DIGITAL AMD OPERATING INSTRUCTIONS FOR S110, S164, & S281 MODELS ��������������������������������������������������������������������������������������������������8 SYSTEM INSTALLATION DIAGRAMS ���������������������������������������������������������������������������������������������������������������������������������������������������������������������9 MAINTENANCE ��������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������10 VALVES AND SWITCHES ������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������10 S110 PARTS DIAGRAM ��������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������11 S280 PARTS DIAGRAM ��������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������12 S281 PARTS DIAGRAM ��������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������13 S164 PARTS DIAGRAM ��������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������14 S163/S253/S418 PARTS DIAGRAM ������������������������������������������������������������������������������������������������������������������������������������������������������������������15 TROUBLESHOOTING �����������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������16...
Misuse of this valuable and helpful air-power source may shorten its expected life as well as void the warranty of the entire unit� We ask you take the time to read this manual to ensure the dependable service you can expect from your C-Aire compressor�...
18 PSI 418 GALLONS 10 PSI 810 GALLONS SELECTING A LOCATION: FACTORY SET AT 10-20 PSI C-Aire compressors are to be installed and operated in a clean, PRESSURE SWITCH MINIMUM dry, well-lighted, and well-ventilated area� DIFFERENTIAL: 5 PSI 2�21 @ 10 PSI...
Place unit on anchor bolts slide on washer and then loosely thread * nut over bolt. * Do not tighten nut. Tightening the nut may lead to stress on the frame causing damage to the unit. Install air filter assembly *Floor mounting for S280/S281 ONLY...
MOTOR WARNING: The compressor must be grounded� Ground- ing reduces the risk of electric shock� Certain C-Aire Models are equipped with a cord that has a grounding wire with a grounding plug� The plug must be plugged into an outlet that is installed and grounded in accor- dance with all local codes and ordinances�...
WIRING DIAGRAM INCOMING POWER TO PUMP POWER TO MOTOR SWITCH LINE LINE POWER MOTOR MOTOR S163R/S253R/S418R PRESSURE SWITCH S280 PRESSURE SWITCH WIRING DIAGRAM WIRING DIAGRAM POWER CORD POWER CORD WHITE WHITE DIGITAL AMD POWER DIGITAL AMD POWER SOLENOID PUMP PUMP...
START UP NOTE: There is no need to “break-in” your compressor� It has been tested and run at the factory by qualified personnel� NOTE: S163/S253/S418 - Remove the air filter when filling systems near maximum capacity� The check valve unloader orifice will continuously bleed a small amount of air while the compressor is running�...
DIGITAL AMD OPERATING INSTRUCTIONS (CONTINUED) To unlock, repeat the previous process until the SETTINGS Pressing the mode button a fourth time, the 7DAYS LOCKED light turns off� indicator will display the total number of starts in the last 7 days STARTS (The counter will not measure time if the unit has no power)�...
(see parts identification item 1)� is satisfied, the motor stops� They are both preset at the factory by C-Aire and do not require adjustment� However, if you want to Twist the top cap off of the filter housing to access the make adjustments to the Digital AMD, those instructions are on filter�...
S281 PARTS DIAGRAM Mounting Bracket RM BRACKET Solenoid Valve EL SV3V1-06 Check Valve BR 37525 Flex Hose DT 0504 Digital AMD EL D0911 Manifold BP 3M Power Cord EL CORD115V-RM Safety Relief Valve BR SV-25-70 Capacitor Cover EL CBB60-C 10 Capacitor EL CBB60 11 Filter Assembly FA S28...
S164 PARTS DIAGRAM 1 Filter Assembly FA S28 2 Digital AMD EL D0911 3 Discharge Kit DT S164-K Hose & Push Lock Fittings 4 Safety Relief BR SV-25-50 50 PSI 5 Check Valve BR PA6 NOTE: AIR WILL DISCHARGE THROUGH UNLOADER ORIFICE WHILE COMPRESSOR IS RUNNING AND SHORTLY...
WARRANTY OIL FREE COMPRESSOR C-Aire Inc� warrants its compressors to be free from defects in material and workmanship subject to the following provisions: STANDARD WARRANTY DURATION: 12 months from date of install� WHAT THE WARRANTY COVERS DURING THE WARRANTY DURATION: All components on the compressor except for those items listed in the section titled “What is excluded from warranty coverage”�...
Page 20
380 West 1st Street, Dresser, WI 54009 800�762�2247 - 651�462�3440 www�cairecompressors�com...
Need help?
Do you have a question about the S280 and is the answer not in the manual?
Questions and answers