Advertisement
Quick Links
MODEL 473741008• PRODUCT GUIDE
THIS GRILL IS FOR OUTDOOR USE ONLY.
CAUTION:
Read and follow all safety statements, assembly
instructions, and use and care directions before
attempting to assemble and cook.
INSTALLER/ASSEMBLER:
Leave this manual with consumer.
CONSUMER:
Keep this manual for future reference.
If you have any questions or need assistance during assembly, please call 1-800-241-7548.
To insure your satisfaction and for follow-up service, register your grill online at www.grillregistration.com
WARNING:
Failure to follow all manufacturer's instructions
could result in serious personal injury and/or
property damage.
CAUTION:
Some parts may contain sharp edges –
especially as noted in the manual! Wear
protective gloves if necessary.
473741008 • 80012802 • 07-18-07
Advertisement
Subscribe to Our Youtube Channel
Related Manuals for Char-Broil 473741008
Summary of Contents for Char-Broil 473741008
- Page 1 CONSUMER: Keep this manual for future reference. If you have any questions or need assistance during assembly, please call 1-800-241-7548. To insure your satisfaction and for follow-up service, register your grill online at www.grillregistration.com 473741008 • 80012802 • 07-18-07...
- Page 2 Date Purchased WARNING CAUTION WARNING: Indicates an potentially hazardous situation For residential use only. Do not use for commercial which, if not avoided, could result in death or serious cooking. injury. 2 • 473741008...
-
Page 3: Table Of Contents
Use only authorized replacement parts supplied by manufacturer. CAUTION CAUTION: Indicates a potentially hazardous situation or unsafe practice which, if not avoided, may result in minor or moderate injury. 473741008 • 3... - Page 4 • To remove gas from LP cylinder, contact an LP dealer or call a Retainer Strap by the sun. local fire department for assistance. Check the telephone • Do not store an LP cylinder in an area where children play. directory under “Gas Companies” for nearest certified LP dealers. 4 • 473741008...
-
Page 5: For Your Safety
Continued on next page. Nipple has to be centered into the LP cylinder valve. WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! 473741008 • 5... -
Page 6: Grill Service Center
• Do not use grill until leak-tested. • If a leak is detected at any time, STOP and call the fire department. • If you cannot stop a gas leak, immediately close LPcylinder valve and call LP gas supplier or your fire department! 6 • 473741008... - Page 7 Only use the pressure regulator and hose assembly supplied with this grill. Replacement pressure regulator and hose assemblies must be specified or supplied by Char-Broil, LLC. If you have a grill problem see the "Troubleshooting Section". If the regulator frosts, turn off grill and LP cylinder valve immediately.
- Page 8 •Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot. 8 • 473741008...
- Page 9 • Store grill indoors ONLY if LP cylinder is turned off and disconnected, removed from grill and stored outdoors. • When removing grill from storage, follow “Cleaning the Burner Assembly” instructions before starting grill. 473741008 • 9...
- Page 10 For more information call: USDA Meat and Poultry Hotline at • When reheating takeout foods or fully cooked meats like hot 1-800-535-4555 In Washington, DC (202) 720-3333, 10:00 am- dogs, grill to 165° F, or until steaming hot. 4:00 pm EST. 10 • 473741008...
-
Page 11: Parts List
Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C. Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates. Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan... -
Page 12: Parts Diagram
PARTS DIAGRAM – Model No. 473741008 Estimated assembly time: 30 minutes. NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method of assembly remains the same. -
Page 13: Assembly
ASSEMBLY – Model No. 473741008 (A) Place leg shelf support onto leg with leg extender. Attach each side with #10-24x1-3/4" machine screw and #10-24" wing nut. (B) Attach one support bar to legs with #10-24x1-3/4" machine screws and #10-24 wing nuts. - Page 14 Turn assembly upside-down. Insert axle into wheel. Facing the back, position tank support bracket between left legs. Insert axle through leg and bracket and secure with hitch pin. Axle Wheel 1” Hitch Pin Qty. 1 Hitch Pin "Cone" side of wheel against leg 14 • 473741008...
- Page 15 Push Fastener Back Machine Screw Qty: 4 Qty: 2 Upper Panel with Stamp “A” Hook the tank exclusion wires into back of panels and rear rail. Secure with hitch pins. Tank exclusion wire 1” Hitch Pin Qty. 4 473741008 • 15...
- Page 16 Insert ignitor into control panel. Insert the round terminal lug of the ignitor wire into the pin located at the end of the ignitor. Control Panel Qty: 2 #10-24x1-3/4" Machine Screw Ignitor #10-24 Wing Nut Qty: 2 Valve/Hose/Regulator #10-24X1/2" Machine Screw Qty: 2 16 • 473741008...
- Page 17 Qty: 2 #10-24 #8 Sheet Metal Wing Nut Screw Firebox Qty: 6 Fiber Washer Control knobs Heat shield Ignitor Wire Attach side shelves with #10-24x1-3/4" machine screws. Shelf Qty: 8 Left Side Right Side #10-24x1-3/4" Machine Screw 473741008 • 17...
- Page 18 #10-24X1/2" Machine Screw Qty: 4 Fiber Washer Qty. 10 #10-24 Wing Nut Qty. 2 Upper lid hinge #10-24 Rectangular Nut Qty. 4 18 • 473741008...
- Page 19 Place vaporiser bar onto V-shaped bar rests inside firebox. Place cooking grate onto firebox. NOTE: The vaporiser bar must be inserted into firebox at an angle in order to fit beneath cooking grate supports. Cooking grate Vaporiser bar 473741008 • 19...
- Page 20 Hang grease cup clip from bottom of firebox and place grease cup into grease clip CAUTION Failure to install grease cup clip and cup will cause hot grease to drip from bottom of grill with risk of fire or property damage. Grease Cup Clip Grease Cup Clip Grease Cup 20 • 473741008...
- Page 21 CAUTION Cylinder valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged Correctly Installed in operation, resulting in the risk of fire. LP cylinder. 473741008 • 21...
-
Page 22: Troubleshooting
• Clean wire and/or electrode with rubbing alcohol and clean swab. cooking residue. • Wires are loose or disconnected. • Reconnect wires or replace electrode/wire assembly. • Wires are shorting (sparking) between • Replace ignitor wire/electrode assembly. ignitor and electrode. 22 • 473741008... - Page 23 Use and Care. Unable to fill LP • Some dealers have older fill nozzles • The worn nozzles don’t have enough “bite” to engage the valve. Try cylinder. with worn threads. a second LP dealer. 473741008 • 23...
-
Page 24: Limited Warranty
Consumer returns will not be accepted unless a valid Return Authorization is first acquired by calling 1-800-241-7548 and then clearly marked on the outside of the package and the package is shipped freight/postage pre-paid to the address above. 24 • 473741008... - Page 25 Page intentionally blank 473741008 • 25...
- Page 26 Please register your grill online at: WWW.GRILLREGISTRATION.COM (If you register online, you do not need to send in this registration card.) La parrilla estaba ensamblada Chimenea / Envíelo a: 26 • 473741008...
- Page 27 Always ensure control knobs are in OFF position and regulator is attached to tank BEFORE opening tank valve to avoid low flames. Perform leak test regularly. Thank You for Your Purchase! Char-Broil, LLC • Columbus, GA 31902 • Printed in China...
Need help?
Do you have a question about the 473741008 and is the answer not in the manual?
Questions and answers