Table of Contents
Advertisement
9 Maintenance
9.1 Wear and Tear Information
General Information
Normal wear and tear items and components include
but are not limited to: all upholstery items including
seat and back upholstery, arm and calf pads, cushions,
wheels, tires and casters, all types of batteries, joystick
overlays and inductive rubberized protective boots.
Invacare reserves the right to ask for any item back
that has an alleged defect in workmanship. Refer to
the Warranty section in this manual for specific
warranty information.
Refer to the Inspection Checklists for proper
preventative maintenance schedule.
This is just a general guideline and does not include
items damaged due to abuse and misuse.
Product Type
Wheelchairs
Mobility Hardware and
Electronics
Upholstery and Seating
Batteries
9.2 User/Attendant Inspection Checklists
Every six months, and as necessary, take your
wheelchair to a qualified technician for a
60127229-A
Product Wear and Tear
Wheels, Brake Assembly,
Hand Grips
Rubber Urethane Tires
and Casters, Handgrips,
Joystick Inductive Tops,
Joystick Overlays, Joystick
Housing, Bus Cables for
Electronics, Motors and
Gearboxes (if exposed to
prolonged moisture,
urine, etc.), Pneumatic
Tires and Tubes
Arm pads, Seat Cushion
Foam, Seat Cushion
Covers, Back Cushion
Foam, Back Cushion
Covers, Headrest Foam,
Headrest Covers,
Footplate Covers, Calf
Pad (if applicable) Foam
and Cover
Lead acid/Lithium, Coin
cell (watch type), Gel (6
months)
thorough inspection and servicing.
Weekly, monthly, and periodic inspections
should be performed by user/attendant
between the six month service inspections.
Regular cleaning will reveal loose or worn
parts and enhance the smooth operation of
your wheelchair. To operate properly and
safely, your wheelchair MUST be cared for just
like any other vehicle. Routine maintenance
will extend the life and efficiency of your
wheelchair.
DANGER!
Risk of Injury, Damage or Death
Overinflation of tires may cause tires to
explode.
-Inflate tire to the proper tire pressure
(P.S.I. / kilopascals) listed on the side
wall of the tire.
-Only use wheelchair with tires at
proper pressure.
-The wheels and tires should be checked
periodically for cracks and wear and should
be replaced if necessary.
9.2.1 Inspect/Adjust Weekly
Ensure that the casters are free of debris.
Inspect tires for flat spots and wear.
Inspect all fasteners.
Inspect TRRO fasteners and hardware.
Ensure proper operation of powered functions
(Example: drive, seating and legrests).
9.2.2 Inspect/Adjust Monthly
Clean upholstery and armrests.
Clean dirt and lint from axles.
Clean dirt and lint from bearings.
Ensure that the casters are free of debris.
Inspect seat positioning strap for any signs of wear.
Ensure buckle latches. Verify hardware that
attaches strap to frame is secure and undamaged.
Replace if necessary.
Invacare® AVIVA® Storm RX
40
Advertisement
Table of Contents
