Ariens walk behind lawn mower parts manual (17 pages)
Summary of Contents for Ariens LM21SC
Page 1
Walk Behind Lawn Mower Owner/Operator Manual Models 911511 - LM21SC 911513 - LM21 911514 - LM21S 911515 - LM21SE 911516 - LM21SW ENGLISH FRANÇAIS ESPAÑOL Transfer Coller l’autocollant du model & modèle et du numéro de serial number série dans cet encadré.
Page 2
- El abajo firmante - Undertegnede, - Undertecknaren av detta dokument, - Me, allekirjoittaneet, ARIENS COMPANY, certify that the Walk Behind Lawn Mower - certifie que les tondeuses - bestätige ich, daß der handgeführte Rasenmäher - verklaart dat de maaitrekker - certifica che i tosarba - certifica que el tractor cortacésped de empuje manual - bevidner herved at...
CONTROLS AND FEATURES 11. Poignée du démarreur manuel 12. Commande de l’entraînement des roues (tondeuses autotractées) 13. Déflecteur à paillis Mulchmaster™ 14. Commande des gaz (modèle professionnel) 15. Trous de réglage du guidon 16. Indicateur de vitesse ESPAÑOL 1. Control del motor 2.
Before operation of unit, carefully and A warranty registration card must be filled out completely read your manuals. The contents by the Ariens dealer, signed, and returned at will provide you with an understanding of time of sale. This card activates the warranty.
DISCLAIMER Ariens reserves the right to discontinue, make changes to, and add improvements upon its products at any time without public notice or obligation.The descriptions and specifications contained in this manual were in effect at printing. Equipment described within this manual may be optional.
Page 6
SAFETY DECALS AND LOCATIONS ALWAYS replace missing or damaged Safety Decals. Refer to Figure 3 for Safety Decal locations. DANGER / PELIGRO CAUTION • BAG IS SUBJECT TO WEAR AND DETERIORATION. • CHECK BAG FEQUENTLY, REPLACE WHEN TO AVOID SERIOUS INJURY OR DEATH NECESSARY.
Page 7
NEVER operate the engine with the Rear NEVER leave unit unattended on a slope. Door open unless the Grass Bag is in place. Chock wheels if parking on a slope. When mulching, the Side Discharge Opening Mow across the face of slopes, never up and Cover must be installed and the Rear Door down.
Page 8
Accessories excessive lubricants. Use only accessories which have been Battery (electric start models) approved by Ariens and are properly installed. Avoid Electric Shock. DO NOT remove wire Spark Arrestor from spark plug while engine is running. Do not put battery in fire or mutilate.
ASSEMBLY TO REMOVE UNIT FROM CARTON 3. Cut out back of carton and roll unit out. 4. Remove protective packaging 1. Cut off top of carton. materials. 2. Remove front and rear inserts and literature pack. OM0340 L i t a t u OM0320 OM0311...
OPERATION CONTROLS AND FEATURES To change cutting height, move cutting height levers one notch at a time on each wheel until See Figures 1 and 6 for Controls and desired height of cut is obtained. (Figure 6) Features. Cutting Height Settings Chart WARNING: DO NOT attempt to start Notch Cut grass length...
Page 11
OPTIONAL CONTROLS Speed Selector See Figures 1 and 6. Speed Selector is used to select variable forward travel speeds of mower. Cutting Height – Swivel Models High –Push selector all the way CAUTION: On swivel wheel forward. models, when mowing on slopes it is recommended that the linchpin be positioned through the swivel lock hole.
Page 12
Allow Check grass bag frequently for wear engine to cool several minutes or deterioration. Replace worn or damaged bag with Ariens original before removing fuel tank cap. equipment replacement bag only. Never fill tank when engine is running or is hot from operation.
Page 13
STARTING AND SHUT OFF Mowing Tips See Figures 1, 4 and 6 for all Controls and Features. CAUTION: On swivel wheel models, when mowing on slopes it is NOTE: Start engine on a hard level surface that is free of debris. recommended that the linchpin be positioned through the swivel lock Manual Start...
MAINTENANCE Ariens Dealers will provide any service, parts or adjustments which may be required to keep WARNING: Stop engine, wait for your unit operating at peak efficiency. Should moving parts to stop, and remove engine service be required, contact an Ariens...
Page 15
GENERAL LUBRICATION Mower does not require any lubrication. Wheel assemblies are designed for long life without additional lubrication. NOTE: The LM21SC does have lube fittings on drive mount for use in commercial applications. Lubricate as needed. (swivel units) Swivel Lubrication See Figure 10.
Page 16
When using Sten Mix Grease for the first time, CHECK FASTENERS all components should be thoroughly cleaned Check all fasteners for proper tightness. Pay prior to lubricating. special attention to blade hardware and all guards, shields and safety devices. NOTE: Linchpin must be in the swivel lock CHECK SPARK PLUG hole while lubricating.
SERVICE AND ADJUSTMENTS SERVICE POSITION IMPORTANT: When tipping to service engine or unit, use the following service positions for WARNING: ACCIDENTAL ENGINE the brand and type of engine on your mower: START UP can cause death or Robin Engines: place handlebar into service serious injury.
Page 18
3. Charge for 24 to 48 hours (battery may be charged for up to 72 hours with no harmful effects). An engine run time of at least 8 hours is required to charge a fully discharged battery. To Remove Battery from Unit 1.
Page 19
DRIVE BELT (Self propelled units) 3. To obtain the proper adjustment, turn the cable nuts. Turn clockwise if the To remove drive belt: measurement is more than 2" (5cm); 1. Position right hand rear wheel Height counterclockwise if the measurement is Adjustment lever in first notch and left less than 1-1/2"...
Clean unit thoroughly. Brush dirt and debris off with a brush. Apply paint or spray lubricant to exposed metal joints and surfaces. Matching touch-up paint is available from your Ariens Dealer. Do not use abrasives, solvents, or harsh cleaners. Inspection Inspect mower for signs of wear or damage.
8. Bearings damaged. 8. Replace bearings.Contact 9. Debris in gear set. your Dealer. 9. Remove debris. Contact your Dealer. SERVICE PARTS Always use genuine Ariens parts to keep your Mower running like new. Mower Model 911511 911513 911514 911515 911516...
Ariens Company warrants to the original purchaser that consumer products manufactured by Ariens Company will be free from defects in material and workmanship for a period of two (2) years after the date of purchase, and will repair any defect in material or...
Page 24
Ariens Company 655 West Ryan Street P.O. Box 157 Brillion, WI 54110-0157 920-756-2141 Fax 920-756-2407 www.ariens.com...