Commercial refrigeration unit cooler medium & low temperature (21 pages)
Summary of Contents for Daikin LXE10E-A33
Page 1
Marine type Container Refrigeration Unit Service Manual · Parts List Optional Functions LXE10E -A33 LXE10E -A33A TR06-04A...
Page 2
Covered Models Regarding the features and operation of the unit, this service manual describes the items which are different from those of the service manual TR01-09A. Different points from service manual Item (Maintenance and Repair) 1☆ Dehumidification function Refer to the details in the following pages.
Page 3
*Differences from standard model service manual (TR01-09A) are marked with ☆ CONTENTS Safety Precautions 3.10 Chartless function ........3-56 • Danger ..............3 3.10.1 Chart indication function ....3-56 • Warning ............... 4 3.10.2 P code (Pull down time indication) ..3-58 •...
Page 4
1. Introduction 1.1 OPERATION RANGE Use the units within the following range. Item Operation range Ambient temperature range -30˚C to +50˚C (-22˚F to + 122˚F) Inside temperature range -30˚C to +30˚C (-22˚F to + 86˚F) 50Hz: 380V/400V/415V, 60Hz: 440V/460V Voltage Voltage fluctuation rate should be within ±10%...
Page 6
2.2 Names of components 2.2.1 Outside ●LXE10E 2 1 2 0 1 9 1 6 1 5 q Access panel !6 Discharge pressure regulating valve (DPR) w Thermometer check port (Return air) !7 Compressor suction pipe temperature e Condenser fan motor (CFM)
Page 7
2.2.2 Inside ●LXE10E q Evaporator fan motor (EFM) w Evaporator e Supply air temperature sensor (SS) Data recorder supply air temperature sensor (DSS) r Evaporator outlet pipe temperature sensor (EOS) t Evaporator inlet pipe temperature sensor (EIS) y Return air temperature sensor (RS)
Page 8
2.2.3 Control box GInside of the control box In case of LXE10E-A33 In case of LXE10E-A33A (Same as A33 besides ⑧, ⑩, ⑫.) PAK-61JC PAK-61JC PAK-61JC PAK- F U S E B 3 P S V H R A – H 3 4 1 T D...
Page 9
2.3 Set point of functional parts and protection devices Device name Actuation Set point Detection method Symbol High-pressure switch 2400kPa (24.47kg/cm High-pressure switch 1900kPa (19.37kg/cm Water pressure switch 98kPa (1.0kg/cm Water pressure switch (optional) 39kPa (0.4kg/cm Chilled mode +30.0°C ~ –10.0°C Set point temperature (+86.0°F ~ –14.0°F)
Page 10
2.4 OPERATION MODES AND CONTROL The relationship between the operation mode and setting temperature is as follows. Operation mode Setting temperature Control sensor Operation description –10.1˚C to –30.0˚C Return air Frozen mode Compressor ON/OFF control (13.82˚F to –22.0˚F) temperature sensor Capacity control operation +30.0˚C to –10.0˚C...
Page 11
3 Dehumidification mode The unit have dehumidification control by a reheat coil, which is under the evaporator coil. To execute dehumidification, controller setting is required. (Refer to Page 3-12) In dehumidification, the Reheat Solenoid Valve (RSV) opens to flow high pressure and high temperature refrigerant to reheat coil.
Page 12
4. Mode Operation MODE Press the key in current indication mode to move to MODE operation. All indication Lights on (for 3 sec.) Starting Preparation (for 18 sec.) Current indication (Operation state) MODE MODE OPERATION In mode operation, the following settings/operations are available.
Page 13
5 Alarm display and back-up function 5.1 Alarm list Alarm Alarm Alarm content Action with alarm grouping code F101 HPS activated within 30 seconds after operation start or protection device Unit stops activated 5 times at start-up operation or Fuse 1 brown (Refer Page 7-7).
Page 14
6.1 Specifications Controller can use Rechargeable batteries. The battery is positioned on CPU & I/O box in controller box. Rechargeable: DAIKIN original rechargeable battery 6.2 Function This battery is used without main power supply for the following functions. 1) Display wake up (Refer to chapter 3.3.2) page 3-11.
Page 15
6.4 Battery replacement (Rechargeable battery) Detach the cover of battery and replace the battery Rechargeable battery (In case of LXE10E-A33) (Battery fixing plate) Rechargeable battery (In case of LXE10E-A33A) Voltage indicator (Battery check meter) (Battery fixing plate) 3-40...
Page 16
8 Electronic expansion valve ● Model Coil : EBM-MD12MD-30 (2) Replacing the body q Loosen the lock nut, then remove the coil. Body : EDM-B804DM-1 w Remove the hexagonal head bolts, and cut This unit adopts an electronic expansion valve.
Page 17
9. APPENDIX 9.1 Piping diagram HEAT EXCHANGER SERVICE PORT (HIGH) (QUICK JOINT TYPE) SERVICE PORT (HIGH) CHECK VALVE RECEIVER (QUICK JOINT TYPE) LIQUID INDICATOR DRIER SERVICE PORT (HIGH) (QUICK JOINT TYPE) SERVICE PORT (LOW) HEAT EXCHANGER (QUICK JOINT TYPE)
Page 21
9.3 Stereoscopic wiring diagram (LXE10E-A33A) T r c T B 1 RCD(YORK) D R S ( B L U , R E D ) C N - 4 C N - 5 E C 1 . C N 1 6 ※...
Page 22
ORDERING INSTRUCTIONS The parts list contains the parts of the DAIKIN Marine Type Container Refrigeration Units. Please read the following items before using the list. 1. When ordering the parts, be sure to specify the model No., the name of part and the type of part.
Page 23
Denomination of Model Name L X E NOMINAL HORSE POWER 5 : 5 10 : 10 CONDENSER COOLING TYPE NIL : AIR and WATER COOLED TYPE A : AIR COOLED TYPE OPTION NUMBER Note) "R" GIVEN AFTER OPTION NUMBER STANDS FOR "REVISION"...
Page 24
C O N T E N T S 目 次 Page A. Parts related with the unit(outside)………………………………………………………………………24 庫外関連部品 B. Parts related with refrigerant piping(outside) …………………………………………………………28 庫外冷媒配管関連部品 C. Parts related with the unit(inside) ………………………………………………………………………32 庫内関連部品 D. Parts related with refrigerant piping(inside) …………………………………………………………36 庫内冷媒配管関連部品...
Page 25
Parts related with the unit(outside) 庫外関連部品 (Refer to 63Page) (Refer to 62Page) (Refer to 63Page)
Page 26
Parts related with the unit(outside) 庫外関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1549647 Power plug(400V class) 電源プラグ(400V) 3P130172-1 1787432 Power cable 電源ケーブル(400V) 3P056891-2 0954936 Condenser fan motor 凝縮器電動機...
Page 27
Parts related with the unit(outside) 庫外関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1267084 Gasket, resin bolt パッキン樹脂ボルト用 4PA63573-1 1679416 Front panel(right) 前板(右) 3P173348-1 1787456 Front panel(right) RESIN 前板(右)<樹脂>...
Page 28
Parts related with the unit(outside) 庫外関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A...
Page 29
Parts related with refrigerant piping(outside) 庫外冷媒配管関連部品 B11詳細(Detail of B11) B7-6 Discharge pipe Feeler bulb inserting pipe B21詳細(Detail of B21) B7-4 B7-3 B21 B12 B7-1 断面A-A 断面A-A B13詳細(Detail of B13) Suction pipe Feeler bulb inserting pipe B7-5 B8-1-1 B8-1-2 B7-7 B7-2 B8-1-3 B8-1-5 B8-1-4 B6-1 B8-1 B3-2 B5-2...
Page 30
Parts related with refrigerant piping(outside) 庫外冷媒配管関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1315426 Compressor 圧縮機 JT224DBNYR 1387173 Air cooled condenser 空冷凝縮器 2P089486-1 CA-LXE10E1 Air cooled condenser 空冷凝縮器...
Page 31
Parts related with refrigerant piping(outside) 庫外冷媒配管関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A B7-6 0088738 Nev type solenoid valve body NEV型電磁弁本体 R3305099-1-KI NEV-202DXF Refer to Page64...
Page 32
Parts related with refrigerant piping(outside) 庫外冷媒配管関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A...
Page 33
Parts related with the unit(inside) 庫内関連部品 Option Option E57詳細(Detail of E57) Sealing compound (KE44RTV or its equivalent) シール剤 (KE44RTV又は相当品) INSIDE OUTSIDE PUTTY (Equivalent of NEO-SEAL B-1) パテ (ネオシールb-1相当品) C3 C6 C40 C39 A部詳細(Detail of A) C17-2 <Without recorder> RS(Blue) DRS(Blue・Red) C17-1 C23詳細(Detail of C23)
Page 34
Parts related with the unit(inside) 庫内関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 0955333 Three phase AC fan motor 三相交流ファン電動機 3PA07524-4 0955340 Three phase AC fan motor 三相交流ファン電動機...
Page 35
Parts related with the unit(inside) 庫内関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1713361 Sensor(DRS) センサー(DRS) 3PA61769-19 Refer to Page66 860015 Universal nut 自在ナット R4713188-1 860011 Speed bolt スピードボルト(M6)...
Page 36
Parts related with the unit(inside) 庫内関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A...
Page 37
Parts related with refrigerant piping(inside) 庫内冷媒配管関連部品 D4詳細(Detail of D4) D3-3 D3-7 D3-4 D3-5 Feeler bulb inserting pipe D3-2 D3-2 D5詳細(Detail of D5) D3-8 D3-6 Feeler bulb 感温部 D3-9 D3-1 D3-10...
Page 38
Parts related with refrigerant piping(inside) 庫内冷媒配管関連部品 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1683927 Evaporator ass'y 蒸発器組立品 2P163797-1 CRB-LXE10E9 1787470 Evaporator ass'y 蒸発器組立品 2P195931-1 CRB-LXE10E15 1683934 ass'y for pipe of drain pan ドレンパン配管組立品...
Page 39
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等) C詳細(Detail of C) B詳細(Detail of B) Tie wrap Wires E断面(Section of E) Condenser coil...
Page 40
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等) ※(L = XX mm) indicates the length of cushion rubber E35.(Cut to suit pipe size.) ※(L = XX mm)と表記のものは、緩衝ゴム(E35)の長さです。(配管のサイズに合わせて切って使用ください。) 矢視A/B(View A/B) 矢視D(View D) (L=50mm) 受液機器部詳細 (Receive part detail) (L=90mm) (L=60mm) ドライヤー部詳細 圧力センサー配管部詳細 (Dryer part detail) (Pressure tranducer detail) E31(L=40mm)
Page 41
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等) EFM1 EFM2 矢視A(VIEW A)
Page 42
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等) FAN GUIDE ファンガイド...
Page 43
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等)...
Page 44
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等) QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1266694 Set plate, discharge pipe 吐出配管取付板 4P079462-1 Page39 1779727 Set plate, discharge pipe 吐出配管取付板...
Page 45
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等) QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1584260 Cushion rubber 緩衝ゴム NE41013-4-230 Page40 1267060 Packing for prevention of air bypass バイパス防止用パッキン...
Page 46
Other parts(Pipe clamp, sealing and insulation material etc.) その他部品(配管固定具、シール材、防熱材等) QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A...
Page 51
Control box コントローラボックス QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 平蝶番(レコーダボックス蓋) 4P021346-1 1136407 Hinge(recorder/box cover) 当板ナット 1136414 Patch plate nut 4P044898-2 コントロールボックス溶接組立品 2P098553-4 1622496 C.BOX welding ass'y コントロールボックス組立品...
Page 52
Control box コントローラボックス QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1267541 Cover ass'y, PC port パソコンポートカバー組立品 3P010743-1 0954633 PT/CT board PT/CTボード 2P010906-3 1256116 Terminal strip boaed 端子台基板...
Page 53
Control box コントローラボックス QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 380401 Locking card spacer ロッキングカードスペーサー R3428091-2 1326820 Packing for control box front plate パッキン (コントロールボックス前板 (左) ) 4P085513-1 1739387 Packing for control box front plate パッキン...
Page 54
Control box コントローラボックス QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A...
Page 55
Parts related with name plate 銘板関連 コントロールボックス内部(Inside of Control Box) 電磁弁配置銘板貼付位置詳細 (Detail location of nameplate, solenoid valve) Name plate, solenoid valve 電磁弁配置銘板G9 A断面(Section A)
Page 56
Parts related with name plate 銘板関連 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1684045 Name plate, ventilator 換気口銘板(%併記仕様) 4P176172-1 1267952 Name plate, ventilator arrow ベンチレータ矢印銘板 4P018502-1 1646081 Name plate, operation 操作銘板(C&MODE,韓)...
Page 57
Parts related with option 1 – USDA オプション関連部品1 – USDA関連 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1622580 Mounting plate ass'y, receptacle USDA取付板(樹脂) 2P146266-1 0991531 PC port connector パソコンポートコネクタ...
Page 58
Parts related with option 2 – MODEM オプション関連部品2 – モデム MODEM モデム Supply by customer 客先支給 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 0954640 Noise filter ノイズフィルタ...
Page 59
Parts related with option 3 – Others オプション関連部品3 – その他 1.Indoor fan guard 1.庫内ファンガード 2.Evaporator coil 2.蒸発器コイル組立品...
Page 60
Parts related with option 3 – Others オプション関連部品3 – その他 QTY/UNIT PARTS NO. DWG. NO. TYPE SPECIFICATION REMARKS INDEX PARTS NAME LXE10E- 部品名称 符号 部品番号 図面番号 形式 仕様 備考 A33 A33A 1605299 Inside fan cover 庫内ファンカバー(P&ON) 3P150480-1 1605484 Fixture 固定具(網・中央)...
Page 61
List of size for standard pipe clamp 配管固定具サイズ表 1.Resin clamp 1.樹脂バンド (外穴) (OUTER HOLE) (内穴)(外穴) (INNER HOLE)(OUTER HOLE) (INTERMEDIATE HOLE) (内穴)(中穴)(外穴) (INNER HOLE) (OUTER HOLE) PARTS NO. DWG NO. SIZE サイズ PARTS NAME 部品名称 LXE10E- 符号 部品番号 図面番号 A33A E10 1222764...
Page 62
List of size for standard pipe clamp 配管固定具サイズ表 2.Tube clamp 2.管止金 2-φ5.5穴 SIZE サイズ PARTS NO. DWG NO. PARTS NAME 部品名称 LXE10E- 符号 部品番号 図面番号 A33A 1592425 Tube clamp 管止め金 NE31016-58 E15 0782775 Tube clamp 管止め金 NE31016-51 E16 1584215 Nylon coating tube clamp ナイロンコーティング管止め金 4P143802-51 E17 1584208 Nylon coating tube clamp ナイロンコーティング管止め金...
Page 63
Notes for ordering spare parts 部品発注の際の注意事項 1.Parts recommended to be ordered together with packing, gasket, sealing material and name plate 1.発注の際にパッキングやシール材、銘板等の同時発注を推奨する 部品 For ordering following spare parts, we recommend that you order the following packing, gasket, sealing material and name plate together at the same time. 上記のサービス扉やボックスカバーを発注の際には、下記のパッキングを同時に発注 することをおすすめします。 (1)Service door (1)サービス扉 PARTS NO. DWG NO. REMARKS PARTS NAME 部品名称 符号 部品番号 図面番号 備考 (Without cushion and sealing material) 1612576 Access panel (FRP) サービス扉組立品 1P006678-5 (クッション材、...
Page 64
Notes for ordering spare parts 部品発注の際の注意事項 (3)Ventilation cover (3)換気口蓋 PARTS NO. DWG NO. PARTS NAME 部品名称 符号 部品番号 図面番号 A19 1266120 Ventilation cover 換気口蓋 3P067053-1 Sealing material シール材 A20 1266221 4P016185-1 (Ventilator) (換気口) (4)Front plate (CA) (4)前板(CA) PARTS NO. DWG NO. PARTS NAME 部品名称...
Page 65
Notes for ordering spare parts 部品発注の際の注意事項 2.Order for motorized valve, solenoid valve and pressure regulating valve 2.電動弁・電磁弁・圧力調整弁の発注 Refer to the following table for the name, main body, solenoid coil and ass'y of solenoid valves etc. applied to this model. この機種に使用されている電磁弁等の名称と本体・ コイル・組立品は下記のとおりです。 Common Parts 共通部品 Body/Coil PARTS NO. DWG NO. PARTS NAME 部品名称 LXE10E- 本体/コイル 符号 部品番号 図面番号 本体 Body B7-3 125649J Electronic expansion valve body ass'y 電子膨張弁本体組立品 2SA50010-2-KU 1.EV...
Page 66
Notes for ordering spare parts 部品発注の際の注意事項 3.Order for pressure trasducer 3.圧力センサーの発注 Refer to the following table for the pressure transducer applied to this model. For ordering pressure transducer, we recommend that you order the following best shrinkable tube together at the same time. この機種に使用している圧力センサーは下記の通りです。 圧力センサー発注の際は、下記の熱収縮チューブを同時に発注することをおすすめし ます。 PARTS NO. DWG NO. TYPE REMARKS 呼称名 PARTS NAME 部品名称 形式 備考 符号 部品番号 図面番号 B16 1587959 High pressure transducer 高圧圧力センサ 3P141602-1 NSK-BD030F-070 B15 1587942 Low pressure transducer 低圧圧力センサ...
Page 67
Notes for ordering spare parts 部品発注の際の注意事項 4.Order for temperature sensor 4.温度センサーの発注 Refer to the following table for temperature sensors applied to this model. この機種に使用されている温度センサーは下記の通りです。 Lot marks Type No. 表示 型番表示 Lot marks Type No. LOT 表示 型番表示 5Y01 ST9503-1- 1210 ST9701- Length Length ※Operating temp. range ー30〜+150℃ ※Operating temp. range ー30〜+70℃ 使用温度範囲 ー30〜+150℃ 使用温度範囲 ー30〜+70℃ Lot marks Type No. LOT 表示 型番表示 7828 ST9703-1 Length ※Operating temp. range ー30〜+15℃...
Page 68
Measuring and adjusting tools 測定調整用工具 1.Tools for emergency operation 1.緊急運転用工具 PARTS NO. DWG NO. ILLUSTLATION PARTS NAME 部品名称 用途 姿図 符号 部品番号 図面番号 For electronic Emergency coil エマージェンシー expansion 1080263 3P017370-1 valve コイルキャップ 電子膨張弁用 Suction modulating E m e r g e n c y エマージェンシー...
Page 69
Measuring and adjusting tools 測定調整用工具 2.Personal computer cable (for DCCS) 2.パソコンケーブル(DCCS用) The following parts are connector cables required to exchange information between the refrigeration unit and personal computer. The table below describes parts required to apply to Model LXE-C, -D, and -E new model. 下記の部品は冷凍ユニットとパソコンの情報交換に必要なコネクター、ケーブル類で す。LXE-C型、 D型、及び新機種E型対応に必要な部品を掲載しています。 [TYPE A]タイプA LXE10C LXE10C LXE10CA LXE10CA 1.5m LXE10D for MOL MOL用LXE10D (Receptacle) (レセプタクル) RS232C (Female) RS232C(メス) on the controller コントローラー側 [TYPE B]タイプB 0.3m 1.5m LXE10D LXE10D...
Page 70
Measuring and adjusting tools 測定調整用工具 Illustlation Internal Wiring 符号 姿図 内部配線 RS232C RS232C Female Female メス メス Frame Frame フレーム フレーム Daikin RS232C made Female ダイキン製 メス White Black Daikin RS232C made Female ダイキン製 メス Red 赤 White 白 Black 黒 Frame フレーム ...
Need help?
Do you have a question about the LXE10E-A33 and is the answer not in the manual?
Questions and answers