Advertisement
O
NOTE: To completely drain the
system the elbow has to be
blocked, otherwise no syphoningeffect
will be provided and a certain quantity
of liquid will remain in the system.
_
CAUTION: To prevent rust for-
.". mation in the cooling system, al-
ways replenish the system with the re-
commended solution (60% anti-freeze
40% water).
To refill the cooling system; position
the disconnected end of the hose
higher than the engine head, then pour
in the liquid until it reaches the elbow
fitting in the engine head. Reconnect
the hose. Continue to pour the liquid
in the system until the coolant lever
reaches 2.5 cm (1 in.l below filler neck
of reservoir.
Inspection and cleaning should be per-
formed by the dealer at the end of each
season.
Drain the chaincase completely and re-
, fill to proper level using fresh chain-
case oil. To drain, remove chaincase
cover.
Lubricate steering mechanism. Inspect
components
for
tightness,
(spring
coupler bolts, steering arm locking
bolts, tie rods, ball joints, etc.l. Tighten
if necessary.
+
W A RNING: Do not lubricate
throttle and / or brake cables and
housings.
Coat electrical connections and switch-
es with a greaseless metal protector. If
unavailable, use petroleum jelly.
22
Clean the vehicle thoroughly, removing
all dirt and grease accumulation.
_
CAUTION: Plastic alloy cornpo-
.". nents such as fuel tank, wind-
shield, etc., can be cleaned using mild
detergents or isopropyl alcohol. Do not
use strong soaps, degreasing solvents,
abrasive cleaners, paint thinners, etc.
Inspect cab and repair damage. Repair
kits are available at your authorized
dealer. Clean frame. (Use only "Alu-
minum cleaner" and tollowinstructions
on containerl.
Touch up all metal spots where paint
has been scratched off. Spray all bare
metal parts of vehicle with metal pro-
tector. Wax the cab for better pro-
tection.
O
NOTE: Apply wax on glossy fin-
ish of cab only. Protect the vehi-
cle with a Ski-Doo cover to prevent
dust accumulation during storage.
_
CAUTION: If for some reason
.". the snowmobile has to be stored
outside it is necessary to cover it with
an opaque tarpaulin. This caution will
prevent the sun rays affecting the plas-
tic components and the vehicle finish.
Check electrical wiring and compo-
nents, retighten loose connections.
Check for stripped wires or damaged
insulation.
Thoroughly inspect the vehicle and
tighten loose bolts, nuts and linkage.
O
NOTE: Leave drive belt off pul-
leys for the entire storage period.
Advertisement
