Related Manuals for Yamaha Neo's 4 YN50F
Summary of Contents for Yamaha Neo's 4 YN50F
- Page 1 Read this manual carefully before operating this vehicle. OWNER’S MANUAL YN50F/YN50FM -F8199-E0...
- Page 2 EAU46090 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
- Page 3 Welcome to the Yamaha world of motorcycling! As the owner of the YN50F/YN50FM, you are benefiting from Yamaha’s vast experience and newest technology regar- ding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability.
- Page 4 IMPORTANT MANUAL INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death.
- Page 5 IMPORTANT MANUAL INFORMATION EAUS1172 YN50F/YN50FM OWNER’S MANUAL ©2012 by 1st edition, 2012 All rights reserved. Any reprinting or unauthorized use without the written permission of is expressly prohibited. Printed in...
-
Page 6: Table Of Contents
TABLE OF CONTENTS Starting off ........5-2 Checking the front brake pads SAFETY INFORMATION .....1-1 Further safe-riding points ....1-5 Acceleration and deceleration ..5-2 and rear brake shoes ....6-17 Braking..........5-3 Checking the brake fluid level ..6-18 Tips for reducing fuel consumption..5-3 Changing the brake fluid ....6-19 DESCRIPTION........2-1 Left view ...........2-1 Engine break-in.........5-4... - Page 7 TABLE OF CONTENTS Storage ..........7-3 SPECIFICATIONS .......8-1 CONSUMER INFORMATION .....9-1 Identification numbers ......9-1...
-
Page 8: Safety Information
SAFETY INFORMATION EAUT1016 each time you use the vehicle to through intersections, since Be a Responsible Owner make sure it is in safe operating con- intersections are the most As the vehicle’s owner, you are res- dition. Failure to inspect or maintain likely places for scooter acci- ponsible for the safe and proper ope- the vehicle properly increases the... - Page 9 SAFETY INFORMATION due to excessive speed or under- Never ride under the influence of feet. The engine or exhaust sys- cornering (insufficient lean angle alcohol or other drugs. tem become very hot during or for the speed). This scooter is designed for on- after operation and can cause •...
- Page 10 Yamaha accessories, which are avai- tribute the weight as evenly as of the scooter is changed. To avoid lable only from a Yamaha dealer, have possible on both sides of the the possibility of an accident, use been designed, tested, and approved...
- Page 11 SAFETY INFORMATION modifications not specifically recom- does not in any way reduce improper position limits the fre- mended by Yamaha, even if sold and ground clearance or cornering edom of movement of the ope- installed by a Yamaha dealer. clearance, limit suspension tra-...
-
Page 12: Further Safe-Riding Points
SAFETY INFORMATION Remove all loose items from the EAU10372 Always wear a helmet, gloves, Further safe-riding points scooter. trousers (tapered around the cuff Be sure to signal clearly when Point the front wheel straight and ankle so they do not flap), making turns. -
Page 13: Description
DESCRIPTION EAU10410 Left view 1. Storage compartment (page 3-11) 2. Final transmission oil filler cap (page 6-11) 3. Brake lever free play adjusting nut (page 6-17) 4. Final transmission oil drain bolt (page 6-11) 5. Kickstarter (page 3-10) 6. Air filter element (page 6-13) 7. -
Page 14: Right View
DESCRIPTION EAU10420 Right view 1. Grab bar (page 5-2) 9. Coolant reservoir (page 6-12) 2. Fuel tank cap (page 3-7) 10. Engine oil dipstick (page 6-8) 3. Seat (page 3-11) 11. Centerstand (6-21) 4. Battery (page 6-23) 5. Fuses (page 6-24) 6. -
Page 15: Controls And Instruments
DESCRIPTION EAU10430 Controls and instruments 1. Rear brake lever (page 3-7) 2. Left handlebar switches (page 3-6) 3. Multi-function display (page 3-3) 4. Right handlebar switch (page 3-6) 5. Throttle grip (page 6-14) 6. Front brake lever (page 3-7) -
Page 16: Instrument And Control Functions
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 To lock the steering Main switch/steering lock All electrical systems are off. The key can be removed. EWA10061 WARNING Never turn the key to “OFF” or “LOCK” while vehicle moving. Otherwise the electrical systems will be switched off, which may result in loss of control or an 1. -
Page 17: Indicator And Warning Lights
3. Turn signal indicator light “ ” “ON”, or if the warning light remains 4. Fuel level warning light “ ” “OFF” while still pushing it. on, have a Yamaha dealer check the 5. Engine trouble warning light “ ” electrical circuit. EAU11020 Turn signal indicator light “... -
Page 18: Multi-Function Display
“ON”, or if the warning light remains go off. on, have a Yamaha dealer check the If the warning light does not come on electrical circuit. initially when the key is turned to ECA10021 “ON”, or if the warning light remains... - Page 19 INSTRUMENT AND CONTROL FUNCTIONS All LCD segments and warning 3. To change the minutes digits, lights come on and then go off. Be sure to turn the key to “ON” push the button for at least three before using the button. seconds.
- Page 20 INSTRUMENT AND CONTROL FUNCTIONS Odometer and tripmeter modes Pushing the button switches the dis- play between the odometer mode “ODO” and the tripmeter “TRIP” in the following order: RESET/ RESET/ TRIP SELECT SELECT RESET/ SELECT To reset a tripmeter, select it by pus- hing the button, and then push it Fuel gauge RESET/...
-
Page 21: Handlebar Switches
To signal a right-hand turn, push this ning indicator will flash. If this occurs, switch to “ ”. To signal a left-hand have a Yamaha dealer check the vehi- turn, push this switch to “ ”. When cle. released, the switch returns to the center position. -
Page 22: Front Brake Lever
INSTRUMENT AND CONTROL FUNCTIONS EAU12900 EAU12950 EAU13192 Front brake lever Rear brake lever Fuel tank cap 1. Front brake lever 1. Rear brake lever 1. Fuel tank cap The front brake lever is located on the The rear brake lever is located on the To remove the fuel tank cap right handlebar grip. -
Page 23: Fuel
INSTRUMENT AND CONTROL FUNCTIONS To install the fuel tank cap EAU13221 Fuel 1. Insert the fuel tank cap into the Make sure there is sufficient gasoline tank opening and turn it clockwi- in the tank. EWA10881 WARNING Gasoline and gasoline vapors are extremely flammable. -
Page 24: Fuel Tank Breather/Overflow Hose
Your Yamaha engine has been desig- ned to use regular unleaded gasoline with a research octane number of 91... -
Page 25: Catalytic Converter
INSTRUMENT AND CONTROL FUNCTIONS EAU13433 ECA10701 EAU13680 Catalytic converter NOTICE Kickstarter This model is equipped with a cataly- Use only unleaded gasoline. The tic converter in the exhaust system. use of leaded gasoline will cause EWA10862 unrepairable damage to the cataly- WARNING tic converter. -
Page 26: Seat
INSTRUMENT AND CONTROL FUNCTIONS EAU13932 EAUM1191 Seat Storage compartment To open the seat 1. Place the scooter on the centers- tand. 2. Insert the key into the main switch, and then turn it counter- clockwise to “OPEN”. 1. Seat open position To close the seat 1. -
Page 27: Luggage Hook
INSTRUMENT AND CONTROL FUNCTIONS ECA10080 EAUT1072 NOTICE Luggage hook Some helmets cannot be stored EWAT1031 in the storage compartment Keep the following points in mind WARNING because of their size or shape. when using the storage compart- Do not exceed the load limit of Do not leave your scooter unat- ment. -
Page 28: For Your Safety - Pre-Operation Checks
Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures pro- vided in this manual, have the vehicle inspected by a Yamaha dealer. Before using this vehicle, check the following points:... - Page 29 • Make sure that operation is smooth. • Check cable free play. Throttle grip 6-14, 6-20 • If necessary, have Yamaha dealer adjust cable free play and lubricate cable and grip housing. • Make sure that operation is smooth. 6-19 Control cables •...
-
Page 30: Operation And Important Riding Points
This model is equipped with a lean there is a control or function you do angle sensor to stop the engine in not understand, ask your Yamaha See page 5-4 for engine break-in case of a turnover. To start the engine dealer. -
Page 31: Starting Off
OPERATION AND IMPORTANT RIDING POINTS EAU16761 4. Check for oncoming traffic, and EAU16780 Starting off Acceleration and then slowly turn the throttle grip deceleration (on the right) in order to take off. 5. Switch the turn signals off. Before starting off, allow the engine to warm up. -
Page 32: Braking
OPERATION AND IMPORTANT RIDING POINTS EAU16793 Front EAU16820 Braking Tips for reducing fuel EWA10300 consumption WARNING Fuel consumption depends largely on Avoid braking hard or suddenly your riding style. Consider the follo- (especially when leaning over wing tips to reduce fuel consumption: to one side), otherwise the sco- Avoid high engine speeds during oter may skid or overturn. -
Page 33: Engine Break-In
During this period, prolonged immediately have a Yamaha dealer Do not park on a slope or on full-throttle operation or any condition check the vehicle. -
Page 34: Periodic Maintenance And Adjustment
To avoid possible burns, let service or while using the vehicle. If brake components cool before tou- you are not familiar with vehicle ching them. service, have a Yamaha dealer per- form service. -
Page 35: Periodic Maintenance Chart For The Emission Control System
From 30000 km (17500 mi), repeat the maintenance intervals starting from 6000 km (3500 mi). Items marked with an asterisk should be performed by a Yamaha dealer as they require special tools, data and technical skills. -
Page 36: General Maintenance And Lubrication Chart
PERIODIC MAINTENANCE AND ADJUSTMENT EAU17717 General maintenance and lubrication chart ODOMETER READING CHECK OR ANNUAL ITEM MAINTENANCE JOB CHECK 1000 km 6000 km 12000 km 18000 km 24000 km (600 mi) (3500 mi) (7000 mi) (10500 mi) (14000 mi) 1 * Air filter element •... - Page 37 PERIODIC MAINTENANCE AND ADJUSTMENT ODOMETER READING CHECK OR ANNUAL ITEM MAINTENANCE JOB CHECK 1000 km 6000 km 12000 km 18000 km 24000 km (600 mi) (3500 mi) (7000 mi) (10500 mi) (14000 mi) • Check bearing play and steering for roughness. 9 * Steering bearings •...
- Page 38 PERIODIC MAINTENANCE AND ADJUSTMENT ODOMETER READING CHECK OR ANNUAL ITEM MAINTENANCE JOB CHECK 1000 km 6000 km 12000 km 18000 km 24000 km (600 mi) (3500 mi) (7000 mi) (10500 mi) (14000 mi) 20 * V-belt • Replace. Every 10000 km (6000 mi) Front and rear brake •...
-
Page 39: Removing And Installing The Cowling And Panel
PERIODIC MAINTENANCE AND ADJUSTMENT EAU18741 Removing and installing the cowling and panel The cowling and panel shown above need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling or panel needs to be removed and installed. -
Page 40: Checking The Spark Plug
To install the panel operating improperly. Do not attempt Place the panel in the original posi- to diagnose such problems yourself. tion, and then install the screw. Instead, have a Yamaha dealer check 1. Spark plug cap the vehicle. -
Page 41: Engine Oil And Oil Strainer
PERIODIC MAINTENANCE AND ADJUSTMENT 2. Check the spark plug for electro- 2. Clean the surface of the spark EAUS1481 Engine oil and oil strainer de erosion and excessive carbon plug gasket and its mating surfa- The engine oil level should be chec- or other deposits, and replace it if ce, and then wipe off any grime ked before each ride. - Page 42 PERIODIC MAINTENANCE AND ADJUSTMENT 3. Wait a few minutes until the oil settles, remove the oil filler cap, wipe the dipstick clean, insert it back into the oil filler hole (wit- hout screwing it in), and then remove it again to check the oil level.
- Page 43 PERIODIC MAINTENANCE AND ADJUSTMENT 1. While the key is turned to “ON”, Tightening torque: hold the button pushed more Engine oil drain bolt A: than eight seconds. 23 Nm (2.3 m•kgf, 16.6 ft•lbf) 2. Release the button, and the oil Engine oil drain bolt B: change indicator will go off.
-
Page 44: Final Transmission Oil
Make sure that no oil ride. If any leakage is found, have a gets on the tire or wheel. [EWA11311] Yamaha dealer check and repair the scooter. In addition, the final trans- Tightening torque: mission oil must be changed as... -
Page 45: Coolant
If water has been positioned straight up when added to the coolant, have a checking the coolant level. A Yamaha dealer check the anti- slight tilt to the side can result in freeze content of the coolant a false reading. -
Page 46: Replacing The Air Filter Element And Cleaning The Check Hose
2. Pull the air filter element out. check hose maintenance and lubrication chart. 3. Insert a new air filter element into Have a Yamaha dealer change the the air filter case as shown. coolant. WARNING! Never attempt NOTICE: Make sure that the air... -
Page 47: Checking The Throttle Grip Free Play
To prevent cle, note the following points regar- this from occurring, the valve clearan- ding the specified tires. ce must be adjusted by a Yamaha dealer at the intervals specified in the Tire air pressure periodic maintenance and lubrication chart. - Page 48 After extensive tests, only the tires lis- Front: 175 kPa (1.75 kgf/cm ted below have been approved for 25 psi, 1.75 bar) this model by Yamaha Motor Co., Ltd. Rear: ZAUM0054 200 kPa (2.00 kgf/cm 29 psi, 2.00 bar) 1. Tire tread depth 90-163 kg (198-359 lb) 2.
-
Page 49: Cast Wheels
Besides lever free play and, if necessary, have An unbalanced wheel can result being illegal, operating the a Yamaha dealer check the brake sys- in poor performance, adverse vehicle with excessively worn tem. handling characteristics, and a... -
Page 50: Adjusting The Rear Brake Lever Free Play
If a brake pad is damaged or if adjusting nut in direction (b). the lining thickness is less than 3.1 mm (0.12 in), have a Yamaha dealer replace the brake pads as a set. 6-17... -
Page 51: Checking The Brake Fluid Level
If ches the wear limit mark, have a the brake fluid level is low, be sure to Recommended brake fluid: Yamaha dealer replace the brake sho- check the brake pads for wear and DOT 4 es as a set. -
Page 52: Changing The Brake Fluid
If a cable is Brake fluid may deteriorate pain- damaged or does not move smoothly, ted surfaces or plastic parts. have a Yamaha dealer check or repla- Always clean up spilled fluid ce it. WARNING! Damage to the immediately. -
Page 53: Checking And Lubricating The Throttle Grip And Cable
Front brake lever Recommended lubricants: In addition, the cable should be lubri- Front brake lever: cated by a Yamaha dealer at the inter- Silicone grease vals specified in the periodic mainte- Rear brake lever: Lithium-soap-based grease nance chart. -
Page 54: Checking And Lubricating The Centerstand
If the centerstand does not move front fork compresses up and down smoothly, have a rebounds smoothly. Yamaha dealer check or repair it. Otherwise, the centerstand could contact the ground and distract the operator, resulting in a possible loss of control. 6-21... -
Page 55: Checking The Steering
2. Hold the lower ends of the front have a Yamaha dealer check or fork legs and try to move them repair it. forward and backward. If any free play can be felt, have a Yamaha dealer check or repair the stee- ring. 6-22... -
Page 56: Battery
PERIODIC MAINTENANCE AND ADJUSTMENT EAUS1800 contains minerals that are Battery Make sure that the scooter is positio- harmful to the battery. [ECA10611] EWA10760 ned straight up when checking the WARNING electrolyte level. Electrolyte is poisonous and 2. Remove panel A. (See page 6-6). dangerous since it contains 3. -
Page 57: Replacing The Fuse
PERIODIC MAINTENANCE AND ADJUSTMENT KEEP THIS AND ALL BATTE- connected to the battery termi- EAUT2023 Replacing the fuse RIES OUT OF THE REACH OF nals and that the breather hose is CHILDREN. properly routed, in good condi- tion, and not obstructed. NOTI- 5. -
Page 58: Replacing The Headlight Bulb
NOTICE the electrical circuits to check if transparency of the glass, the It is advisable to have a Yamaha the devices operate. luminosity of the bulb, and the dealer perform this job. 4. If the fuse immediately blows... -
Page 59: Replacing A Front Turn Signal Light Bulb
Replacing a front turn signal der, and then remove the burnt- light bulb out bulb. ECA10670 NOTICE It is advisable to have a Yamaha dealer perform this job. 1. Place the scooter on the centers- tand. 2. Remove cowling A. (See page 1. Cowling 6-6). -
Page 60: Replacing A Turn Signal Light Bulb Or The Tail/Brake Light Bulb
PERIODIC MAINTENANCE AND ADJUSTMENT 5. Insert a new bulb into the socket, EAU24283 Replacing a turn signal light push it in, and then turn it clock- bulb or the tail/brake light wise until it stops. 6. Install the socket (together with bulb the bulb) by turning it clockwise. -
Page 61: Replacing The License Plate Light Bulb
PERIODIC MAINTENANCE AND ADJUSTMENT EAUS1151 EAU45462 Replacing the license plate Replacing the auxiliary light light bulb (Depens on bulb (Depends on models) If the auxiliary light bulb burns out, models) replace it as follows. 1. Remove the lens by removing the 1. -
Page 62: Troubleshooting
The following troubleshooting charts represent quick and easy procedures for checking these vital systems your- self. However, should your scooter require any repair, take it to a Yamaha dealer, whose skilled technicians have the necessary tools, experience, and know-how to service the scooter properly. -
Page 63: Troubleshooting Charts
Remove the spark plug and check the electrodes. The engine does not start. Have a Yamaha dealer check the vehicle. Check the battery. 4. Battery The engine turns over The battery is good. - Page 64 Start the engine. If the engine overheats again, have a The coolant level Yamaha dealer check and repair the cooling system. is OK. If coolant is not available, tap water can be temporarily used instead, provided that it is changed to the recommended coolant as soon as possible.
-
Page 65: Scooter Care And Storage
Some models are equipped with nology, it also makes it more vulnera- matte colored finished parts. Be ble. Rust and corrosion can develop Cleaning sure to consult a Yamaha dealer for ECA10783 even if high-quality components are NOTICE advice on what products to use used. - Page 66 SCOOTER CARE AND STORAGE with water may be used. Be scratches on the windshield. sure to rinse off any detergent Test the product on a small hid- Salt sprayed on roads in the winter residue using plenty of water, den part of the windshield to may remain well into spring.
-
Page 67: Storage
Storing the scooter in a poorly EWA10942 ventilated room or covering it WARNING Consult a Yamaha dealer for with a tarp, while it is still wet, Contaminants on the brakes or advice on what products to use. will allow water and humidity to tires can cause loss of control. - Page 68 SCOOTER CARE AND STORAGE 2. Fill up the fuel tank and add fuel electrodes while turning the stabilizer (if available) to prevent engine over. Make any necessary repairs before [EWA10951] the fuel tank from rusting and the 4. Lubricate all control cables and storing the scooter.
-
Page 69: Specifications
SPECIFICATIONS Dimensions: Engine oil: Fuel: Overall length: Type: Recommended fuel: 1840 mm (72.4 in) SAE 10W-30, SAE 10W-40, SAE 20W-40 Regular unleaded gasoline only Overall width: or SAE 20W-50 Fuel tank capacity: 793 mm (31.2 in) 5.3 L (1.40 US gal, 1.17 Imp.gal) Overall height: Fuel reserve amount: 1260 mm (49.6 in) - Page 70 SPECIFICATIONS Trail: Spring/shock absorber type: 175 kPa (1.75 kgf/cm , 25 psi, 1.75 bar) 92.6 mm (3.65 in) Coil spring/oil damper Rear: Wheel travel: Front tire: 200 kPa (2.00 kgf/cm , 29 psi, 2.00 bar) 70.0 mm (2.76 in) Type: Loading condition: Rear suspension: Tubeless...
- Page 71 SPECIFICATIONS 12 V, 5.0 W x 1 Meter lighting: High beam indicator light: Turn signal indicator light: Fuel level warning light: Coolant temperature warning light: Engine trouble warning light: Fuses: Main fuse: 15.0 A...
-
Page 72: Consumer Information
Record the vehicle identification num- ber and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is stolen. VEHICLE IDENTIFICATION NUMBER: 1. Vehicle identification number 1. - Page 73 INDEX Fuel consumption, tips for reducing..5-3 Spark plug, checking .........6-7 Fuel level warning light ......3-2 Specifications..........8-1 Acceleration and deceleration ....5-2 Fuel tank breather/overflow hose ....3-9 Start switch ..........3-6 Air filter element and check hose, Fuel tank cap ..........3-7 Starting off ..........5-2 replacing and cleaning ......6-13 Fuse, replacing.........6-24 Starting the engine........5-1...
- Page 76 MBK Industrie Z.I. de Rouvroy 02100 Saint Quentin Société Anonyme au capital de 45 000 000 e PRINTED IN FRANCE 2012-03 (E) R.C St-Quentin B 329 035 422...