Page 1
OWNER’S MANUAL 19-Inch 2x20V (40V) Lithium-ion Cordless Mower With (2) 20V 4.0Ah Lithium-ion Batteries Copyright All Rights Reserved. Model 622019-1 BATTERY MUST BE CHARGED BEFORE FIRST USE. TWO TO THREE INITIAL CHARGING/ DISCHARGING CYCLES MAY BE REQUIRED TO ACHIEVE MAXIMUM RUN TIME/CAPACITY.
To avoid serious injury, do not attempt to use this product until you read thoroughly and understand completely the owner‘s manual. If you do not understand the warnings and instructions in the owner‘s manual, do not use this product. Call Yardworks customer service for assistance. WARNING: The operation of any power tool can result in foreign objects being thrown into your eyes, which can result in severe eye damage.
Tragic accidents can occur if the operator is not alert to the WARNING: Cancer and Reproductive Harm – presence of children. Children are often attracted to the www.P65Warnings.ca.gov. machine and the mowing activity. Never assume that children will remain where you last saw them. Model 622019-1...
Page 4
Stay behind the handle when the motor is running. • Do not mow near drop-offs, ditches, or embankments. • Mow across the face of slopes, never up and down. Exercise extreme caution when changing direction on slopes. Model 622019-1...
Page 5
Do not use battery-operated appliance in rain. • • Recharge only with Yardworks 20V charger (CHL82000- Remove or disconnect battery before servicing, cleaning 1). A charger that is suitable for one type of battery pack or removing material from the gardening appliance.
CAUTION Indicates a potentially hazardous situation, which, if not avoided, may result in minor or moderate injury. CAUTION (Without Safety Alert Symbol) Indicates a situation that may result in property damage. Model 622019-1...
Environmental Protection Agency for information and specific instructions. Take the battery to a local recycling and/or disposal center for disposal. Never throw the battery pack away in a standard receptacle or have it incinerated. See page 13 for more details. Model 622019-1...
20V 4.0Ah Batteries Never operate the mower without the proper safety 20V Charger devices in place and working. Never operate the mower with damaged safety devices. Failure to heed Owner‘s manual this warning can result in serious personal injury. Model 622019-1...
Page 9
A pinched live power cord can cause the handles to become electrically energized. Contact with electrically live conductive parts will result in death by electrocution, electric shock, and/or serious personal injury. Model 622019-1...
Page 10
When the grass bag is not full, the watch window will rise up. After the grass bag is full, the watch This product will accept Yardworks 20V x 2 lithium-ion window will not rise up. battery packs only.
Tighten securely all fasteners and caps and do not operate this product until all missing or damaged parts are replaced. Please contact customer service or an authorized service center for assistance. Fig. 8 To stop the mower: • Release the bail wire. Model 622019-1...
Page 12
If you Fig. 9 feel you are losing your balance, re- lease the switch control bail wire im- mediately. • Do not mow near drop-offs, ditches, or embankments; you could lose your footing or balance. Model 622019-1...
CHARGING THE BATTERY PACK When fully charged, the battery can be safely stored in Charge the battery packs only with Yardworks 20V Chargers. temperatures down to -4 degrees F (-20 degrees C) for a Allow at least 160 minutes of charge time for each 4.0Ah period of up to four weeks, before requiring charging.
When seated properly, the blade should be flat. • Replace the blade, then thread the blade nut onto the shaft and finger tighten. Model 622019-1...
Page 15
See Figure 14 When sharpening, care should be taken to keep the blade balanced. An unbalanced blade will cause excessive vibration when the mower is running. This vibration will eventually cause damage to the mower, especially the motor. Model 622019-1...
Page 16
Lower the handle assembly as shown in figure 15. • Store mower indoors in a clean, dry place out of the reach of children. • Do not store near corrosive materials such as fertilizer or rock salt. Fig. 15 Model 622019-1...
Bent motor shaft. Contact the service center at 1-800-633-1501. Handle not in position Carriage bolts not seated properly. Adjust the height of the handle and make sure the carriage bolts are seated properly. Handle knobs not tightened. Tighten handle knobs. Model 622019-1...
BL80204-1 20V 4.0Ah Battery CHL82000-1 20V Charger CALL US FIRST !! Call us first with questions about operating or maintaining your product at 1.800.633.1501 between 8:00 a.m. – 5:00 p.m. Eastern Standard Time, or get assistance on www.americanlawnmower.com. Model 622019-1...
The Great States Corp. (GSC) warrants to the original owner that this Yardworks product and service part is free from defects in ma- terials and workmanship and agrees to repair or replace any defective product or part for the warranty period as stated above.