Related Manuals for Vintage Air SureFit 491275
Summary of Contents for Vintage Air SureFit 491275
- Page 1 1953-56 Ford F-100 Control Panel Kit (491275) 18865 Goll St. San Antonio, TX 78266 Phone: 800-862-6658 Sales: sales@vintageair.com Tech Support: tech@vintageair.com www.vintageair.com 901411 REV A 06/27/23, PG 1 OF 8...
- Page 2 Table of Contents www.vintageair.com Cover..........................Table of Contents......................... Packing List/Parts Disclaimer....................Control Panel Installation....................... Gen IV Wiring Diagram......................Gen 5 Wiring Diagram......................Operation of Controls......................Packing List......................... 901411 REV A 06/27/23, PG 2 OF 8...
- Page 3 Universal Control Harness ** Before beginning installation, open all packages and check contents of shipment. Please report any shortages directly to Vintage Air within 15 days. After 15 days, Vintage Air will not be responsible for missing or damaged items.
- Page 4 Control Panel Installation www.vintageair.com Install the control panel assembly into the dash by placing the control panel bracket behind the dash and securing it to the control panel assembly using a 10-24 nylon locknut (See Figure 1, below). Plug the control panel wiring harness into the control panel assembly and the ECU on the evaporator unit as shown in Figure 2, below.
- Page 5 Gen IV Wiring Diagram www.vintageair.com 232007-VUR AC ANNUNCIATOR BACKLIGHT POS BACKLIGHT NEG 5V-SW WHT/RED TEMP WIPER WHT/YEL MODE WIPER WHT/GRN FAN WIPER PRE-WIRED VIEWED FROM WIRE SIDE GEN IV ECU 232002-VUA (IF USED) TEMP MODE PROGRAM * DASH LAMP (IF USED) *** WIDE OPEN THROTTLE SWITCH...
- Page 6 Gen 5 Wiring Diagram www.vintageair.com 232007-VUR AC ANNUNCIATOR BACKLIGHT POS BACKLIGHT NEG 5V-SW WHT/RED TEMP WIPER WHT/YEL MODE WIPER WHT/GRN FAN WIPER PRE-WIRED VIEWED FROM WIRE SIDE GEN 5 ECU 232002-VUA (IF USED) TEMP MODE PROGRAM DASH LAMP * (IF USED) PINK WIDE OPEN ** THROTTLE...
- Page 7 Operation of Controls www.vintageair.com On Gen IV and Gen 5 systems with three lever/knob controls, the temperature control toggles between heat and A/C operations. To activate A/C, move the temperature lever/knob all the way to cold and then back it off to the desired vent temperature.
- Page 8 Packing List: Control Panel Kit (491275) www.vintageair.com Qty. Part No. Description 491274 Control Panel Assembly 232007-VUR Universal Control Harness Checked By: Packed By: Date: NOTE: Images may not depict actual parts and quantities. Refer to packing list for actual parts and quantities. 901411 REV A 06/27/23, PG 8 OF 8...
Need help?
Do you have a question about the SureFit 491275 and is the answer not in the manual?
Questions and answers