on the Ethernet interfaces, ensure that the far end side of the Ethernet cable shield itself is connected to protective earth. SIM card SIM type Mini-SIM 2FF Recommended temperature Industrial grade rating Ibex-RT-330-5G Series...
- Page 27 LTE: LB TX0/PRX & MHB TX0/PRX & UHB TX1/DRX WCDMA: LMB TRX 5G NR: - Refarmed: MHB PRX MIMO & UHB PRX MIMO - n41 PRX MIMO - n77/n78/n79 PRX MIMO LTE: MHB PRX MIMO & UHB PRX MIMO & LAA 5G NR: Ibex-RT-330-5G Series...
- Page 28 Concurrent GPS, GLONASS, Galileo and BeiDou plus SBAS and QZSS constellations reception Sample rate 25 Hz (independent of the GNSS constellation) Protocols NMEA 4.10/4.11, UBX SBAS and QZSS are only active in combination with GPS NOTICE Unused antenna port must be terminated with 50 Ohm terminations. Ibex-RT-330-5G Series...
- Page 29 NOTICE To avoid damages on the antenna interfaces, ensure that the far end side of the antenna cable and/or the antenna itself is connected to protective earth. NOTE External GNSS LNA is recommended to improve sensitivity. Ibex-RT-330-5G Series...
-
Page 30: Type Tests And Environmental Conditions
Ethernet ports Insulation resistance EN 50155 Power port (DC) > 100 MOhm to all other ports Dielectric strength EN 50155 Power port (DC) 750 VDC, 60 s to all other ports Table 10. EMC and electrical conditions Ibex-RT-330-5G Series... - Page 31 The power and Ethernet cables need to be fastened 200 mm or closer to the unit. The same recommendation applies to the Antenna cables. Provided all connectors are connected with IP66 cabling or fitted with protective caps (delivered with the unit) and tightened to the specified torque Table 11. Environmental and mechanical conditions Ibex-RT-330-5G Series...
-
Page 32: Abbreviations And Terms
FLOSS Free/Libre Open Source Software Galileo European Global Positioning System GNSS Global Navigation Satellite System GLONASS Russian Global Positioning System US Global Positioning System International Engineering Consortium Industry Canada Identification International Mobile Telecommunications Input / Output Ingress Protection Ibex-RT-330-5G Series... - Page 33 Satellite-Based Augmentation System Subscriber Identity Module Serial Number SNMP Simple Network Management Protocol Time Division Duplex Telephone Network Voltage Transmitter / Receiver Ultra-high Band Up Link UMTS Universal Mobile Telecommunications System Virtual Private Network WCDMA Wideband Code Division Multiple Access Ibex-RT-330-5G Series...
- Page 34 Abbreviation Description WebGUI Web Graphical User Interface WeConfig Westermo Configuration Tool WEEE Waste Electrical and Electronics Equipment WLAN Wireless Local Area Network Table 12. Abbreviations and terms Ibex-RT-330-5G Series...
-
Page 35: Revision Notes
7. Revision Notes Revision Date Change description Rev. A 2023-12 First revision Ibex-RT-330-5G Series... - Page 36 Westermo • Metallverksgatan 6, SE-721 30 Västerås, Sweden Tel +46 16 42 80 00 Fax +46 16 42 80 01 E-mail: info@westermo.com www.westermo.com 6629-2220 REV. A 2023 12 @ Westermo Network Technologies AB, Sweden...