Dell Latitude D410 Service Manual
  1. Manuals
  2. Brands
  3. Dell Manuals
  4. Laptop
  5. Latitude D410
  6. Service manual

Dell Latitude D410 Service Manual

Hide thumbs Also See for Latitude D410:
Table of Contents

Advertisement

Quick Links

Download this manual
Dell™ Latitude™ D410 Service Manual
Before You Begin
System Components
Internal Card With Bluetooth® Wireless Technology
Hard Drive
Memory Module and Modem
Coin-Cell Battery
Center Control Cover
Keyboard
Notes, Notices, and Cautions
NOTE:
A NOTE indicates important information that helps you make better use of your computer.
NOTICE:
CAUTION:
Information in this document is subject to change without notice.
© 2005 Dell Inc. All rights reserved.
Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly forbidden.
Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Inc.; Intel is a registered trademark of Intel Corporation; Bluetooth is a trademark owned by
Bluetooth SIG, Inc. and is used by Dell Inc. under license.
Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any
proprietary interest in trademarks and trade names other than its own.
January 2005 Rev. A00
Great user manuals database on
A NOTICE indicates either potential damage to hardware or loss of data and tells you how to avoid the problem.
A CAUTION indicates a potential for property damage, personal injury, or death.
UserManuals.info
Mini PCI Card
Display Assembly
Palm Rest
Fan
Smart Card Reader
System Board
Pin Assignments for I/O Connectors
Flashing the BIOS

Advertisement

Table of Contents
loading

Related Manuals for Dell Latitude D410

Summary of Contents for Dell Latitude D410

  • Page 1 Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly forbidden. Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Inc.; Intel is a registered trademark of Intel Corporation; Bluetooth is a trademark owned by Bluetooth SIG, Inc. and is used by Dell Inc. under license.

  • Page 2: Before You Begin

    CAUTION: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. Read and follow applicable instructions in the safety instructions in the Product Information Guide that came with the computer.

  • Page 3: Recommended Tools

     Recommended Tools The procedures in this manual require the following tools:  #1 Phillips screwdriver  ¼-inch flat-blade screwdriver  Small plastic scribe  Flash BIOS update program CD or USB memory key with the flash BIOS update program.  Computer Orientation front left back right  Screw Identification When you are removing and replacing components, print...
  • Page 4 Display Assembly (top — hinges): Palm Rest (top): Fan: (2 each — M2 x 6 mm) (5 each — M2.5 x 5 mm) (3 each) (1 each — M2 x 3 mm) Display Assembly (bottom — computer base): Computer Base: System Board: (2 each —...
  • Page 5 Back to Contents Page Flashing the BIOS   1. Ensure that the AC adapter is plugged in and that the main battery is installed properly. NOTE: If you use a BIOS update program CD to flash the BIOS, set up the computer to boot from a CD before inserting the CD.  ...

  • Page 6: Removing The Internal Card With Bluetooth® Wireless Technology

    Back to Contents Page   Internal Card With Bluetooth® Wireless Technology Dell™ Latitude™ D410 Service Manual   Removing the Internal Card With Bluetooth® Wireless Technology   Replacing the Internal Card With Bluetooth® Wireless Technology  Removing the Internal Card With Bluetooth® Wireless Technology CAUTION: Before performing the following procedures, read the safety instructions in your Product Information Guide.
  • Page 7 3. Replace the battery. Back to Contents Page   Great user manuals database on UserManuals.info...

  • Page 8: Removing The Coin-Cell Battery

    Back to Contents Page   Coin-Cell Battery Dell™ Latitude™ D410 Service Manual   Removing the Coin-Cell Battery   Replacing the Coin-Cell Battery  Removing the Coin-Cell Battery CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
  • Page 9   Replacing the Coin-Cell Battery   1. Affix the replacement battery with the double-sided tape on the system board.   2. Replace the coin-cell battery cover. Back to Contents Page   Great user manuals database on UserManuals.info...

  • Page 10: Removing The Center Control Cover

    Back to Contents Page   Center Control Cover Dell™ Latitude™ D410 Service Manual   Removing the Center Control Cover   Replacing the Center Control Cover  Removing the Center Control Cover CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.

  • Page 11: Removing The Display Assembly

    Back to Contents Page   Display Assembly Dell™ Latitude™ D410 Service Manual   Removing the Display Assembly   Replacing the Display Assembly  Removing the Display Assembly CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.

  • Page 12: Replacing The Display Assembly

      8. Pull up on the pull-tab to disconnect the display cable from the system board.   9. Remove the two M2 x 6-mm screws from the left and right hinges.   10. Lift the display away from the computer and lay it aside. 1 M2 x 6-mm screws (2) 2 display cable 3 system board connector...
  • Page 13   8. Turn the computer over and replace the two screws labeled "D" on the computer base. Back to Contents Page   Great user manuals database on UserManuals.info...

  • Page 14: Removing The Fan

    Back to Contents Page   Fan Dell™ Latitude™ D410 Service Manual   Removing the Fan   Replacing the Fan  Removing the Fan CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
  • Page 15 Great user manuals database on UserManuals.info...

  • Page 16: Removing The Hard Drive

    NOTICE: Hard drives are extremely fragile; even a slight bump can damage the drive. NOTE: Dell does not guarantee compatibility or provide support for hard drives from sources other than Dell.  Removing the Hard Drive   1. Follow the instructions in "Preparing to Work Inside the...
  • Page 17 Great user manuals database on UserManuals.info...

  • Page 18: Removing The Keyboard

    Back to Contents Page   Keyboard Dell™ Latitude™ D410 Service Manual   Removing the Keyboard   Replacing the Keyboard  Removing the Keyboard CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.

  • Page 19: Replacing The Keyboard

     Replacing the Keyboard   1. Reconnect the keyboard connector to the to the system board connector/tab.   2. Gently slide the bottom of the keyboard into the base of the computer. NOTE: You may need to push the bottom of the keyboard down slightly into the computer base to slide the keyboard into the base of the computer.  ...

  • Page 20: Removing The Mini Pci Card

    Back to Contents Page   Mini PCI Card Dell™ Latitude™ D410 Service Manual   Removing the Mini PCI Card   Replacing the Mini PCI Card  Removing the Mini PCI Card CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.

  • Page 21: Replacing The Mini Pci Card

    b.  Release the Mini PCI card by spreading the metal securing tabs until the card pops up slightly. c.  Remove the Mini PCI card from the connector at a 45-degree angle.  Replacing the Mini PCI Card NOTICE: To avoid damaging the antenna cables or the Mini PCI card, never place the cables under the card. NOTICE: The connectors are keyed to ensure correct insertion.
  • Page 22 3. Replace the metal shield: a.  Slide the metal shield into place. b.  Tighten the two captive screws that secure the metal shield.   4. Replace the keyboard.   5. Replace the center control cover. Back to Contents Page   Great user manuals database on UserManuals.info...

  • Page 23: Removing The Palm Rest

    Back to Contents Page   Palm Rest Dell™ Latitude™ D410 Service Manual   Removing the Palm Rest   Replacing the Palm Rest  Removing the Palm Rest CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
  • Page 24 1 M2.5 x 5-mm screws (5) 2 M2 x 3-mm screw NOTICE: Pull on the plastic tab on top of the connectors to avoid damaging the connectors.   8. Disconnect the speaker connector from the system board.   9. Disconnect the button board from the system board. a.

  • Page 25: Replacing The Palm Rest

     Replacing the Palm Rest   1. Align the palm rest with the computer base and gently snap into place.   2. Connect the touch pad connector to the system board.   3. Connect the speaker connector.   4. Connect the button board connector.  ...

  • Page 26: Pin Assignments For I/O Connectors

    Back to Contents Page   Pin Assignments for I/O Connectors Dell™ Latitude™ D410 Service Manual   USB Connector   Video Connector  USB Connector     Signal USB5V+ USBP– USBP+  Video Connector         Signal Signal CRT_R 9 CRT_G 10 CRT_B 11 MONITOR_DETECT– DDC_DATA CRT_HS...

  • Page 27: Removing The Smart Card Reader

    Back to Contents Page   Smart Card Reader Dell™ Latitude™ D410 Service Manual   Removing the Smart Card Reader   Replacing the Smart Card Reader  Removing the Smart Card Reader CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
  • Page 28   3. Replace the M2 x 3-mm screw. Back to Contents Page   Great user manuals database on UserManuals.info...

  • Page 29: Removing The System Board

    Back to Contents Page   System Board Dell™ Latitude™ D410 Service Manual   Removing the System Board   Replacing the System Board  Removing the System Board CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.

  • Page 30: Replacing The System Board

    1 connector on internal card with Bluetooth® wireless technology 2 smart card connector   11. Remove the remaining two screws that secure the system board to the computer base. 1 M2.5 x 5-mm screws (2)   12. Starting from left to right, slide up toward the left and pull out the system board assembly. 1 system board assembly 2 computer base  Replacing the System Board...
  • Page 31 1. Follow all of the steps in "Removing the System Board" in reverse order. NOTICE: Before turning on the computer, replace all screws and ensure that no stray screws remain inside the computer. Failure to do so may result in damage to the computer.

  • Page 32: System Components

      System Components Dell™ Latitude™ D410 Service Manual NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. NOTICE: Unless otherwise noted, each procedure in this document assumes that a part can be replaced by performing the removal procedure in reverse order.

  • Page 33: Notes, Notices, And Cautions

    Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly forbidden. Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Inc.; Intel is a registered trademark of Intel Corporation; Bluetooth is a trademark owned by Bluetooth SIG, Inc. and is used by Dell Inc. under license.

  • Page 34: Memory Module And Modem

    Only DDR2 memory dimms fit and can be used in this computer. NOTE: Memory modules purchased from Dell are covered under your computer warranty. Your computer has two user-accessible SODIMM sockets, one accessed from beneath the keyboard (DIMM A), and the other accessed from the bottom of the computer (DIMM B).
  • Page 35 a.  Align the notch in the module with the slot in the center of the connector. b.  Slide the module firmly into the slot at a 45-degree angle, and rotate the module down until it clicks into place. If you do not feel the click, remove the module and reinstall it.
  • Page 36 1 memory module 2 securing clips (2 per connector) 3 BIOS daughter card (may not be present in all computers)   Replacing the Memory Module in DIMM B   1. Ground yourself and install the new memory module: a.  Align the notch in the module with the slot in the center of the connector. b.
  • Page 37 Removing the Modem CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. CAUTION: To prevent static damage to components inside your computer, discharge static electricity from your body before you touch any of your computer's electronic components.
  • Page 38 Replacing the Modem   1. Connect the modem cable to the modem. NOTICE: The connectors are keyed to ensure correct insertion. If you feel resistance, check the connectors and realign the card.   2. Align the modem with the modem-screw hole and press the modem into the modem connector on the system board.  ...

Table of Contents