Advertisement
Quick Links
Operators Manual
2.5 GPM
HIGH PRESSURE WASHER
CLEANING SYSTEM
Model No. 580.768030
HOURS: Mon. - Fri. 8 a.m. to 5 p.m. (CT)
CAUTION:
Before using this product, read this
manual and follow all its Safety Rules
and Operating Instructions.
Sears, Roebuck
and Co., Hoffman
Estates, IL 60179
Visit our Craftsman website: www.sears.GomJcmftsmen
•
Safety
•
Assembly
•
Operation
•
Maintenance
•
Parts
Part No. B3595 D_tt $ (4/5/1999) Pr;.rttsd i n _
U.S.A.
Advertisement
Related Manuals for Craftsman 580.768030
Summary of Contents for Craftsman 580.768030
- Page 1 Before using this product, read this manual and follow all its Safety Rules and Operating Instructions. Sears, Roebuck and Co., Hoffman Visit our Craftsman website: www.sears.GomJcmftsmen Part No. B3595 D_tt $ (4/5/1999) Pr;.rttsd i n _ Estates, IL 60179 U.S.A. •...
- Page 2 LIMITED ONE YEAR WARRANTY For one year from the date of purchese, when t_is Craftsman Cleaning System is maintained and operated according to the instructions in the owner's manual, Sears will repair, free of charge, any defect in material and workmanship.
- Page 3 • Operate engine onlyatgovemed speed.Running theengine at excessive speeds increases the hazard of personal injury. Do not tamper with parts which may increase or decrease the governed speed. • Do not wear loose clothing, jewelry or anything that may be caught in the starter or other rotating parts.
- Page 4 Check carton for additional loose parts HOW TO SET UP YOUR PRESSURE WASHER For the most part, your Craftsman High Pressure Cleaning System has been assembled at the factory You must, however, assemble the spray gun, and attach the high pressure hose to the spray gun •...
- Page 5 Gas Cap - Fill engine with regular unleaded gasoline here. High Pressure Hose - Connect one end to the spray gun. WASHER Gas Cap Pump Pressure Commend Oil Fill Cap - Fill engine with oil here. See page 7 for oil recommendations.
- Page 6 Read these instructions and learn how to use your cleaning system before you attempt to start your cleaning system. If you have any problems operating your cleaning system, please call the pressure washer helpline at 1-800-222-3136. How To Use the Adjustable Nozzle...
- Page 7 Allow detergent to 'soak in' (between 3-5 minutes) before washing and rinsing. Reapply as needed to prevent surface from drying. Wash and Rinse Surface This Craftsman Cleaning System permits regulatLonof output water pressure by varying the engine speed. The Pressure Command found on the front panel...
- Page 8 Toaddfueltoengine: • Clean area around fuel cap, remove cap. • Add regular unleaded gasoline, slowly, to the fuel tank. Important: Never mix oil with gasoline. • Install fuel cap and wipe up any spilled gasoline. TO START THE CLEANING The best way to start your cleaning system engine for the first time is to follow these instructionsstep-by- step.
- Page 9 Once the engine has started, disengage the slSray gun safety latch. HOW TO STOP YOUR PRESSURE WASHER Important: Do not run pump without the water supply connected and turned on. You must follow this caution or the pump will be damaged.
- Page 10 Change oil after the first (2) opera_ng hours and every 50 hours thereafter. Change sooner when operating under dirty or dusty conditions. "* Replace more often under dirty or dusty conditions. PRODUCT SPECIFICATIONS Pressure Washer Specifications PRESSURE FLOW RATE CHEMICAL WATER...
- Page 11 Check gun and wand assembly for leaks. Purge pump of air and contaminants. • Check engine oil level. PRESSURE WASHER MAINTENANCE Check and Clean Inlet Screen Examine garden hose inlet screen. Clean if it is, clogged or replace if it is tom.
- Page 12 Note: The above two o-rings are close in size. Please match carefully to assure proper o--,ring usage. • 1 rubber washer (p/n B2385) for the inside of the garden hose connector. • 1 water inlet screen (p/n B2384) for the garden hose connector.
- Page 13 ENGINE MAINTENANCE Maintenance, replacement or repair of the emission control devices and systems may be performed by any non-road engine repair establishment or individual. Checldng Oil Level Oil level should be chocked prior to each use or at least every 5 hours of operation. Keep oil level maintained.
- Page 14 Pour RV-Antifreeze (antifreeze without alcohol) into the hose. Pull the recoil handle twice. LONG TERM STORAGE If you do not plan to use the Pressure Washer for more than 30 days, you must prepare the engine for long term storage.
- Page 15 PROBLEM Pump has toilownng problems: failure to produce pressure, or erratic pressure, chattedng, loss of pressure, Lowwater volume. Detergent fails to mix. Engine runs good when not spraying but dies when you begin to spray. Engine will not start; or starts and runs rough Engine shuts down during operation...
- Page 17 Tecumseh 6HP Enduro, Model #143.996005 310 -- 250A...
- Page 18 Tecumseh 6HP Enduro, Model #143.996005 37O4 200~ 1BS _'_ 370K...
- Page 19 Screw, 10-32 x 1FZ" 651008 Screw, 1/4-20 x 31/64" Muffler 36722 650988 Screw, 1/4-20 x 2-9132" 36674 Spacer Nut & Lock Washer 650852 Heat Shield 36893 35985B Starter Cup Rivet (Can be purchased _ocally) Fuel Line 30705 Fual Line Clamp...
- Page 20 Dust Seal (Throttle) 631036 Throttle Shutter 650506 Shutter Screw 31868 Choke Shaft & Lever Assembly 632042 Choke Return Spring 631184 Dust Seal Washer (Choke) 631183 Dust Seal (Choke) 631890 Choke Shutter 630735 Choke Positioning Spring 632164 Fuel Fitting 651025 Throttle Crack Screw/Idle Speed...
- Page 21 Tecumseh 6HP Enduro, Model #143.996005 Pa_# 590736 Rewind Starter 590599A Spring Pin (Incl. 4) 590600 Washer 690696 Retainer 590601 Washer 590697 Brake Spring 590698 Starter Dog 590699 Dog Spring 590700 Pulley & Rewind Spring Ass'y. 590705 Starter Housing Ass'y. 59O535 Starter Rope (98"...
- Page 22 Craftsman 2250 PSI Cleaning System 580.768030 Pump 13,1...
- Page 23 Craftsman 2250 PSI Cleaning System 580.768030 Pump Nern Part# Qtv Descr_bn B2218 O-RING, 1.625"x 0.103 B2260 ADAPTER, Engine B2217 O-RING, 0239 ID x 0.0-/0 B2261B SCREW, ButtonHd 5/16 - 24 x 3/4" Lg 96400 SPRING, PistonReturn 99735 ASSEMBLY,Oil Bmalher 93790 O-RING, 114x 119x 2.6...
- Page 24 Craftsman 2250 PSI Cleaning System 580.768030 Main Unit...
- Page 25 CAP, Vinyl Black B2759 HOOK, Square Neck Gun B3741 AXLE ROD, 1/2" ,x 21.53" B1760 ASSY., Wheel & Tire 10" 75402 PUSHNUT, 1/2" 52858 NUT, M8 - 1.25 Locking System 580.768030 item Part_# 27007 50190 42909 97100 21424 • , B3700D A1408...
- Page 26 CALIFORNIA & US EPA EMISSION CONTROL WARRANTY STATEMENT The U.S. Environmental Protection Agency ("EPA"), the Calitomla Air Resources Board ("CARB") and Tecumseh Products Co. are pleased to explain the Federal and Caiifomia Emission Control Systems Warranty on your new utilityor lawn and garden equipment engine. In California, new 1995 and later utility and lawn and garden equipment engines must be designed, built and equipped to meet the State's stringent anti-smog standards.
- Page 27 EMISSION CONTROL SYSTEM WARRANTY Emission Control System Warranty (=ECS Warranty') for 1995 and later model year Califomia utility and lawn and garden equipment engines (for other states, 1997 and later model year engines): A. Applicability: This warranty shall apply to 1995 and ister model year Califomis utilityand lawn and garden equipment engines (tor other states, 1997 and later model year engines.) The ECS Warranty Period shall begin on the date...
- Page 28 For in-home major brand repair service: Call 24 hours a day, 7 days a week 1-800-4-MY-HOME" (1-800-469-4663) Para pedir servicio de reparack_n a domicilio - t-800-676-5811 In Canada for all your service and parts needs call - 1-800-665-4455 Au Canada pour tout fe service ou les pi_ces For the repair or replacement parts you need: _Call 7 am - 7 pm, 7 days a week 1-800-366-PART...