Jayco JAY FLIGHT BUNGALOW 2023 Owner's Manual
  1. Manuals
  2. Brands
  3. Jayco Manuals
  4. Motorhomes
  5. JAY FLIGHT BUNGALOW 2023
  6. Owner's manual

Jayco JAY FLIGHT BUNGALOW 2023 Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
JAY FLIGHT
BUNGALOW
2023 OWNER'S MANUAL
L
I
M
I
T
E
D
S T R U C T U R A L
WARRANTY
A subsidiary of Thor Industries, Inc.

Advertisement

Table of Contents
loading

Related Manuals for Jayco JAY FLIGHT BUNGALOW 2023

Summary of Contents for Jayco JAY FLIGHT BUNGALOW 2023

  • Page 1 JAY FLIGHT BUNGALOW 2023 OWNER’S MANUAL S T R U C T U R A L WARRANTY A subsidiary of Thor Industries, Inc.

  • Page 3: Table Of Contents

    Suggestions For Obtaining Service Obtaining Service At Our Customer Service Facility Obtaining Service For Separately Warranted Items Parts and Accessories 2023 Jayco Jay Flight Bungalow Limited Warranty Section 2: Occupant Safety Secondary Means of Escape (Exit Window) Fire Safety Fire Extinguisher...
  • Page 4 Table of Contents Section 6: Electrical System The Electrical System Command Center GFCI Receptacle Command Control System (if so equipped) BMPRO Mini System (if so equipped) LCI OneControl® App(if so equipped) Testing The Campsite Power Connection Power Converter 12-Volt DC System Auxiliary Battery (Customer Supplied) Load Center 120-Volt Circuit Breakers...
  • Page 5 Table of Contents Section 11: Electronics Antenna Section 12: Interior Cleaning The Interior Sofa and Dinette Pantry or Hutch (if so equipped) Countertops Flooring Bed Storage Bunk Beds and Bunk Ladders (if so equipped) Section 13: Exterior Cleaning The Exterior Frame E-Z Lube or Super-Lube Axle (if so equipped) Exterior Roof and Sidewall Vents...
  • Page 6 Table of Contents...

  • Page 7: Section 1: Warranty & Service

    Section 1: Warranty & Service WARNING: Read all instructions in this manual and component manufac- turer supplied information before using your RV. This manual has been provided by your recreational vehicle manufacturer for the sole pur- pose of providing instructions concerning the operation and maintenance of this recreational vehicle.
  • Page 8 Section 1: Warranty & Service Table of Contents...

  • Page 9: Introduction

    Canada may differ to conform to Canadian Codes. Dealer Responsibility At the time of sale of the new recreation vehicle, your Jayco dealer is expected to: Deliver your recreation vehicle in the best condition possible. Your recreation ve- hicle must pass the dealer’s pre-delivery inspection (PDI), including all systems...
  • Page 10 (or any effect of the alterations) to any of the parts, components, systems or assemblies installed by Jayco. Jayco is not responsible for the safety or quality of design features, materials or workmanship of any alterations by such suppliers.

  • Page 11: About This Manual

    Section 1: Warranty & Service Failure to contact Jayco Customer Service, unauthorized or improper warranty repairs, or failure to return requested original parts may result in loss of reimbursements and/or loss of warranty. To Contact Us Mailing address Shipping address Jayco, Inc.

  • Page 12: Safety Alerts

    Section 1: Warranty & Service Safety Alerts Throughout this manual, certain items are labeled NOTE, NOTICE, CAUTION, WARN- ING, and DANGER. These terms will alert you to precautions that can involve risk to your vehicle or to your personal safety. Read and follow them carefully.

  • Page 13: Reporting Safety Defects

    Section 1: Warranty & Service Reporting Safety Defects In the United States: If you believe that your recreation vehicle has an alleged defect which could cause a crash or cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA), in addition to notifying our Cus- tomer Service Department.

  • Page 14: Customer Responsibility

    Section 1: Warranty & Service Customer Responsibility It is important you read and understand all instructions and precautions before operating the recreation vehicle. Even if you are an experienced RV’er we encourage you to thoroughly read this Owner’s Manual, as well as the information contained in your Warranty Packet. As technology advances, new improvements enter the RV industry every day, and each RV manufacturer has its own unique manufacturing process.

  • Page 15: Obtaining Service At Our Customer Service Facility

    Section 1: Warranty & Service require notification of any issues with their repairs within a specified time limit. Make sure you are familiar with their repair policies. Obtaining Service At Our Customer Service Facility Should your recreation vehicle be in need of service, and your dealer recommends that the repairs be made at our Customer Service facility, your recreation vehicle may be returned to us with the following guidelines*: You or your dealer must make a confirmed appointment 60 days prior to dropping...

  • Page 16: 2023 Jayco Jay Flight Bungalow Limited Warranty

    Jayco or an authorized servicing dealer during the applicable warranty period, it will be repaired or replaced, at Jayco’s option, without charge to the RV owner, in accor- dance with the terms, conditions and limitations of this limited warranty. Jayco will cover...
  • Page 17 RV is delivered to the first retail purchaser by an independent, authorized dealer of Jayco, or, if the dealer places the vehicle in service before retail sale, on the date the RV is first placed in such service.
  • Page 18 Pay any freight or transportation costs, import duties, fees and all incidental expenses associated with obtaining warranty service. If you need assistance, you may contact Jayco, at 903 S. Main Street, P.O. Box 460, Middle- bury, Indiana 46540, Attn: Customer Service, (800) 283-8267.
  • Page 19 • vening acts not attributable to Jayco; damage caused by unregulated water pressure, tank over fill, or plumbing system modi- •...
  • Page 20 In addition, this warranty is not intended to extend to future performance, and nothing in this warranty, or any action of Jayco, or any agent of Jayco, shall be interpreted as an extension of the warranty period or this limitation period.
  • Page 21 ALSO HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE OR PROVINCE TO PROVINCE. ALL ACTIONS OF ANY KIND RELATING TO THE RV SHALL BE DECIDED BY A JUDGE RATHER THAN A JURY. JAYCO, INC. 903 S. Main Street * P.O. Box 460 * Middlebury, IN 46540 Telephone: (800) 283-8267...
  • Page 22 Section 1: Warranty & Service Notes: Table of Contents...

  • Page 23: Secondary Means Of Escape (Exit Window)

    Section 2: Occupant Safety Secondary Means of Escape (Exit Window) Your recreation vehicle has been equipped with a window(s) that serves as a secondary means of escape. The window(s) will allow a quick exit from the vehicle during an emer- gency if access to the main entrance door is not available.

  • Page 24: Fire Safety

    Section 2: Occupant Safety Lever style latch Remove the screen by pulling the red tab (upper right arrow). Pull the lever out from the sash clamps. Swing the lever out so it is positioned straight out from the win- dow. Push the lever (and window) out to open and exit the vehicle.

  • Page 25: Smoke Alarm

    Section 2: Occupant Safety Do not check the pressure, test or practice using the fire extinguisher by squeezing the trigger, even briefly. The fire extinguisher is not rechargeable or refillable. Once used, it will gradually lose pressure and will not be fully charged for use in an emergency.

  • Page 26: Combination Carbon Monoxide /Propane Alarm

    Section 2: Occupant Safety When the battery is removed from the alarm, the battery flag will pop up; the alarm cannot be installed to the mounting bracket without a battery. To test, stand at arm’s length from the smoke alarm as the alarm horn is loud and may be harmful to your hearing.
  • Page 27 Section 2: Occupant Safety Do not cover or obstruct the carbon monoxide/propane alarm with any- thing that could prevent gas from entering the alarm. This alarm is not designed to detect smoke, fire or gases other than car- bon monoxide and propane. The carbon monoxide detector installed is intended for use in ordinary indoor locations of recreation vehicles.
  • Page 28 Section 2: Occupant Safety the vehicle was constructed (for more information, refer to Sec. 2, Formaldehyde). What you should do if the alarm sounds Actuation of this detector indicates the presence of carbon monoxide which can kill you. Never turn the 12-volt battery disconnect control to the off position and disconnect the battery cable to silence an alarm.

  • Page 29: Formaldehyde

    Section 2: Occupant Safety Alarm features and functions Includes an 85db audible horn, two LEDs, and a SILENCE/TEST button. Alarm States Normal operation: The Green LED is ON steady. Red LED OFF, Audible horn OFF. Power OFF: Both LEDs and the audible horn will be OFF. Self Test: Green LED OFF, Red LED ON/Flashing, audible horn 4 chirps fol- lowed by constant beeps.

  • Page 30: Extended Or Full Time Usage

    Section 2: Occupant Safety To aid in dissipation, ventilate the recreation vehicle by opening all windows and circulate the air with a fan. This label is located inside the vehicle near the entry door and should be left permanently affixed to the rec- reation vehicle.

  • Page 31: Section 3: Pre-Travel Information

    Section 3: Pre-Travel Information Tow Vehicle If you plan to tow your recreation vehicle with a tow vehicle you already own, or if you plan to purchase a new one, make sure the Gross Vehicle Weight Rating (GVWR) or your recre- ation vehicle does not exceed your tow vehicles towing rating.
  • Page 32 Section 3: Pre-Travel Information Weight and Capacity Labels The following labels are typically located on the roadside front corner of the RV. An ad- ditional Occupant & Cargo Carrying Capacity label is also located on the inward surface of the entry door. OCCC Label (Occupant and Cargo Carrying Capacity): The upper portion of this yellow label is feder- ally required and includes the maximum Occu-...

  • Page 33: Loading Your Recreation Vehicle

    Section 3: Pre-Travel Information Loading Your Recreation Vehicle Never load the RV in excess of the GAWR for either axle. Overload- ing your RV may result in adverse handling characteristics and dam- age to the RV. DO NOT EXCEED YOUR GVWR! This means you should weigh your RV as loaded for your normal travel to determine the actual weight.

  • Page 34: Travel Trailer Hitch (Customer Supplied)

    Section 3: Pre-Travel Information Travel Trailer Hitch (customer supplied) Hitch selection affects the towing and handling characteristics of your recreation vehicle. There are many kinds of hitches available and assuring that you have the correct hitch in- stalled is critical to a safe towing. Ask your dealer about the proper class and type of hitch you need for your individual tow vehicle/RV combination.
  • Page 35 Section 3: Pre-Travel Information The following procedure will help to assist you in securely hooking up your recreation ve- hicle to your tow vehicle. Make sure the trailer wheels are blocked. Turn the tongue jack crank to raise the travel trailer tongue above the hitch ball. Open the coupler latch on the travel trailer hitch.

  • Page 36: Wire Harness/Connector Plug

    Section 3: Pre-Travel Information trailer weight. Always have the safety chains attached when towing. Install them as shown below so they do not restrict sharp turns, but tight enough so they do not drag on the ground. Crisscross the left safety chain under the coupler and attach to the right mounting slot in the trailer hitch;...

  • Page 37: Weighing Your Tow Vehicle And Rv

    Section 3: Pre-Travel Information White Ground Blue Electric Brakes Green Running Lights Black Auxiliary +12V battery charge line Stop and left turn Brown or Orange Stop amd right turn Yellow Back up Lights Weighing Your Tow Vehicle and RV When the RV is fully loaded it should be weighed. The actual weight of the vehicle, all op- tions, liquids, the hitch weight, and your personal cargo is important for you to know so you do not exceed the GVWR.
  • Page 38 Section 3: Pre-Travel Information the overall RV GVWR to determine the actual “tongue” weight. With the RV still attached to the tow vehicle, weigh each wheel position separately to ensure each tire is not overloaded. To determine the wheel position weight Pull the RV onto the scale so only one tire is on the scale.

  • Page 39: Towing

    Section 4: Vehicle Operation Towing If your RV is equipped with the Command Control Bluetooth system, make sure you turn off your battery disconnect switch according to the following instructions. BEFORE TOWING YOUR RV ON THE ROADWAY: TURN OFF THE BATTERY DISCONNECT SWITCH! Certain components inside the RV can unexpectedly activate which could result in personal injury or property damage.
  • Page 40 Section 4: Vehicle Operation cause clearance problems around some tunnels, canopies and hanging signs. When turning, the tires do not follow the path of your tow vehicle tires. The RV will make a tighter turn than the tow vehicle. Compensate for this action by carefully pulling the tow vehicle out into the intersection further than you would normally so that the RV clears the curb.

  • Page 41: Towing Behind Your Rv

    If you do not have a Jayco factory installed hitch receiver, towing items behind your Jayco RV, or overloading the rear, will void the warranty and may result in: damage to the RV or add-on items, towing difficulties, property dam- age and/or personal injury.

  • Page 42: Entrance Door Step(S)

    Section 4: Vehicle Operation Entrance Door Step(s) Make sure your entrance step is fully extended before exiting the vehicle, and retracted prior to towing. Lubricating the step mechanism Carefully clean the area around the pivot points (the rivets involved in the motion of the mechanism). Lu- bricate these pivot points with an automotive grade, non-staining lubricant every 30 to 60 days.

  • Page 43: Entrance Door

    Section 4: Vehicle Operation Step storage ™ NOTE: When returning steps to the stored position, the adjustable feet may have to be retracted to fit inside the door opening Fold the handrail at the door out of the way or re- move the optional step handrail (if so equipped).

  • Page 44: Stabilizer Jacks

    Section 4: Vehicle Operation Stabilizer Jacks DO NOT USE THE STABILIZER JACKS TO LEVEL THE RV. It is important to remember that the stabilizer jacks are to be used only for support while occupying and moving around the RV. They are not designed to support the weight of the RV.

  • Page 45: Emergency Stopping

    Section 4: Vehicle Operation Emergency Stopping Always carry road flares or reflective warning signs. Pull off the roadway as far as possible for emergency stopping. Turn ON your vehicle hazard warning flashers. If traveling at night, use three red warning indicators such as flares, reflectors or lanterns as required by the Uni- form Vehicle Code and Model Traffic Ordinance.
  • Page 46 Section 4: Vehicle Operation Check and tighten wheel lug nuts regularly to make sure they did not loosen during travel. Wheel lug nuts must be applied and maintained at the proper torque levels to prevent loose wheels, broken studs and possi- ble separation of the wheel(s) from your recreation vehicle.

  • Page 47: Tires

    Section 4: Vehicle Operation Prior to travel and after excessive braking, wheel lug nuts should be checked for torque. Torque readings must fall within the Final Torque Values in chart above. Torque specifications should be checked using a proper torque wrench. If the torque falls below the Final Torque Values, additional torque is required.
  • Page 48 Section 4: Vehicle Operation Tire wear should be checked frequently. Once a wear pattern becomes firmly established in a tire it is difficult to stop, even if the underlying cause is cor- rected. Tire pressure Failure to follow proper inflation guidelines may result in tire failure, which, under certain circumstances can cause loss of vehicle control or accidents that may result in property damage, bodily injury and/or death.

  • Page 49: Tire Pressure Monitor System (Tpms)

    Section 4: Vehicle Operation ™ NOTE: Cold tire inflation pressure is defined as a tire that has not been used for three or more hours, or has been driven less than one mile. Tire inflation pressure of a hot tire may show an increase of as much as 6 psi over a cold tire.

  • Page 50: Changing A Tire

    Section 4: Vehicle Operation Rotating the tires: TPMS sensors – DO NOT MOVE WITH THE TIRES! The TPMS sensor on the front tire (on either side of the trailer) STAYS at the front tire position when rotating tires. The TPMS sensor on the middle tire (on either side of a 3-axle trailer) STAYS at the middle tire position when rotating tires.

  • Page 51: Spare Tire Carrier (If So Equipped)

    Section 4: Vehicle Operation To raise the recreational vehicle, place the jack (hydraulic or screw) under the main frame rail. It must be just ahead of the front tire or just behind the rear tire. Tire Replacement Any service or warranty coverage on tires is to be handled by the tire manufacturer or the store representing the brand installed on your recreation vehicle.

  • Page 52: Seasonal Set-Up

    Section 4: Vehicle Operation Bumper Mount The spare tire bracket can be released and extended down to access a storage compartment at the rear of the trailer without removing the tire. To extend the tire down Remove the cotter key from the pin holding the tire carrier in place.
  • Page 53 Section 4: Vehicle Operation Grass and organic material from the area is removed from under supports or foot- ings. Tie-downs All travel trailers should be securely anchored to the ground with (6) tie-downs and ground anchors (minimum 3 per side), to resist the sliding and overturning effects of high winds. Where tie-downs are required, it will be necessary to adhere to the following instructions.

  • Page 54: Awnings (If So Equipped)

    Section 4: Vehicle Operation Installation / Placement Utility Connections Level Fuel Foundation Water Tie Downs Electric Sewage Detachable Hitch The hitch is detachable; the instructions to remove and install it are listed below: Suggested materials (customer supplied): Quantity Item Description 3-ton jack stands 7/8”...
  • Page 55 Section 4: Vehicle Operation Awnings must be closed (and secured) while the RV is in transit. Keep clear of arm assemblies while opening, adjusting or closing the aw- ning. Failure to obey this caution could result in injury and/or property damage.
  • Page 56 Section 4: Vehicle Operation Remove the solution COMPLETELY from the awning fabric. Make sure the fabric is dry before closing the awning. Air-dry only. Never apply heat to the fabric. Your recreation vehicle may include one or more of the following options: Power window awnings Slide out awnings Power awning over entrance door...

  • Page 57: Section 5: Slideout Systems

    Section 5: Slideout Systems Electric Slide Room(s) (if so equipped) The mechanical components of the slide out are gear driven. Electric powered slideout room systems have a manual override to allow you to extend or retract the slideout room(s) in case of a power loss.
  • Page 58 Section 5: Slideout Systems After the slideout is extended, visually inspect the slideout and the surrounding area to make sure the slideout has extended properly and has adequate clearance from any outside obstructions. If the slideout is equipped with rubber seals, verify that the corners of the black rubber seal are set up correctly.
  • Page 59 Section 5: Slideout Systems and stops moving. Hold the switch in the IN position to retract the room. Release the switch, which will lock the room into position. If the slideout switch is held after the room is fully extended or retracted, the control will sense that the room has stopped and will shut the motor off after a few seconds.
  • Page 60 Section 5: Slideout Systems ™ NOTE: Do not operate the switch after the room is fully extended or re- tracted as damage can occur to the motor and/or switch. To operate the slideout using a wireless remote (if so equipped): Press the on/off button to power on the remote.
  • Page 61 Section 5: Slideout Systems Manual override for the in-wall slideout The slideout system comes with an “electronic” manual override. In event the slide out does not extend or retract follow these steps to override the system which should allow the slideout to be retracted.
  • Page 62 Section 5: Slideout Systems Manually pushing in the slideout Locate the slideout system controller. Unplug motor 1 and motor 2 connectors at the bottom of the slideout controller. This releases the motor brakes for each motor. The slideout room can now be manually pushed in. Larger rooms may require several people to push or pull them.
  • Page 63 Section 5: Slideout Systems Motors and cables are behind the interior fascia board around the slideout opening. Cables may stretch over time. Average stretch will be approximately 1/8” but it will not affect the function and does not require adjustment. Slideout runs off the DC power in the RV.
  • Page 64 Section 5: Slideout Systems If the room still does not move when the switch is pressed, follow the steps below to manually override the slideout room: Turn the Main Power OFF. The override will not work if it has power going to it. Do not work on the system unless the battery is disconnected.
  • Page 65 Section 5: Slideout Systems Power Gear Slim Rack Slideout System The Power Gear® Slim Rack slideout is typically used for slideouts 144” long and longer. It is operated by a 12VDC electric motor. The system is equipped with a manual over- ride allowing the room to be extended / retract- ed in the event of a power loss.
  • Page 66 Section 5: Slideout Systems MAJOR and MINOR faults; faults must be cleared for the room to operate normally. MINOR faults can be cleared by pushing and releasing the IN or OUT buttons on the wall touchpad. MAJOR faults must be cleared by pushing and releasing the SET STOPS/CLEAR FAULTS button located on the back of the wall touchpad.
  • Page 67 Section 5: Slideout Systems -Set parking brake (if ap- -Parking brake not set plicable) (if applicable) -Check for continuity to Park brake LED flashing -Ground signal lost at ground on wire plugged park brake control into park brake connector at control box.
  • Page 68 Section 5: Slideout Systems It is very important to note that during this procedure, the slideout control has NO stop locations. Use a second person to assist in determining when the room is retracted. Damage to the room can occur if the room is retracted too far.
  • Page 69 Section 5: Slideout Systems Power Gear Ram Slideout System Manual Override Procedure The system has been equipped with 3/4” hex override cou- plers located on the drive component of the system. Due to the size and weight of some rooms, assistance may be needed to push the room in.
  • Page 70 Section 5: Slideout Systems The spring lock lever is a thin metal arm with a slight bend at the end, which will hold the brake lever in the released position. The brake lever is the heavier thicker metal arm with the hole in the end. The normal position for these two levers is to be parallel to each other as shown in the first side-by-side photo.
  • Page 71 Section 6: Electrical System The Electrical System The RV electrical system is comprised of two independent electrical systems. One operates off of 12-volt DC power and the other off of 120-volt 60hz AC power. All installations have been made in compliance with industry standards applicable on the date of manufacture. Because the electrical equipment and associated circuitry are engineered into a dedicated system specific to your RV, do not make unauthorized changes or add fixed appliances to it.
  • Page 72 Section 6: Electrical System Awning control switches (press and hold to extend / re- tract) Systems monitor with LED indicators for tank levels and battery charge status Auto leveling control panel (for leveling the RV) Inverter panel (power switch with display) Power bunk bed lift control switch Speaker selector switch Touch Dimmer Switch...
  • Page 73 Section 6: Electrical System RV Auto Leveling System Power Jacks and Stabilizers Interior and Exterior Lighting RV Slideout Rooms Power Awnings Generator TV and Bed Lifts HVAC Thermostat Gas and Electric Water Heaters Water Tank Levels (black,gray,fresh) Battery Levels Back Up Camera Systems Water Pump Kitchen and Bath Vents and Covers Door Locks...
  • Page 74 Section 6: Electrical System Display Control Screen The following buttons can be found on the display control unit mounted inside the RV. Button 1: Page Navigation button; allows you to move from page to page (e.g. Tanks page to Water page). Button 2: Menu Navigation button;...
  • Page 75 Section 6: Electrical System LCI OneControl® App(if so equipped) Some models may include a Bluetooth control module that works with the LCI OneControl App for your smartphone, tablet or other smart device. When connecting to this app, certain systems in your RV can be controlled remotely from your smart device. This free app is available for download for your smartphone, tablet or smart device.
  • Page 76 Section 6: Electrical System Light switches may have to be toggled twice for them to operate as this system is multi- plexed with the command center panel and other wireless controllers in the RV. The OneControl System will NOT operate the hall light, lights located inside each slide-out, exterior amber/red marker lights, or the LED lights located on the front or rear caps.
  • Page 77 Section 6: Electrical System To help prevent power surges from damaging the connected loads, please follow these in- structions when hooking up to the external power source: Turn off the load center main 120-volt circuit breaker. Carefully extend the entire length of the power cord (approximately 25’-35’) from the electric cable hatch to the external power source.
  • Page 78 Section 6: Electrical System Before checking for converter output voltage, the battery cables must be disconnected at the battery. Make sure the converter is plugged into an AC source (105-132 AC volts). Check the converter output voltage at the battery with a voltmeter. Place the voltmeter probes on the disconnected battery cables.
  • Page 79 Section 6: Electrical System Manual Mode (not recommended): The manual mode button is used to override the charge wizard. Refer to the converter owner’s manual for additional information. Reverse Battery Protection: Reverse polarity fuse(s) provide protection for the converter when a battery is used. If the battery is connected backwards to the fuse board a fuse will blow preventing damage to the converter.
  • Page 80 Section 6: Electrical System Keep the protective dust cap on the 12-volt DC outlet when not in use to pre- vent ingestion of foreign material and potential short circuit conditions. Auxiliary Battery (Customer Supplied) Do not store anything inside the battery compartment(s) or near the batteries that could touch the battery or battery cable terminals.
  • Page 81 Section 6: Electrical System tow vehicle engine is operating with the RV connected, the tow vehicle charging system will charge both batteries. Replacement and maintenance Some equipment in your RV will draw small amounts of current even when turned OFF. To prevent the auxiliary battery from being discharged when your RV is not connected to shore line power, disconnect the auxiliary battery negative cable at the battery.
  • Page 82 Section 6: Electrical System Load Center The Load Center contains 12VDC fuses and 120VAC circuit breakers for almost all of the electrical appliances and circuits in the RV. The 120V main breaker may be located in this panel and will turn off all 120-volt power to the RV. Load center location, appearance and configuration may vary by model.
  • Page 83 Section 6: Electrical System Replacement Only replace circuit breakers with those of the same specified type, voltage, and current rat- ing. Never replace a circuit breaker with one listed at a higher amperage rating. Please contact your dealer for repair assistance when replacing circuit breakers. Replacement circuit breakers must be of the same voltage, amperage rating and type.
  • Page 84 Section 6: Electrical System 120 VOLT SYSTEM Air Conditioner 18 AMPS Coffee Maker 6-12 AMPS Converter (each) 8 AMPS DVD System 3 AMPS Fireplace 15 AMPS Hair Dryer or Curling Iron 10-14 AMPS Microwave 15 AMPS Refrigerator 6 AMPS Satellite Receiver 2 AMPS 2-4 AMPS Vacuum Cleaner...
  • Page 85 Section 6: Electrical System 50 AMP Power Cord Do not hook up the power cord to any receptacle until you have verified proper polarity and grounding. Polarity indicators can be purchased in most electrical and hardware stores. Do not use any cheater plug, adapter or extension cord to reconfigure incoming AC power or break the continuity of the circuit connected to the grounding pin.
  • Page 86 Section 6: Electrical System Solar Package (if so equipped) If expanding upon OEM installed solar package, ensure all components are compatible with existing product. Any additional equipment will reduce Car- go Carrying Capacity (CCC) when installed. Your recreational vehicle may be equipped with a factory installed solar panel kit that in- cludes lithium batteries, a DC/DC power converter (allows charging from the tow vehicle connection.), Solar Panels, and an energy management control system.
  • Page 87 Section 7: Fuel & Propane System Exhaust Gas Fumes Avoid inhaling exhaust gases as they contain carbon monoxide, which is a potentially toxic gas that is colorless and odorless. If you are in a recreation vehicle with either a nearby tow vehicle engine running or the generator (if so equipped) running there is a potential for exhaust fumes to filter back into the recreation vehicle.
  • Page 88 Section 7: Fuel & Propane System recommended. Hand tighten the LP gas system valves only, do not use a wrench or pliers as over tightening may damage the valve seals and cause them to leak. ™ NOTE: All propane lines have been checked with air pressure at the time of manufacture.
  • Page 89 Section 7: Fuel & Propane System ASME tanks are permanently mounted to the RV and are commonly used on RV mo- torhomes. The capacity of ASME tanks is expressed in gallons. ASME tanks are filled while the tank is attached to the motorhome by a qualified propane facility. ASME tanks are equipped with an automatic stop fill valve designed to reduce the potential of overfilling.
  • Page 90 Section 7: Fuel & Propane System The propane piping system is designed for use with propane only. Do not connect natural gas to this system. This label should be kept permanently affixed to your RV. Refer to your Warranty Packet for more information on the LP gas system components.
  • Page 91 Section 7: Fuel & Propane System Propane Regulator Propane regulators must always be installed with the regulator vent facing downward. Regulators that are not located in baggage compartments have been equipped with a protective cover. Make sure the regulator vent faces downward and (if applicable) the cover is in place to minimize vent blockage that could result in excessive gas pressure causing fire or explosion.
  • Page 92 Section 7: Fuel & Propane System Propane Leak Test Leaks may be found easily with a soapy water solution. Do not use a solution containing ammonia or chlorine when locating leaks. These products are corrosive to copper gas lines and brass fittings, which could result in deterioration of the copper and brass components. Apply the soapy solution to the outside of the gas piping fittings.
  • Page 93 Section 7: Fuel & Propane System It is especially important that cooking appliances not be used for comfort heating, as the danger of asphyxiation is greater when the appliance is used for long periods of time. FAILURE TO COMPLY MAY RESULT IN DEATH OR SERIOUS INJURY. These warning labels are located in the cooking area to remind the user to provide an ad- equate supply of fresh air for combustion.
  • Page 94 Section 7: Fuel & Propane System All pilot lights, appliances and their igniters (see operating instructions) should be turned off before refueling of motor fuel tanks and/or propane containers. These can cause ignition of flammable vapors, which can lead to a fire or explosion.
  • Page 95 Section 7: Fuel & Propane System Place the cylinder on the bracket in the recess compart- ment or housing and secure them so the outlets of the cylinder valves are facing the “sidewalls” of the com- partment or housing (opposite of each other). Mount the regulator on the center back wall of the com- partment or housing so the vent is pointed downward.
  • Page 96 Section 7: Fuel & Propane System Notes: Table of Contents...
  • Page 97 Section 8: Plumbing System Plumbing System There are two different water systems in your recreation vehicle: The fresh water system consists of the fresh water holding tank, faucets and con- nections, water pump, water heater, tub/shower. On some models, it may also include the water purification system or outside shower assembly (if so equipped).
  • Page 98 Section 8: Plumbing System F = Fair at 11.6 volts L = Low at 6.0 volts Tank monitors on the touch screen have a constant readout. There are no buttons to push. Tank levels are displayed by percentage from 0% to FULL. Level Alert Button (if so equipped): some models may be equipped with a Level Alert Button.
  • Page 99 Section 8: Plumbing System DO NOT drink water deemed microbiologically unsafe or of unknown quality. Avoid traveling with full fresh, black or grey water holding tanks. The weight of holding tank contents in not calculated into the RV cargo car- rying capacity.
  • Page 100 Section 8: Plumbing System 12-volt Water Pump There must be sufficient 12-volt DC power to run the water pump when your recreation vehicle is not hooked up to city water. Once activated, the water pump (also known as the demand pump) will self- prime, and provide water.
  • Page 101 Section 8: Plumbing System from the water lines. When the water lines are nearly full, you may experience some “air pockets.” Allow these to escape before closing the cold water supply faucets. ™ NOTE: The City Water Fill inlet when connected to a pressurized fresh wa- ter source sends water through the water lines and fixtures without the use of the pump.
  • Page 102 Section 8: Plumbing System A white plastic drain attached to the exterior wall A valve located inside the RV adjacent to the water tank (turn 45° to open or close). Pull the white “T” handle on the fresh water holding tank to drain the water. Low point drains are installed at the lowest point of the water lines.
  • Page 103 Section 8: Plumbing System Sanitizing the Plumbing System When to sanitize: When your recreation vehicle is new. At the beginning and end of each season. When the water system becomes contaminated or every three months of use. Preparing to sanitize Prepare a chlorine solution using 1/4 cup of household bleach (sodium hypochlorite solution) to one gallon (3.785 liters) of water in a container.
  • Page 104 Section 8: Plumbing System outside shower faucets (if so equipped). Close the hot water faucets and repeat opening all cold water faucets one by one until you smell chlorine. Include outside shower faucets (if swo equipped) and toilet. 10. Turn OFF the water pump. 11.
  • Page 105 Section 8: Plumbing System Drain the system again, but do not drain the water heater. Water heater bypass set to BYPASS. Do not remove water heater drain plug. Close low point drains and fresh water tank drain. Refill the fresh water tank with clean potable water. Pour water in the gravity fill using a hose or a funnel.
  • Page 106 Section 8: Plumbing System Turn water heater power OFF. Turn water heater gas valve (if so equipped) OFF (out- side of the RV). Water heater bypass valves should be set to BYPASS. Water is prevented from entering the water heater. Level the RV and drain the fresh water plumbing system.
  • Page 107 Section 8: Plumbing System Never apply air pressure to the water system with any of the valves in the closed position. Air pressure applied to a closed valve, faucet or low point drain could potentially damage the seals and cause water leaks. If you have questions, consult with your RV dealer.
  • Page 108 Section 8: Plumbing System Water Heater Your RV may be equipped with either a tank (storage) water heater or tank less water heater. The following is an overview of both systems. Hydrogen gas may result if you have not used the water heater for two weeks or more.
  • Page 109 Section 8: Plumbing System If lock-out occurs before the main burner lights, turn the water heater control switch to OFF, wait five seconds and turn the switch to the ON position. This will restart the ignition cycle. The first start-up of the heater may require several ignition cycles before all the air is purged form the propane lines.
  • Page 110 Section 8: Plumbing System This “weeping” or dripping will continue until the pressure is reduced to below 150 pounds, and the valve closes. This condition is normal and does not indicate a defective relief valve. One way to reduce the frequency of this occurrence is to maintain an air pocket at the top of the water heater tank.
  • Page 111 Section 8: Plumbing System valve for winterizing. It is not affected by high altitudes. The output temperature of the water depends on the temperature of the inlet water AND the amount of hot water that is drawn. If the inlet water temperature is over 65 º F, the tankless water heater will generate water in the range of 105°F to 120°F (on low flame) depending on the water flow selected by the user.
  • Page 112 Section 8: Plumbing System Maintenance Inspect your water heater monthly and have it serviced at least once a year by the manufac- turer’s recommended service technician. If you have questions, contact your RV dealer, the manufacturer, or Customer Service. Outside Shower (if so equipped) A handheld shower assembly with both hot and cold water may be included for use outside of your recreational vehicle.It may be located in a separate outside shower compartment or at the utility center (if so equipped).
  • Page 113 Section 8: Plumbing System The shower faucet may include a vacuum breaker for the shower. There are two purposes for this breaker: To prevent siphoning water through the hose from another fixture. To prevent water from being retained in the hose. The showerhead DOES NOT have a complete shut-off valve (the complete shut-off is at the faucet).
  • Page 114 Section 8: Plumbing System Some models are equipped with a side vent system. On these models this label will be next to the termination valve. This label should not be removed from your recreation vehicle. Black/Grey Water Holding Tanks Dump the gray and black water holding tanks before traveling to avoid carrying unnecessary weight.
  • Page 115 Section 8: Plumbing System Place the end of the sewer hose into the approved dump station. Open the black tank dump valve (depending on your model the valve may be located under the RV, or on the utility center). Close the dump valve when the black water holding tank is empty.
  • Page 116 Section 8: Plumbing System ™ NOTE: Utility center (if so equipped) valve positions do not affect the tank flush function. It does not matter where they are positioned when operating the tank flush. ™ NOTE: To help insure debris does not clog the tank sprayer orifices, use “TANK FLUSH”...
  • Page 117 Section 8: Plumbing System Remove the spray nozzle from the other end of the hose. Hold the open end of the hose near the ground and any water in the line should drain out. Disconnect the hose from the fitting, and store in the RV. Close the port cover.
  • Page 118 Section 8: Plumbing System Notes: Table of Contents...
  • Page 119 Section 9: Heating & Cooling Air Conditioner Cooled air enters the RV through the grill. Make sure you have sufficient power available before operating the air conditioner. Do not operate the air conditioner without the return air filter. Operating the system without the filter allows the lint and dirt that is normally stopped by the filter to accumulate on the cooling coil of the air conditioner.
  • Page 120 Section 9: Heating & Cooling (located on the fan) controls the direction of operation (down for forward, up for reverse). Stop the fan first before reversing the operation direction! ™ NOTE: During cooler temperatures, set your fan settings to "low," and set the fan to turn clockwise to pull warm air from the ceiling back towards the floor.
  • Page 121 Section 10: Appliances Microwave To prevent damage, remove the turntable from the microwave when trav- eling. Make sure you are connected to a 120-volt power source. Never use the microwave cavity for storage. The microwave cavity should always be empty when not in use. For details on operation, cleaning and safety information, refer to the manufacturer’s user guide.
  • Page 122 Section 10: Appliances Cooking With Propane (if so equipped) See the Propane System section for important safety instructions. Refer to the manufactur- er’s owner’s manual for detailed operating and safety instructions for all propane appliances. Cooktops, Range and Oven (if so equipped) For detailed operating and safety information, refer to the manufacturer’s user guide.
  • Page 123 Section 10: Appliances Gas Drop-In Cooktops (if so equipped) Depending on your model, it may be equipped with either a 2 burner or 3 burner cooktop. The 2 burner match-light cooktop has two 6500 BTU/H burners with control panel. The 3-burner piezo-igniter cooktop has (1) front 9000 BTU/H burner and two rear 5200 BTU/H burners.
  • Page 124 Section 10: Appliances Gas/Electric Models (if so equipped) If you smell propane gas STOP! Follow the directions located in your manu- facturer’s owner’s manual and in this manual. Residential Models (if so equipped) ™ NOTE: If you are using electric to power the refrigerator, make sure you are connected to a 120-volt power source.
  • Page 125 Section 10: Appliances on stainless steel. Stainless steel can be cleaned with a commercially available stainless steel cleaner. A spray-on stainless steel cleaner works best. Do not allow the Stainless Steel Cleaner and Polish to come into contact with any plas- tic parts such as the trim pieces, dispenser covers or door gaskets.
  • Page 126 Section 10: Appliances DO NOT PICK UP ANYTHING THAT IS BURNING OR SMOKING, SUCH AS CIGARETTES, MATCHES, OR HOT ASHES. RV damage, personal injury, or death may result from vacuuming up burning or smok- ing material. DO NOT PICK UP FLAMMABLE OR COMBUSTIBLE LIQUIDS SUCH AS GASOLINE, OR USE IN AREAS WHERE THEY MAY BE PRESENT.
  • Page 127 Section 11: Electronics Antenna HDTV Antenna (if so equipped) Your recreation vehicle may be equipped with an exterior fixed height high definition TV antenna. The is omnidirectional so it will receive TV signals from all directions. The an- tenna height is 8” above the roof. Refer to the HDTV manufacturer’s manual for detailed operating and safety information.
  • Page 128 Section 11: Electronics Notes: Table of Contents...
  • Page 129 Section 12: Interior Cleaning The Interior To keep the value of your recreation vehicle, perform regular maintenance using the proper materials and procedures. Using the wrong cleaner may result in damage to the surfaces in your vehicle. Check with the manufacturer’s information for the recommended cleaning agent.
  • Page 130 Section 12: Interior Fill a spray bottle with water and a tiny amount of soap. Then spray a lint-free towel with the mixture and use the towel to wipe down each slat. While cleaning, try not to bend the slats. They can also be soaked in a bathtub to loosen up any debris so the slats can be wiped down easily.
  • Page 131 Section 12: Interior down to provide a sleeping surface. For additional comfort and to reduce fabric damage, you may want to place a cover or air mattress (customer supplied) over the sofa when it is in the sleeping position. Trifold Sofa The trifold sofa offers very similar features to a traditional hide-a-bed.
  • Page 132 Section 12: Interior Free-Standing Table and Chairs (if so equipped) The free-standing dinette table can be positioned to seat up to four people. To prevent dam- age, the free-standing dinette chairs should be fastened securely at the dinette table when traveling.
  • Page 133 Section 12: Interior most dirt and residue from all types of finishes. A damp cloth followed by a dry towel will remove watermarks. Difficult stains can be removed from the matte finish with a green Scotch Brite® pad and a mild abrasive cleaner.
  • Page 134 Section 12: Interior up before they set. Blot with a paper towel and wipe clean with a damp cloth. Do not use dish detergents or vinegar and water because they will dull your floor. To care for the vinyl floor covering, use a damp mop with water and a mild cleaner on the entire floor.
  • Page 135 Section 12: Interior Some models may be equipped with a prop rod or gas struts to assist with easy access to under bed storage. Prop Rod (if so equipped) If your model is equipped with a prop rod: With the help of a second person, raise the bed platform. Release the prop rod from its holder.
  • Page 136 Section 12: Interior Exercise extreme care when entering or exiting the bunk beds and using the ladder. Do not allow more than one person on the top bunk. Do not allow children under 6 years of age to use the upper bunk. Do not allow horseplay on or under the bed and prohibit jumping on the bed.
  • Page 137 Section 13: Exterior Cleaning The Exterior To protect your recreation vehicle’s exterior finish, wash it often and thoroughly. You may wash and wax your new recreation vehicle 60 days after purchase. The exterior paint needs time to cure before any wax is applied to the exterior surface. Careful maintenance for the first 60 days will assure a long lasting durable finish.
  • Page 138 Section 13: Exterior During cold weather Salt and other chemicals that are spread on winter roads in some geographical areas can have a detrimental effect on the recreation vehicle’s underbody. If your recreation vehicle is exposed to these conditions, spray the underbody with a high-pressure hose every time you wash the exterior of your recreation vehicle.
  • Page 139 Section 13: Exterior Do not allow plastic to come into contact with brake fluid, engine oil, grease, paint thinner, or battery acid. These will damage plastic. Use a soft cloth and a mild detergent solution to wipe away any such contact. Chrome parts To prevent chrome parts from spotting or corroding, wash with water, dry thoroughly, and apply a non-abrasive automotive wax.
  • Page 140 Section 13: Exterior If your recreation vehicle is equipped with a roof ladder, do not leave items attached to it while traveling. DO NOT exceed the weight rating of the ladder. The ladder weight capacity label is located under the bottom step of the ladder.
  • Page 141 Section 13: Exterior Sealants Failure to properly maintain or reseal your recreation vehicle may result in serious water damage to the roof and other parts of the recreation ve- hicle. This damage is not covered by the Limited Warranty. To check the exterior sidewall sealants, use a stepladder placed safely alongside the vehicle.
  • Page 142 Section 13: Exterior Travel Trailers - Sealant Diagram Table of Contents...
  • Page 143 Section 14: Travel/Camping/Storage Checklists Travel Checklist Following is a preliminary list of items that need to be checked before leaving your home or campsite. This is a general list, which you may want to customize as you determine your own needs. Safety Make sure you follow all safety precautions noted in this owner’s manual and in any manufacturer’s operators manual when preparing to travel.
  • Page 144 Section 14: Travel/Camping/Storage Checklists Before leaving the campsite Check the area under the RV after overnight parking and look for water or other fluid leaks. If leaks are detected, find the cause and correct it immediately. Turn off propane tanks. Empty black and gray holding tanks, rinse as needed (if so equipped).
  • Page 145 Section 14: Travel/Camping/Storage Checklists Close the propane cylinder valve(s). We recommend using a propane cylinder cover, and to make sure the propane regulator is covered. If is equipped with a gas/ electric DSI range, light a range gas burner to consume any gas remaining in the lines.
  • Page 146 Section 14: Travel/Camping/Storage Checklists Notes: Table of Contents...
  • Page 147 Your recreation vehicle may be equipped with some of the items listed below. This is a partial listing and it is not intended to cover all components. All information is the latest available at the time of publication. Jayco reserves the right to change any of the following information without notice.
  • Page 148 Section 15: Additional Information Thermostat Coleman Mach www.airxcel.com/coleman-mach Toilet Thetford Corp. www.thetford.com See manufacturers’ user guide Winegard Company www.winegard.com TV Antenna King Jack www.kingconnect.com Water Heater, Tank DSI Atwood Greenbrier www.atwoodmobile.com Girard Systems www.greenrvproducts.com Water Heater, Tankless Truma AquaGo www.truma.com Shurflo East www.shurflo.com Water Pump, 12V...
  • Page 149 Section 15: Additional Information Vehicle Maintenance Record Make: Model: Model Year: Vehicle Serial#: Service Performed Mileage Work Performed Notes Date Table of Contents...
  • Page 150 Section 15: Additional Information Jayco Ownership Notification Email the form to unitfile@jayco.com ATTENTION! Federal record keeping laws require that we maintain a file of owners of our product. Your cooperation in filling out this from will be appreciated. □ □...
  • Page 151 Section 15: Additional Information Notes: Table of Contents...

Table of Contents