Related Manuals for MULTIQUIP YELLOW SUBMARINE
Summary of Contents for MULTIQUIP YELLOW SUBMARINE
- Page 1 OPERATION AND PARTS MANUAL YELLOW SUBMARINE SUBMERSIBLE PUMP Revision #1 (03/22/10) THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
-
Page 2: Table Of Contents
@ www.discount-equipment.com Select an option below to find your Equipment We sell worldwide for the brands: Genie, Terex, JLG, MultiQuip, Mikasa, Essick, Whiteman, Mayco, Toro Stone, Diamond Products, Generac Magnum, Airman, Haulotte, Barreto, Power Blanket, Nifty Lift, Atlas Copco, Chicago Pneumatic, Allmand, Miller Curber, Skyjack, Lull,... -
Page 3: Table Of Contents
Troubleshooting/Cable .......... 13 without notice. Pump Assy............14-15 Terms And Conditions Of Sale — Parts ....16 PAGE 2 — YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) -
Page 4: Safety Information
COULD result in DEATH or SERIOUS INJURY. CAUTION Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Addresses practices not related to personal injury. PAGE 4 — YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) - Page 5 No one other than the operator is to be in the working area when the equipment is in operation. DO NOT use the equipment for any purpose other than its intended purposes or applications. YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) — PAGE 5...
- Page 6 flame. Application of heat in this manner may heat the oil in the seal cavity above the critical point, causing pump damage. PAGE 6 — YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10)
- Page 7 National Electrical Code (NEC) and local codes before operating generator. Severe injury or death by electrocution can result from operating an ungrounded motor. NEVER use gas piping as an electrical ground. YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) — PAGE 7...
-
Page 8: Specifications
Motor Rotation – Upon start-up, the pump "kicks" in the opposite direction of motor rotation. The correct rotation is counterclockwise (CCW) as viewed from the impeller end of the pump. PAGE 8 — YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) -
Page 9: General Information
DO NOT install the pump directly into an area where there is a heavy build-up of mud, grit, silt or debris. If this condition is present, install the pump on a platform before operating. YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) — PAGE 9... -
Page 10: Components
AC power cable. Always check the cable for signs of wear. NEVER! use a defective power cable. Replace the cable immediately if the cable is worn or defective. PAGE 10 — YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) -
Page 11: Operation
3. After the pump has been positioned correctly into place, power can be applied to the pump's electric motor. Figure 2. Submersible Pump Upright Position (Correct) YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) — PAGE 11... - Page 12 This pump is supplied with a grounding conductor and a grounding-type attachment plug. To reduce the possibility of electric shock, make certain that pump is connected only to a properly grounded receptacle. PAGE 12 — YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10)
-
Page 13: Troubleshooting/Cable
. t f . t f . t f . t f . t f . t f t l u o r f t l o YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) — PAGE 13... -
Page 14: Pump Assy
PUMP ASSY. PAGE 14 — YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) - Page 15 QTY. REMARKS YS139495 CABLE 9 FT. 80000-002 CABLE 20 FT YS137728 GARDEN HOSE ADAPTER YS137727 FITTING, 3/4" NPT YS020331 BUSHING YELLOW SUB YS139492 STRAINER BASE YELLOW SUBMARINE PUMP — OPERATION AND PARTS MANUAL — REV. #1 (03/22/10) — PAGE 15...
-
Page 16: Terms And Conditions Of Sale - Parts
We sell worldwide for the brands: Genie, Terex, JLG, MultiQuip, Mikasa, Essick, Whiteman, Mayco, Toro Stone, Diamond Products, Generac Magnum, Airman, Haulotte, Barreto,... - Page 17 OPERATION AND PARTS MANUAL HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING Your Local Dealer is:...