1. Manuals
  2. Brands
  3. Trotec Manuals
  4. Dehumidifier
  5. TTK 500
  6. Instructions manual

Trotec TTK 500 Instructions Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
TTK 500
EN
ORIGINAL INSTRUCTIONS
DEHUMIDIFIER

Advertisement

Table of Contents
loading

Related Manuals for Trotec TTK 500

Summary of Contents for Trotec TTK 500

  • Page 1 TTK 500 ORIGINAL INSTRUCTIONS DEHUMIDIFIER...

  • Page 2: Table Of Contents

    Follow the manual Information marked with this symbol indicates that the • Do not use the device with wet or damp hands. instructions must be observed. • Do not expose the device to directly squirting water. dehumidifier TTK 500...
  • Page 3 • Discharge the collected condensate before transport and repaired by specialist companies for cooling and storage. Do not drink it. Health hazard! air-conditioning or by Trotec. • Only use original spare parts, for otherwise safe and functional operation cannot be ensured.
  • Page 4 No smoking. must only be carried out by specialist companies for cooling and P381 – Eliminate all ignition sources if safe to do so. air-conditioning or by Trotec. P403 – Store in a well-ventilated place. Warning of electrical voltage...

  • Page 5: Information About The Device

    Because of the heat radiation generated during operation, the the mains plug while pulling the power cable out of the room temperature may rise slightly. mains socket. 3. Do not reconnect a defective device to the mains. dehumidifier TTK 500...

  • Page 6: Transport And Storage

    Wheels On/off switch Air filter Mains power cable Power cable holder Operating hours counter (optionally energy meter and operating hours counter) Air outlet Foot with rubber buffers Condensation hose connection Air inlet with slot for air filter dehumidifier TTK 500...

  • Page 7: Assembly And Start-Up

    • When positioning the device, keep a sufficient distance to heat sources. • Make sure that no curtains or other objects interfere with the air flow. • When positioning the device, secure the device locally with an RCD (Residual Current Device) which complies with the appropriate regulations. dehumidifier TTK 500...
  • Page 8 • Make sure that the air filter is installed before switching the device on. 3. Turn the transport handle by 90°. 4. Insert the screw (13) in the rivet (15). 5. Tighten the screws (13, 14). dehumidifier TTK 500...
  • Page 9 ð Position the end of the condensation drain hose above a water drain. For larger distances, a longer hose of the same type can also be used. ð The device can also be operated with a condensate pump. Contact your Trotec customer service. dehumidifier TTK 500...
  • Page 10 Installing the condensate pump (optional) dehumidifier TTK 500...

  • Page 11: Operation

    Do not create tripping hazards. 2. Make sure that the condensation drain hose is neither kinked nor jammed and that there are no objects on the condensation drain hose. 3. Make sure that the condensate can run off properly. dehumidifier TTK 500...

  • Page 12: Available Accessories

    (see chapter Available accessories). With a pump performance of up to 50 m and a maximum pump height of 4 m, the condensate can even be continuously discharged across storeys of a building. dehumidifier TTK 500...

  • Page 13: Errors And Faults

    • From the outside, check the condenser for dirt (see chapter Maintenance). If the condenser is dirty, have it cleaned by a specialist company or by Trotec. The device is loud or vibrates: • Check whether the device is set up in a stable and upright position.

  • Page 14: Maintenance

    10. Date: ........11. Date: ........12. Date: ........Signature: ........ Signature: ........ Signature: ........ Signature: ........ 13. Date: ........14. Date: ........15. Date: ........16. Date: ........Signature: ........ Signature: ........ Signature: ........ Signature: ........ dehumidifier TTK 500...
  • Page 15 • Hold onto the mains plug while pulling the power cable out device cleaned by a specialist company for cooling and of the mains socket. air-conditioning or by Trotec. 5. Put the air filter back in. Warning of electrical voltage...
  • Page 16 1. Loosen and remove the screws on both sides of the device. 3. Allow the filter to dry completely. Do not insert a wet filter into the device! 4. Reinsert the air filter into the device. 2. Loosen and remove the screws at the device front. dehumidifier TTK 500...
  • Page 17 7. Carefully set the housing aside. 8. Clean the interior of the device by means of compressed air. 9. Reassemble the housing on base frame and cooling system. Finally retighten all screws. dehumidifier TTK 500...

  • Page 18: Technical Annex

    470 x 438 x 870 mm Minimum distance to walls and other objects A: top: 50 cm 50 cm B: rear: 50 cm 50 cm C: side: 50 cm 50 cm D: front: 50 cm 50 cm Weight 52 kg 58 kg dehumidifier TTK 500...
  • Page 19 Wiring diagram With operating hours counter dehumidifier TTK 500...
  • Page 20 With operating hours counter and MID counter dehumidifier TTK 500...
  • Page 21 Top panel Latch Left panel Foam sheet Right panel Round insert Front panel Saddle spacer Rear panel Tubular handle screw Pump kit dummy cover Housing screw Tubular handle Finishing washer Folding handle Hole finisching cap Folding handle screw dehumidifier TTK 500...
  • Page 22 Tubular foot Pin spacer Saddle foot Compressor screw Round insert Compressor washer Saddle spacer Compressor nut Tubular foot screw Running capacitor Foot nut Capacitor washer Water pan Capacitor nut Water pan rubber plug Power supply cable Pressure switch dehumidifier TTK 500...
  • Page 23 Fan blade Ventilation duct Fan motor support Heat exchanger Side panel spacer Heat exchanger insulation EPS Grommet Defrost temperature sensor Copper tube bracket Defrost valve Screw M5×30 Defrost valve coil Condensates pump connector Fan motor Air outlet nozzle dehumidifier TTK 500...
  • Page 24 ITEM NO. SPARE PART QTY. ITEM NO. SPARE PART QTY. Control's box Control box internal wiring Control's cover Unit internal wiring Sealed electronic controller Remote humidistat socket On/Off switch Time counter Energy & time counter (optional) dehumidifier TTK 500...

  • Page 25: Disposal

    Declaration of conformity in accordance with the EC Machinery • IEC 61000-3-3:2013/A2:2021 Directive 2006/42/EC, Annex II, Part 1, Section A Manufacturer and name of the authorised representative of We – Trotec GmbH – declare in sole responsibility that the the technical documentation: product designated below was developed, constructed and Trotec GmbH produced in compliance with the requirements of the Grebbener Straße 7, D-52525 Heinsberg...
  • Page 26 Trotec GmbH Grebbener Str. 7 D-52525 Heinsberg +49 2452 962-400 +49 2452 962-200 info@trotec.com www.trotec.com...

Table of Contents