Related Manuals for JAYLINE CLEAN AIR
Summary of Contents for JAYLINE CLEAN AIR
- Page 1 JAYLINE CLEAN AIR FREESTANDING WOOD FIRE OWNERS MANUAL & INSTALL INSTRUCTIONS Please leave this information with the appliance SEE INSIDE TO REGISTER YEAR FOR YOUR 15 YEAR WARRANTY. NOVEMBER 2017...
-
Page 2: Installation
Keep this booklet as a reference guide. INSTALLATION OF YOUR JAYLINE WOOD FIRE Jayline recommends you use a suitably qualified installation technician to install your fire. Your dealer or heating specialist will be able to help with recommendations as well as advise on permits/consents required for the installation in your area. - Page 3 6mm x 50mm dynabolts. BAFFLE Before lighting your appliance for the first time, make sure the baffle is in the correct position being as far to the rear as possible, and ensure all packing material has been removed. www.jayline.co.nz page 3 NOVEMBER 2017...
- Page 4 Example: • Side wall clearance for the Jayline FR300 is 290mm • A 12mm gapped shield on the wall with a factor of 0.40 • Calculate: 290mm x 0.40 = 116mm (This is the new sidewall minimum clearance) •...
- Page 5 BEEN APPROVED IN WRITING BY THE TESTING AUTHORITY IS CONSIDERED TO BE IN BREACH OF THE APPROVAL GRANTED FOR COMPLIANCE WITH AS/NZS 4013:1999. 3. PLEASE ENSURE THAT ONLY COMPONENTS APPROVED BY JAYLINE ARE USED FOR THE INSTALLATION AS SUBSTITUTES MAY ADVERSELY AFFECT PERFORMANCE AND MIGHT NULLIFY COMPLIANCE WITH THE REQUIREMENTS OF AS/NZS 2918:2001.
- Page 6 CORRECT OPERATION OF YOUR JAYLINE WOOD FIRE Simply by burning your Jayline fire correctly, you can improve efficiency, reduce fuel consumption and minimise air pollution. STARTING A NEW FIRE Please note: If lighting the fire for the first time, dust fire, glass, trim and flue before firing to avoid particles sticking or discolouring.
- Page 7 7 (loaded front to back). Try to avoid smothering the fire with the new pieces. Placing the pieces on the burning kindling can help prevent smothering. Your Jayline heater requires approximately 45-60 minutes to preheat the steel firebox before it can effectively emit heat into the room.
- Page 8 (AS VIEWED FROM DOOR) Fire in cycles: Don’t expect perfectly steady heat output from your Jayline heater. Solid fuel heaters burn in cycles. A cycle is the time between the ignition of a load from charcoal and the consumption of the load back to a coal bed.
- Page 9 Correctly installed and operated, Jayline solid fuel heaters do not spill smoke into the house. There are three main reasons why some woodstoves smoke: Bad installation design: Incorrect flue installation, resulting in low flue temperatures and low draught, can make a wood heater more likely to spill smoke.
- Page 10 PLEASE NOTE: WOOD WITH A MOISTURE CONTENT OF 10-25% IS THE RECOMMENDED WOOD TO USE IN CLEAN AIR ZONES Kiln dried fuel (less than 10%) will not burn for as long as seasoned wood. Firewood should be cut and split in the early spring and stacked under cover, with good ventilation, to be ready for burning when required.
-
Page 11: Burning Coal
(6 in.) across the largest dimension and a range of smaller pieces will be needed for effective stoking. Maximum log length varies according to model. BURNING COAL Due to their construction, the burning of coal in Jayline solid fuel heaters is prohibited. Please also refer to ‘Exclusions’ in the Warranty Page 14. JAYLINE WOOD FIRE MAINTENANCE To keep your fire burning clean and efficient it is important that you carry out regular maintenance. - Page 12 Flue pipes can deteriorate very quickly with incorrect firing. CONSUMABLES Some parts of your Jayline fire are considered consumable. They are designed to be replaced as they will degrade over time. The life of the consumables will vary depending on;...
- Page 13 WARNINGS Below is a list of warnings to ensure efficient and safe operation of your Jayline wood fire: • WARNING: DO NOT USE FLAMMABLE LIQUIDS OR AEROSOLS TO START OR REKINDLE THE FIRE.
- Page 14 We select only certain companies to act as our Jayline dealers. They must have high standards and be able to provide a total service both pre and post sale to you the customer. Therefore we have every confidence that our dealers will be able to answer your questions or fix any problem that may occur.
- Page 15 JAYLINE WOOD FIRE WARRANTY 15 YEARS (conditional) Congratulations on the purchase of your Jayline Wood fire. You must register your fire by email or post within 30 days of installation to validate the guarantee (this registration card is in your install/operation guide).
- Page 16 JAYLINE WOOD FIRE - SERVICE REGISTER Jayline recommends NZHHA registered service technicians To ensure many years of performance and safety with your Jayline Fire, we have outlined the key servicing requirements that form part of routine annual servicing. Maintenance of parts that protect your firebox will extend the life of your fire, ensuring it burns clean and correctly.
-
Page 17: Product Registration
TO ACTIVATE YOUR 15 YEAR WARRANTY, PLEASE COMPLETE AND RETURN WITHIN 30 DAYS OF INSTALLATION TO: Or complete your product registration online RETAIL LINKS LTD PO BOX 9056 ANNESBROOK, 7044 www.jayline.co.nz/manuals-technical/#register NELSON NAME: ________________________________________________________________________ ADDRESS: ____________________________________________________________________ ______________________________________________________________________________ ______________________________________________________________________________ EMAIL: ________________________________________ PHONE: ________________________...