Related Manuals for JAYLINE SS280
Summary of Contents for JAYLINE SS280
- Page 1 JAYLINE SS280 & SS600 FREESTANDING WOOD FIRE INSTALLATION & OPERATION INSTRUCTIONS NOVEMBER 2012...
-
Page 2: Installation
INSTAllATION OF yOuR JAylINE WOOD FIRE Jayline recommends you use a qualified solid fuel heater installer or a registered plumber to install your fire. Your dealer or heating specialist will be able to help with recommendations as well as advise on permits/consents required for the installation in your area. - Page 3 6mm x 50mm dynabolts. BAFFlE Before lighting your appliance for the first time, make sure the baffle is in the correct position being as far to the rear as possible. NOVEMBER 2012 www.jayline.co.nz page 3...
- Page 4 BEEN APPROVED IN WRITING BY THE TESTING AUTHORITY IS CONSIDERED TO BE IN BREACH OF THE APPROVAL GRANTED FOR COMPLIANCE WITH AS/NZS 4013:1999. 3. PLEASE ENSURE THAT ONLY COMPONENTS APPROVED BY JAYLINE ARE USED FOR THE INSTALLATION AS SUBSTITUTES MAY ADVERSELY AFFECT PERFORMANCE AND MIGHT NULLIFY COMPLIANCE WITH THE REQUIREMENTS OF AS/NZS 2918:2001.
- Page 5 CORRECT OpERATION OF yOuR JAylINE WOOD FIRE Simply by burning your Jayline fire correctly, you can improve efficiency, reduce fuel consumption and minimise air pollution. STARTING A NEW FIRE Please note: If lighting the fire for the first time, dust fire, glass, trim and flue before firing to avoid particles sticking or discolouring.
- Page 6 7 (loaded front to back). Try to avoid smothering the fire with the new pieces. Placing the pieces on the burning kindling can help prevent smothering. Your Jayline heater requires approximately 45-60 minutes to preheat the steel firebox before it can effectively emit heat into the room.
- Page 7 (AS vIEWED FROM DOOR) Fire in cycles: Don’t expect perfectly steady heat output from your Jayline heater. Solid fuel heaters burn in cycles. A cycle is the time between the ignition of a load from charcoal and the consumption of the load back to a coal bed.
- Page 8 Correctly installed and operated, Jayline solid fuel heaters do not spill smoke into the house. There are three main reasons why some woodstoves smoke: Bad installation design: Incorrect flue installation, resulting in low flue temperatures and low draught, can make a wood heater more likely to spill smoke.
- Page 9 During the summer, as warm breezes flow through the stacks, carrying away the evaporating water, the moisture content of the wood will fall to around 20 per cent. At this moisture content the wood is ready for burning. NOVEMBER 2012 www.jayline.co.nz page 9...
-
Page 10: Burning Coal
(6 in.) across the largest dimension and a range of smaller pieces will be needed for effective stoking. Maximum log length varies according to model. BuRNING COAl Due to their construction, the burning of coal in Jayline solid fuel heaters is prohibited. Please also refer to ‘Exclusions’ in the Warranty Page 13. JAylINE WOOD FIRE MAINTENANCE To keep your fire burning clean and efficient it is important that you carry out regular maintenance. - Page 11 Flue pipes can deteriorate very quickly with incorrect firing. WARNINGS Below is a list of warnings to ensure efficient and safe operation of your Jayline wood fire: • WARNING: DO NOT USE FLAMMABLE LIQUIDS OR AEROSOLS TO START OR REKINDLE THE FIRE.
- Page 12 We select only certain companies to act as our Jayline dealers. They must have high standards and be able to provide a total service both pre and post sale to you the customer. Therefore we have every confidence that our dealers will be able to answer your questions or fix any problem that may occur.
- Page 13 Any repairs undertaken without the written authority of the Manufacturer will invalidate this warranty. If a Water Booster is fitted (Rural models only), it must be a Jayline Water Booster in order to be warranted. The warranty is only valid to the initial purchaser of the product.
-
Page 15: Warranty Card
RETAIL LINKS LTD PO BOX 9056 ANNESBROOK, 7044 NELSON NAME: _____________________________________________________________________________ ADDRESS: ___________________________________________________________________________ ____________________________________________________________________________________ ____________________________________________________________________________________ EMAIL: ________________________________________ PHONE: _______________________________ JAYLINE MODEL: ________________________________________________________________________ SERIAL NUMBER: _______________________________________________________________________ DATE PURCHASED: ____________________________________________________________________ PURCHASED FROM: ____________________________________________________________________ DATE INSTALLED: _____________________________________________________________________ INSTALLED BY: _____________________________________________________________________ NOVEMBER 2012 www.jayline.co.nz...