Basic Safety Measures - HADEF 340/15 Installation, Operating And Maintenance Instruction

 Defective devices and load suspension devices must not be used until they have been repaired! Only
original spare parts must be used. Non-compliance will result in any warranty claims becoming void.
 Liability and warranty will become void if unauthorized modifications of the units are made by the user!
 The permissible ambient temperature when operating the devices:
Type of drive
Manually driven
Motor driven
) * At an atmospheric pressure range from 0.8bar to 1.1bar and an oxygen content of approx. 21%
) ** Devices of this category have been specially modified and labeled by the manufacturer
DANGER!
The permissible ambient temperature must not be exceeded!
A manually slewing of jib.
Jib range of wall mounted cranes 180° when mounted at the wall.
Jib range of jib cranes 270°.
The cranes are adequate for using with manually and electrical hoisting units up to the maximum rated load.
NOTICE!
If the units are not used appropriately, it is not possible to ensure safe operation.
The owner and operator have sole liability for all personal injury and damage to property arising from
inappropriate use.
DANGER!
In particular, use is not permitted:

for tearing loose fixed loads, dragging of loads as well as diagonal pulling
 for pulling against a fixed point without additional safety and/or measuring equipment against exceeding
the nominal load
 in potentially explosive atmospheres, unless the equipment has been modified for this purpose and
this is shown on special type plates it carries for this purpose.

in reactor containments

for transporting persons

for holding lifted loads

for scenic use

when persons are under suspended loads
2.5

Basic safety measures

 Observe installation-, operation and maintenance instruction.
 Take notice of caution notes at units and in the manual
 Observe safety distances.
 Take care for a free view on the load.
 Only use the hoists appropriately.
 The equipment is to be used exclusively for movement of goods. Under no circumstances my persons be
moved.
 Never load the devices beyond their working load limit.
 Pay attention to the accident prevention regulations (UVV).
 Should the hoist be used outside of Germany, please pay attention to the national regulations that apply.
 Supporting structures and load-attached devices used in conjunction with this equipment must provide an
adequate safety factor to handle the rated load plus the weight of the equipment. In case of doubt, consult
a structural engineer.
5.52.734.00.01.00
Device classification for
not explosive atmosphere
-20°C/+50°C
-20°C/+40°C
Explosive atmosphere
)* )**
according to ATEX
-20°C/+40°C
-20°C/+40°C
5