Page 1
Model Year 2004 Where Tradition and Innovation Meet... Type C Motorhome Owner’s Manual...
Page 2
Nothing in this manual creates any warranty, either expressed or implied. The only warranty offered by Jayco, Inc. is as set forth in the limited warranty applicable to this vehicle.
Page 3
YOUR NEW JAYCO IS YOUR PASSPORT TO A WHOLE WORLD OF NEW FRIENDS, CAMPING FUN AND TRAVEL ADVENTURE WHEN YOU JOIN THE THOUSANDS OF JAYCO FAMILIES WHO MAKE UP THE . . . JAYCO JAFARI INTERNATIONAL TRAVEL CLUB You will find us enjoying the friendship and fellowship of JAFARI CAMPING as we join our local area FLIGHTS at hundreds of weekend camp-outs all over North America each month .
Page 4
TO: Membership Coordinator for the Jayco Jafari International Travel Club Please enroll us as members in the Jayco Travel Club. We are ready to roll to where the “friends we just haven’t met yet” have the coffee on the fire and are waiting for us to arrive: We are ...
Thank you for purchasing your Jayco Recreation Vehicle and welcome to the world of recreation vehicle travel. Your purchase of a Jayco RV allows you to enter this unique world of camping and leisure in a grand style. Your Jayco RV has been designed and engineered to offer you many comforts of home that will make your camping experience as enjoyable as possible.
If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer or Jayco, Inc. NHTSA Customer Relations Dept.
WARNING: For traveling safety, it is extremely important to read and understand the towing, hitching and loading cargo information provided in Chapter 3. If you do not understand the information provided, please consult your dealer or Jayco owner representative. • Sanitize the fresh water supply system periodically (see sanitizing instructions).
• Check and tighten wheel lugs regularly, according to your chassis owner’s manual recommendations. • Check brakes in a safe area - not while traveling a busy highway. • Before leaving a camp area, ensure that the 120-volt electrical cord is properly stored. •...
Jayco. In most cases, the dealer can provide the service you require. If you are traveling and are unable to locate an Independent Jayco dealer, or an authorized dealer for the component needing service, please call our customer service office at 1-877-825-4782 or 1-574-825-0608 or contact your selling dealer for assistance.
Some RV dealers may be authorized service centers for certain manufacturers of products warranted separately. Check with your dealer before contacting others to reduce delays. If your Jayco dealer is not an authorized service center for the product in question, he can assist you in obtaining authorized service.
Located on the post of the driver's door is a "Federal Certification" label supplying a portion of this information. Fig. 3-1 MANUFACTURED BY: JAYCO, INC. DATE FABRIQUÉ PAR: INC. VEHICLE MFG. BY: VÉHICULE FABRIQUÉ PAR: V.I.N./N.I.V.
Page 18
MOTORHOME WEIGHT INFORMATION SERIAL # MODEL (GROSS VEHICLE WEIGHT RATING) MEANS THE MAXIMUM GVWR PERMISSIBLE WEIGH OF THIS FULLY LOADED MOTORHOME. (UNLOADED VEHICLE WEIGHT) MEANS THE WEIGHT OF THIS MOTORHOME AS MANUFACTURED AT THE FACTORY WITH FUEL ENGINE OIL, AND COOLANTS. (SLEEPING CAPACITY WEIGHT RATING) MEANS THE DESIGNATED SCWR NUMBER OF SLEEPING POSITIONS MULTIPLIED BY 154 LBS (70 KG).
Page 19
This not only wastes gas, but depending upon the location of the tank, can affect handling characteristics. Weight labels are posted inside a cabinet door inside all Jayco RV's so you can make a decision before you buy about how much cargo capacity is important for you personally.
HITCH - SEE CHAPTER 7 "OPTIONS" WARNING YOUR MOTORHOME CHASSIS IS RATED FOR TOWING OPERATION AT GVWR NOT GCWR. CONSULT YOUR CHASSIS OWNER’S MANUAL(S) FOR SPECIFIC WEIGHING INSTRUCTIONS AND TOWING GUIDELINES. THE BRAKING CAPACITY OF YOUR MOTORHOME IS NOT NECESSARILY AS GREAT AS THE TOWING CAPACITY. SEPARATE BRAKING SYSTEMS SHOULD BE USED FOR CONTROL OF A TOWED VEHICLE, (AUTO, TRAILER, BOAT, ETC.), BEHIND THE MOTORHOME.
WARNING: The rear bumper on the frame of the motorhome is NOT designed to carry over 100 lb. of weight. Installation of items exceeding 100 lb. may cause metal fatigue and weld stress. If such failures occur, it could damage your property and endanger vehicles following your motorhome during travel, possibly causing an accident.
2. SEGMENTED PLATFORM - Platform scales with segmented sections can provide individual axle weights and total vehicle weights simultaneously, when the vehicle is positioned properly. Position the vehicle on the scales so that each axle is centered as much as possible on separate segments, and record the weight.
WHEEL LUGS Ensure that wheel lugs are tight as specified in the chassis manual. FIRE EXTINGUISHER A fire extinguisher (Fig. 3-4) is installed in each vehicle and is located near the entrance door in the motorhome. Be familiar with its location and operating instructions as printed on the extinguisher.
TV ANTENNA Raising Antenna to Operating Position Turn the elevating crank clockwise in the UP direction about thirteen turns or until some resistance to turning is noted. (Fig. 3-5) On Amplified models, 12-Volt DC power is required. Turn the power supply ON to use either the front or rear TV outlet.
SEAT BELTS Three-point shoulder harnesses and lap belts are provided at the front driver and passenger seats by the chassis manufacturer. See the chassis manual for operating instructions. For the recreation vehicle section, the dinette, sofa, and barrel chairs have a two-point lap seat belts installed.
Procedures to Take During an Alarm WARNING: The activation of the CO detector is a warning that indicates the presence of carbon monoxide! WARNING: Do not disconnect the CO detector to silence the alarm. The detector is designed to sense when the level of CO in the air falls below the danger level. All individuals must remain outside the unit until the alarm is silent.
SETUP FOR CAMPING Leveling your RV is important for several reasons: 1. The refrigerator is designed to operate when level for best performance due to the absorption system. 2. The water drainage systems are designed with proper slope and must be level for proper operation.
TL Enterprises (Trailer Life, Motorhome, etc.) can offer you additional, practical advice on the proper storage of your vehicle. Damage from rodents or insects are NOT covered under your Jayco Limited Warranty. Escapade Type C Owner’s Manual...
Chapter 4 THE SYSTEMS PLUMBING SYSTEM Included in your Jayco recreation vehicle is a complete fresh water system. Each component is explained along with its operation.` City Water Connection Water may be received into the system through a direct hookup referred to as the city water connection (Fig.
Tanks A water tank is permanently installed inside your motorhome located either under a bed, dinette or sofa depending on the floor plan. CAUTION: Do not leave the tank unattended while filling. You must be careful not to over fill tank. This can pressurize the tank, causing leakage and water damage. TO FILL THE WATER TANK: 1.
Outside Shower (Option) A convenient faucet assembly with hot and cold water is available for exterior use washing or rinsing on the outside of camper. (Fig. 4-6) OPERATION 1. Turn on the pump. 2. Open the door with the key and allow it to hinge down; or on units with the utility center, open the door to the utility center.
Page 32
11. After the water heater and water lines fill, 1 & 2 - Low Point Drain Valves the air will stop bubbling out of the 3 - Tank Drain Valve faucets. Please note, the water heater will 4 - Tank Fill Valve hold approximately six gallons (22.7 5 - Tank Outlet Valve liters) of water.
Bath and Shower Your bathroom facilities function similar to those in your home. Prepare your bath or shower curtains to prevent water from spilling onto the floor. Be sure the water heater is in operation before bathing. Adjust the faucets for desired temperature before entering the tub or shower. The shower heads are equipped with a vacuum breaker to prevent pressure buildup.
SANITATION SYSTEM Toilets The Aqua Magic® 4 model of toilet is used in your motorhome. This model features two levers on the back side to flush the toilet. Operating Instructions - Aqua Magic® 4 The Aqua Magic® 4 is equipped with two operating levers located on the right side of the toilet when facing the unit.
Holding Tanks The final part of your system are the holding tanks. They hold waste and are located below the floor of your. Bath tub and sinks drain into the waste water tank, also referred to as the "gray" water holding tank.
GRAY WATER HOLDING TANK No special preparation is required. However, placing a small quantity of chemicals into this tank, such as baking soda or a Thetford chemical, will reduce odors from food particles in the system. WARNING: We recommend that you DO NOT travel with full gray or black holding tanks.
Preparing your recreation vehicle for winter is very important for most states and Canada. Failure to prepare the will cause supply lines and water heater to freeze causing breakage. Repairs due to freezing are not to be covered under the terms of your Jayco Limited Warranty. WARNING: Do not use Ethylene Glycol (automotive antifreeze) or Methanol (windshield washer antifreeze) in your fresh water system.
THE LP FUEL SYSTEM It is because of the LP gas system that your RV has the convenience of a refrigerator, stove, water-heater, and furnace. This system has containers that contain the fuel and also regulators to control the pressure of the fuel and supplies the gas vapor to the various appliances. When correctly used, the LP system is very effective and will ensure the comfort and added convenience for your vehicle.
Page 39
CAUTION: DO NOT use tools or heavy equipment to open or close valves on the containers. HAND TIGHTEN only. There are four components attached to the container for filling and dispensing the fuel (Fig. 4-27): 1. Gas Fill Valve (A): attach the fill hose before opening valve. Unless you are filling the container, keep the cap on at all times.
WARNING: Do not fill LP Gas tank(s) to more than 80 percent of capacity. Overfilling the LP gas container can result in uncontrolled gas flow which may cause a fire or an explosion. A properly filled container will contain approximately 80 percent of its volume as liquid LP gas.
Page 41
WARNING: LP gas regulators must always be installed with the diaphragm vent facing downward. Regulators that are not in a compartment have been equipped with a protective cover. Ensure that the regulator vent faces downward and that the cover is in place. This will minimize vent blockage that could result in excessive gas pressure causing a fire or an explosion.
Checking for Leaks Upon delivery and periodically thereafter, check your gas system for possible leaks. Although the entire distribution system and its attached appliances have undergone factory testing for leaks, the camper is subject to road vibrations, which can cause connections and fittings to develop leaks. If you do encounter this odor, turn off all open flames immediately and begin a systematic search for leaks throughout the gas system.
LP Gas Consumption Most gas appliances are operated intermittently. Unless there is heavy use of hot water, water heater consumption of LP gas is minimal. During freezing weather and high wind conditions, furnace consumption can be extremely high. LP gas consumption depends upon individual use of appliances and the length of time operated. Each gallon of LP gas produces about 91,500 (96,530) of heat energy.
ALARM The red LED will flash and the alarm will sound when dangerous levels of gas are detected. The detector will continue to alarm until the gas clears or the "MUTE" switch is pressed. (See Procedures To Take During An Alarm). PROCEDURES TO TAKE DURING AN ALARM 1.
ELECTRICAL SYSTEM General The electrical system in the recreation vehicle is composed of 120-volt AC (alternating current) and 12-volt DC (direct current) capabilities. All installations are made in compliance with safety requirements of ANSI standard A.1192 National Electric Code, Canadian Standards Association, NFFA-70.
AC DISTRIBUTION CENTER When 120-volt AC is connected to the power center through commercial power or the generator, the 120-volt AC circuits are protected by the breakers contained in the AC panel board. 120-volt AC circuits may be turned off by flipping the breaker to indicate “OFF” or turned on by flipping the breaker to indicate “ON”.
6. If the GFCI did not trip, do not use. Call a qualified electrician to service or replace the receptacle. The ground fault protection is no longer working and the GFCI may not be working properly. 7. To restore power after tripping, press in the RESET button. It must remain in. (If an indicator light is furnished, it will be off.) 12-Volt DC (Direct Current) System NOTE: The motorhome master battery switch MUST be on before any 12 volt device will...
120-Volt AC/12-Volt DC Layout The diagram below defines the layout for the complete electrical system Fig. 4-31 120-volt AC layout A - Main D - Kitchen, Bath, Outside, GFCI B - Air Conditioner E - Converter/Utility C - Microwave F - Electric Water Heater 12-volt DC Layout 1 - Bath 7 - Optional...
Batteries, Chassis and Auxiliary Each motorhome chassis is built with a battery to provide energy to start the engine and supply energy for other components in the chassis. This battery is located under the hood. Ford Motor Co. uses a "Motorcraft" battery, serviced and warranted by Ford. An auxiliary battery is included in each motorhome for storage power when 120-volt energy is not available.
STORAGE Preparation of battery(ies) for winter storage must be carefully considered, especially the auxiliary battery. Components attached to either battery will discharge the battery in one to three months. Discharged batteries are subject to freezing, breaking and permanent damage. If you are storing your motorhome for an extended period, it is important to charge the battery(ies) every thirty days to maintain a charged condition at 1.265 specific gravity.
Fuse Chart All exterior light fuses are located in the chassis fuse block, located under the dash near the emergency brake pedal. The fuse chart below is for interior items built into the house portion of the vehicle by the recreation vehicle manufacturer. Some items are optional as listed. CAUTION: DO NOT install any replacement fuse with a higher rating than specified below.
All appliances in your Jayco recreation vehicle are name brand quality built equipment, guided by current code and standards. For gas operation, the appliances in your motorhome will operate on LP gas only, not on natural gas.
FURNACE The furnace requires both 12-volt DC and LP gas energy for full operation. The combustion system is fully sealed. Oxygen is drawn from outside through the center port of the vent by the fan motor. After burning fuel, the carbon monoxide exhaust is expelled into open air through the outer port of the vent.
NOTE: If furnace should lock out, the blower will go in 5 minutes and remain off until unit is reset by reactivating thermostat. To Turn Off Gas to Appliance 1. Set the thermostat to the lowest setting, then move the “ON/OFF” lever located on the bottom of the thermostat to “OFF”...
Top Burner Operation WARNING: • Use range or cooktop only for use as described in the manufacturer’s manual. • Do not leave children alone or unattended in area where range or cooktop is in use. Never allow anyone to sit, stand, or on any part of the range cooktop.
Page 56
WARNING: • Burner flame should not extend beyond the edge of the cooking utensil. The flame could be burned or a fire could start if a burner is accidentally left ON. • Be sure all control knobs are turned to OFF when you are not cooking. Someone could be burned or a fire could start if a burner is accidentally left ON.
SETTING RECOMMENDED USE • To light the burner LITE • To start foods cooking • To bring liquids to a boil • To hold liquids at a boil • To fry chicken or pancakes • To cook large amounts of vegetables •...
Page 58
NOTE: The LP gas shut off valve must be int he open or on position. LIGHTING THE OVEN PILOT: a. Push in oven control knob (Figure 5-1A) and rotate counter-clockwise to PILOT ON. b. Light oven pilot (Figure 5-1C) located near the back of the oven, under the broiler shelf (Figure 5-1B) and to the left of the oven burner (Figure 5-1D).
WATER HEATER Safety Information WARNINGS: Hydrogen gas may result if you have not used this heater for two weeks or more. HYDROGEN GAS IS EXTREMELY FLAMMABLE. To reduce the risk of injury under these conditions, open the hot water faucet for several minutes at the kitchen sink before you use any electrical appliance connected to the hot water system.
Never operate the heater if you smell gas. Do not assume that the smell of gas in your RV is normal. Any time you detect the odor of gas, it is to be considered life threatening and corrected immediately. Extinguish any open flames including cigarettes and evacuate all persons from the vehicle.
1. STOP! Read the safety information provided. 2. Turn off all electric power to the appliance. 3. Turn “OFF” gas supply. 4. Wait five minutes for gas to clear the area. If you smell gas then STOP! Follow instructions at the beginning of this chapter and/or in the manufacturer’s owner’s manual. If you do not smell gas, go to next step.
Page 62
ANODE PROTECTION The tank in this water heater is protected by a magnesium or aluminum anode (Fig. 5-2) to prolong the life of the tank. Under normal use, the anode rod will deteriorate and because of this, we recommend it be replaced yearly. NOTE: Water with high levels of iron and/or sulfate will increase the rate of deterioration;...
Page 63
Suburban recommends that a check valve not be installed directly at the inlet to the water heater tank. This will increase weeping of the pressure relief valve. WARNING: Do not remove or plug the relief valve. One way to reduce the frequency of this occurrence is to maintain an air pocket at the top of the water heater tank.
REFRIGERATOR WARNING: • The storage of flammable materials behind or around the refrigerator creates a fire hazard. Do not use the area behind the refrigerator to store flammable materials (gasoline, cleaning supplies, etc.) • Do not remove the round ground prong from any of the AC power cords. Do not use a two prong adapter or an extension cord with any of the AC power cords.
About Your Refrigerator: LEVELING CAUTION: The refrigerator is made to operate within 3” off level side-to-side and 6” off level front-to-back (as looking at the front of the refrigerator). Operating it at more than these limits can cause damage to the cooling system and create a risk of personal injury or property damage.
Page 66
ADJUSTABLE SHELVES The shelves in the freezer and the fresh food compartment are made so you can remove them or move them. • To remove or move the shelf of the freezer: • Pull the shelf forward out of the slot. •...
Page 67
BACKUP OPERATING SYSTEM This refrigerator has a backup operating system. The backup operating system allows the refrigerator to continue to cool if the temperature sensor of the refrigerator should fail. If this failure occurs: • The refrigerator automatically changes to the backup operating system. •...
Model N611 CONTROL PANEL The refrigerator control panel is between the freezer compartment and the fresh food compartment. To maintain the operating control functions of the refrigerator, a 12-volt DC power supply is necessary. The refrigerator and any other DC components in the vehicle receive DC power from the 12-volt system of the vehicle;...
If the energy source is interrupted: • The refrigerator stops operation. • A fault code flashes in the center display. • Refer to the “Fault Codes” section of manufacturer’s owner’s manual. Ignition of propane gas in either auto or gas mode: NOTE: On initial start up of the refrigerator, ignition of the propane gas may not occur within 30 seconds.
Page 70
The TEMP SET button (Fig. 5-6B) controls the temperature adjustment of the freezer ant the fresh food compartment. The temperature adjustment that you select does not change if the mode of operation of the refrigerator changes: • Push the TEMP SET button and the temperature setting “1-9” appears in the center display(Fig.
OPERATION OF PROPANE GAS IN EITHER AUTO OR MANUAL MODE NOTE: On initial start up of the refrigerator, ignition of the propane gas may not occur within 30 seconds. If ignition of the propane gas does not occur within 30 seconds: •...
AIR CONDITIONER Operation FOR COOLING 1. Turn the selector switch to the “LOW COOL” or “HIGH COOL” position. 2. Rotate the thermostat (temperature control) to the position that is the most comfortable to you. The thermostat will turn the compressor on when the temperature of the air entering the air conditioner rises a few degrees above the setting you have selected.
Chapter 6 CARE AND MAINTENANCE EXTERIOR CAUTION: We recommend that you do not take your recreation vehicle through automatic car washes and extreme caution must be used if utilizing any type of pressure sprayer around all attachments, doors, windows, appliance vents, etc. to avoid forcing water inside the vehicle, possibly damaging components.
Doors, Extrusions, Windows & Vents These components have putty tape between the component and the wall surface. Portions of these items may have a cap seal added as a secondary seal. Inspect these seals at least once a year. Both putty tape and cap seals can become damaged by U.V.
Chassis Instructions for drive train and automotive chassis are included in the manual supplied by the chassis manufacturer. A frame extension has been added to your motorhome chassis. You may wish to have an undercoating material applied to the frame extension to protect your investment from the effects of road grime, salts, and other corrosive materials.
INSPECTION POINTS FOR SEALING The following diagram indicates the locations that need to be inspected semi-annually and resealed at least one time each year. 1. Moldings 4. Windows 2. TV Antenna 5. Exterior Attachments 3. Vents 6. Clearance & Tail Lights Escapade Type C Owner’s Manual...
INTERIOR CARE Furnace Preventive maintenance and safety checks should be performed by a qualified technician once a year, or more, depending on the use of the furnace. Failure to properly maintain the furnace may void the furnace warranty and can result in unsafe furnace operation. Preventive maintenance is NOT covered under the warranty.
Page 78
WARNING: Do not install screens over the vent for any reason. Screens will become restricted and cause unsafe furnace operation. Accessories are being marketed for RV products which the manufacturer does not recommend. For your safety, only factor authorized parts are to be used on your furnace. 2.
14. Do not install air boosters in the ducting system. Such devices will cause the furnace to cycle on limit and to have erratic sail switch operation. 15. Clothing or other flammable material should not be placed on or near the appliance. 16.
Page 80
fins. The water from the cooling fins drains into a collection cup that is attached to the back of the refrigerator. The heat of the cooling system evaporates the water from the collection cup. It is normal for frost to collect inside the freezer. Excess frost decreases the cooling performance of the refrigerator.
Page 81
Have a qualified RV dealer or a authorized service center do these annual safety and maintenance checks: • Examine the gas supply lines for leaks. Replace or repair if needed. • Make sure the propane gas pressure is correct. Adjust if needed. •...
REFRIGERATOR FUSE REPLACEMENT The electrical circuits of this refrigerator have fuses to protect them from an overload. If a fuse is unserviceable, replace it as follows. WARNING: Do not operate the refrigerator without the power board cover on the refrigerator. To prevent a circuit overload and a possible electrical fire, use only these fuses: DC control circuit 5 amp tan blade type automotive fuse...
Page 83
CAUTION: • Clean all surfaces as soon as possible after boil overs or spillovers. • Use warm soapy water only to clean the burner grates, cooktops, painted surfaces, porcelain surfaces, stainless steel surfaces and plastic items on your range or cooktop.
Clean all surfaces quickly after boil overs or spillovers. Use a dry towel or cloth to soak up spills. ALL SURFACES - When surface is cool, clean with warm soapy water, rinse and dry with soft cloth. Additional cleaning measures: •...
Maintenance of Water Heater WARNING: If the user of the appliance fails to maintain it in the condition in which it was shipped from the factory or if the appliance is not used solely for its intended purpose or if appliance is not maintained in accordance with the instructions in the manual, then the risk of a fire and/or the production of carbon monoxide exists which can cause personal injury, property damage or loss of life.
Winterizing Water Heater If your water heater plumbing system is equipped with a bypass kit, use it to close off the water heater, drain the water heater completely and leave the water heater closed off (out of the system) in the bypass position particularly if you are introducing antifreeze into the plumbing system. Antifreeze can be very corrosive to the anode rod creating premature failure and heavy sediment in the tank.
Carbon Monoxide Detector TESTING WARNING: DO NOT attempt to test the detector by any other means than using the "test" button. DO NOT attempt to produce carbon monoxide to test the detector. The CO detector should be tested weekly for proper operation: 1.
Smoke Alarm 1. Test weekly by pushing “test” button. The alarm will sound also test by blowing smoke into alarm. The alarm will stop after the smoke has cleared out of the alarm (approximately one minute). 2. Model 4662 has a silence feature. This is incorporated in the test button. When this feature is present, this button is colored yellow.
Paneling The wall paneling in your new Jayco is a vinyl covered panel. If deep scratches occur, putty sticks can be used to cover scratches on wood surfaces. These can be obtained from hardware stores and lumber yards.
Use a mild detergent soap and water, Bon Ami or Bar Keeper's Friend to clean the tub surface. For any type of repair work, see your authorized Jayco dealer. Hardware and Sink or Shower Fixtures Use mild dish soap and water to clean these fixtures. Never use harsh chemicals or sprays. A mild solution of vinegar and water works well to remove hard water spots and stains from the sink or shower fixtures.
Below is a list of suggested maintenance items to follow at specific intervals for optimum performance and operation of your Jayco RV. This list is meant to be a supplement to the maintenance items of the chassis manufacturer's owner's manual. Please add these items to your maintenance routine.
Page 92
EVERY THREE MONTHS OR 3,000 MILES 0 Vacuum around LP Burner and pilot light areas. 0 Compare water heater pilot flame with ideal flame. Refer to the water heater owner's manual for ideal flame. Clean and adjust as necessary. 0 Compare refrigerator pilot flame with ideal flame. Refer to the refrigerator owner's manual for ideal flame.
Chapter 7 OPTIONS NOTE: Information in this chapter may not necessarily apply to your unit. For some models, optional equipment may have been added as your vehicle was being built. There may be some information here that is standard equipment for the model of motorhome that you own.
MOVING PARTS CAN CAUSE SEVERE PERSONAL INJURY OR DEATH • Before starting work on the generator set, disconnect negative (-) cable at the battery. This will prevent accidental arcing or starting. • Keep your hands away from moving parts. • Make sure that fasteners on the generator set are secure. Tighten supports and clamps, keep guards in position over fans, etc.
gasoline or gasoline additives (deicers) containing methanol because methanol can be corrosive to fuel system components. CAUTION: Do not use gasoline or gasoline additives containing methanol because methanol can be corrosive to fuel system components. Avoid using highly leaded gasolines and lead additives because of the extra engine maintenance that will be required.
Starting and Stopping WARNING: EXHAUST GAS IS DEADLY! Exhaust gases contain carbon monoxide, an odorless and colorless gas. Carbon monoxide is poisonous and can cause unconsciousness and death. Symptoms of carbon monoxide poisoning include: Dizziness Throbbing in Temples Nausea Muscular Twitching Headache Vomiting Weakness and Sleepiness...
CAUTION: Proper engine cooling requires that the access cover be secured during operation. Also, hot engine parts can cause severe burns. Always secure the access cover as soon as the engine starts up. 1. For top performance and engine life, especially in colder weather, let the engine warm up for at least two minutes before connecting the genset to the vehicle electrical loads (appliances).
Page 98
WARNING: Electrical shock can cause severe personal injury or death. Read and follow the equipment and tool manufacturer’s instructions and warnings. TYPICAL APPLIANCE POWER CONSUMPTION Power Consumption Appliance (watts) Air Conditioner 1400-2000 Battery Charger Up to 800 DC Converter 300-500 Refrigerator 600-1000 Microwave Oven...
Restarting a Stalled “Genset” If the genset stalls, disconnect or turn off as many appliances as possible and try restarting the genset as instructed under Starting and Stopping. Reconnect the loads (appliances) one by one up to a total load that does not overload the genset or cause the circuit breaker to trip. Resetting Circuit Breakers If a circuit breaker in the main power distribution panel of the vehicle or on the genset (Fig.
DUSTY CONDITIONS Pay particular attention to the following items when operating the genset in dusty conditions: 1. Do not let dirt and debris accumulate inside the genset compartment. Keep the genset clean. 2. Perform air cleaner maintenance more often than usual. See manufacturer’s owner’s manual. 3.
ELECTRIC DOOR STEP The electric door step opens automatically when the screen door is opened. The power is supplied by 12-volt DC arriving through a 30-amp breaker located in the engine bay. A yellow wire supplies power to the electric step. CAUTION: When opening the door from the outside, ensure that you are not in the path of the step.
HEATED HOLDING TANKS With the heated tank option, a pad will be glued to the exterior bottom side of the holding tank. Heat is supplied by 12-volt DC power through the heating element built into the pad. Approximately 6-amps of energy per pad is consumed and fused through the 12-volt power supply board.
TIRE CHANGING Your recreation vehicle may be equipped with Versa-Liner Wheel Liners. The following instructions will give you direction for removing and reinstalling the wheel liners when necessary. VERSA-LINER® WHEEL LINERS NOTE: DO NOT loosen or remove lug nuts. Set the vehicle parking brake prior to wheel product installation.
SPARE TIRE CARRIER The following procedures should be used for securing the spare tire in the travel position: 1. Put the steel hoist lift support located on the end of the cable through the rim of the tire. Clips need to seat inside of the hole. •...
The warranty on your unit is transferrable one time only, form the original owner to a subsequent owner. This form as shown here and one the next page must be completed by the dealership. The form should be sent with the $100.00 to Jayco, Attention: After Market Services. Warranties...
Page 112
Jayco. We are pleased you chose Jayco and want to do everything possible to make sure you stay as happy with your Jayco RV home as you were on the day you bought it.