Air curtain with disinfection technology (28 pages)
Summary of Contents for Airtecnics ZEN
Page 1
Air curtain: ZEN (M, G, ECG) INSTALLATION, OPERATION AND MAINTENANCE MANUAL Please, read these instructions carefully before attempting installation Deliver this manual to the final user. SECURITY ADVISE SYMBOLS Danger from electric current or high voltage! ¡Attention, Danger, Safety Advice! Injuries risk! Danger! Do not stay underneath: Heavy load.
INSTALLATION Tips and recomendations for a good installation LENGTH CENTERED/ HEIGHT (*) Unless it has been de- signed to be installed at that height. DOOR DISTANCE Instruction manual - Air curtain ZEN...
Page 5
AIR DISCHARGE AIR ASPIRATION MAINTENANCE ACCESSIBILITY CONTROL (CLEVER) Instruction manual - Air curtain ZEN...
Page 6
In this case, dimension B will be 100 mm� The minimum recommended distance between the suction grille and any obstacle is 200 mm (Dimension A) Dimension D: service opening distance� Instruction manual - Air curtain ZEN...
Page 7
Connexion diagram Standard without heating, with water and electric heating 400V x 3 Instruction manual - Air curtain ZEN...
Page 8
The anchor must be sized according to the weights of each curtain indicated on the techni- cal data page� The installation can be done using threaded rods, tensioners or other supports (see available supports in the accessories section)� Instruction manual - Air curtain ZEN...
Page 9
During the first uses, the electric battery can give off some odor that disappears in a few days. According to battery power, the regulation is carried out by: Coil heating power (kW) Regulation type 9 / 12 / 15 / 18 / 22,5 / 24 PRBEO CONTACTORS Instruction manual - Air curtain ZEN...
- 5 fan speeds� - Memory: guarantees that, in the event of a power outage, the selected speed is maintained when service is restored� This function can be activated/deactivated using the ON/OFF switch located inside the regulator� Instruction manual - Air curtain ZEN...
Page 11
It also prevents the air expelled by the curtain from exceeding 60ºC (excessive thermal sensation for people)� Instruction manual - Air curtain ZEN Common characteristics to all regulators for electric batteries...
Page 12
), there are two controllers that allow much more possibilities than the standard controller, especially the Clever� The following regulators have their own manual: • Hand Auto • Clever control Instruction manual - Air curtain ZEN Remote Control Features...
Page 13
In air curtains with electrical heating, it modifi es the power of the heating. On air curtains with water heating, it opens and closes the solenoid valve� It works with batteries of type AAA / LR03� Instruction manual - Air curtain ZEN...
ELECTRICAL SCHEMES Curtain with water battery or only air with standard regulator (AIRDOE09051) In case there is a need to connect the curtain to a PLC, the corresponding diagram is attached� Instruction manual - Air curtain ZEN...
Page 15
Curtain with water battery or without heating with Hand Auto (AIRDOE09251) In case there is a need to connect the curtain to a PLC, the corresponding diagram is attached� Instruction manual - Air curtain ZEN...
Page 16
Electric curtain <27kW with PRBEO and standard regulator (AIRDOE09110) In case there is a need to connect the curtain to a PLC, the corresponding diagram is attached Instruction manual - Air curtain ZEN...
Page 17
30kW electric curtain with standard regulator (AIRDOE09101) In case there is a need to connect the curtain to a PLC, the corresponding diagram is attached Instruction manual - Air curtain ZEN...
, otherwise the mixture between the dust and a damp cloth would form a paste of dirt that could damage the fan rotor when it sucks in the air or clog the water coil� An annual cleaning of the discharge area must be carried out� Instruction manual - Air curtain ZEN...
Page 21
110% and 85% of the value indicated on the label� Check that all fans blow air� Keep the curtain at full speed for a few minutes and listen for abnormal noises from the curtain� Instruction manual - Air curtain ZEN...
Page 22
Check the inlets and outlets of the water tubes to ensure that there are no fl uid leaks. If a water leak has been detected in the battery, possible corrosion problems in both the battery and the curtain components should be checked. Instruction manual - Air curtain ZEN...
G , M : Water VERCCO33005 CW - 5AW - IR speed regulator IR receptor (P86, P64, P54) Electrical WINDBOX M,G 5 VERCCO33010 CE - 5AW - IR G , M: Electrical speed regulator IR receptor Instruction manual - Air curtain ZEN...
Page 25
Next, identify and release the fan cables. Remove the fan by loosening the four fixing screws (one on each side) and mount the replacement fan following the process in reverse order� Instruction manual - Air curtain ZEN...
Page 26
Recommendation: installation with silentblocks To reduce the sound level and the vibrations of the curtain, it is recommended to carry out an installation with silentblocks: Instruction manual - Air curtain ZEN...
Page 27
Before removing the screws that secure the battery: 1. Remove the battery suction grille. Remove the rubber plug and the suction grille screws : Lift and slide the suction grille to one side to remove it : Instruction manual - Air curtain ZEN...
Page 28
2. Remove the union phase and the sides of the curtain by removing the corresponding screws: 3. Remove the screws and fixing angles of the battery. 4. Empty the battery. Instruction manual - Air curtain ZEN...
Page 29
1. Disconnect the power supply from the battery itself by unscrewing the two screws on the connec- tion box: 2. Remove the screws and fixing angles of the battery. Air curtain size Nº lateral fixing angles 1000 1500 2000 2500 Instruction manual - Air curtain ZEN...
Run the cable as far away as possible from sources of constantly for no apparent reason but interference, emitters, cable interference (especially on long runs) or use a shielded the control lights do not fl ash trays, especially those that cable feed motors, etc� Instruction manual - Air curtain ZEN...
Page 31
Suports, feets, silentblocks, etc� (depending on model)� Door contact, thermostatic valve, solenoid valve, antifreeze sensor, etc�� RJ45 cable 20m y 50m� Instruction manual - Air curtain ZEN...
If you detect some error in this manual, we’ll be pleased to receive your feedback, it helps us to improve even more. Airtècnics reserves the right to modify some of the specifi cations in this manual Instruction manual - Air curtain ZEN...
Page 36
Conca de Barberà, 6 - Pol. Ind. Pla de la Bruguera E-08211 Castellar del Vallès (Barcelona) Spain ☏ + 34 93 715 99 88 airtecnics@airtecnics.com www.airtecnics.com AIRDOM05081-R14(01/22) Airtècnics reserves the right to modify some of the specifications in this manual.
Need help?
Do you have a question about the ZEN and is the answer not in the manual?
Questions and answers