Related Manuals for Vintage Air 491248
Summary of Contents for Vintage Air 491248
- Page 1 ISO 9001:2015 Registered Company Streamline 3-Knob Horizontal Wide Panel 491248 18865 Goll St. San Antonio, TX 78266 Phone: 800-862-6658 Sales: sales@vintageair.com Tech Support: tech@vintageair.com www.vintageair.com 901355 REV A 02/27/19, PG 1 OF 8...
- Page 2 ECU. Please confirm that your unit has the proper ECU prior to installing the control panel as shown Service Info: below. A replacement ECU can be purchased from Vintage Air if needed. Evacuate the system for 35-45 minutes with system components (Drier, compressor, evaporator and condenser) at a temperature of at least 85°...
- Page 3 Gen IV Universal Control Harness ** Before beginning installation, open all packages and check contents of shipment. Please report any shortages directly to Vintage Air within 15 days. After 15 days, Vintage Air will not be responsible for missing or damaged items.
-
Page 4: Control Panel Installation
Control Panel Dimensions www.vintageair.com 5.318” 4.250” 1.068” Level This Line Figure 1 Control Panel Installation Select a suitable location for the control panel, considering heater control valve location, wiring harness length and operator convenience. After selecting a location for the control panel, mask the area 2 ½” (tall) x 6 ½” (wide). Using the dimensions provided above, mark or scribe the control panel opening location onto the dash. - Page 5 Control Panel Installation (Cont.) www.vintageair.com Plug the control panel wiring harness into the control panel and the ECU on the evaporator (See Figure 4, below). Wire according to the wiring diagram on Page 6. Control Panel PC Board Assembly Dash Thread Into Control Panel Face...
-
Page 6: Wiring Diagram
Wiring Diagram www.vintageair.com 232007-VUR AC ANNUNCIATOR BACKLIGHT POS BACKLIGHT NEG 5V-SW WHT/RED TEMP WIPER WHT/YEL MODE WIPER WHT/GRN FAN WIPER PRE-WIRED VIEWED FROM WIRE SIDE GEN IV ECU 232002-VUA GEN IV WIRING DIAGRAM (IF USED) REV E, 10/6/2017 TEMP MODE PROGRAM * DASH LAMP (IF USED) - Page 7 Operation of Controls www.vintageair.com On Gen IV systems with three lever/knob controls, the temperature control toggles between heat and A/C operations. To activate A/C, move the temperature lever/knob all the way to cold and then back it off to the desired vent temperature.
- Page 8 Packing List: Control Panel Kit (491248) Streamline 3-Knob Horizontal Wide www.vintageair.com Qty. Part No. Description 491249 Streamline 3-Knob Horizontal Wide Control Panel 232007-VUR Gen IV Universal Control Harness Checked By: Packed By: Date: NOTE: Images may not depict actual parts and quantities.
Need help?
Do you have a question about the 491248 and is the answer not in the manual?
Questions and answers