Related Manuals for MASSEY FERGUSON MF 6700 S Series
Summary of Contents for MASSEY FERGUSON MF 6700 S Series
- Page 1 Workshop Service Manual MF 6700 S series tractors Beauvais May 2016 AGCO S.A.S. - 41 avenue Blaise Pascal - 60000 Beauvais - France - RC B562 104 539 ACT0025630 © AGCO 2016 English...
- Page 2 Find manuals at https://best-manuals.com...
- Page 3 Table of contents MF 6700 S series tractors 1 Introduction ............. . 1-1 1.1 General...
- Page 4 3.1.4.1 Measuring the engine oil pressure ......3-17 MF 6700 S series tractors ACT0025630 Find manuals at https://best-manuals.com...
- Page 5 5.1.4.2 Reassembling the Dyna-VT unit ....... 5-43 MF 6700 S series tractors ACT0025630 Find manuals at https://best-manuals.com...
- Page 6 5.4.4.7 Reassembling the planet gears ......5-158 MF 6700 S series tractors ACT0025630 Find manuals at https://best-manuals.com...
- Page 7 5.7.4.2 Disassembling the input planet carrier ......5-235 5.7.4.3 Reassembling the input planet carrier ......5-236 MF 6700 S series tractors ACT0025630...
- Page 8 6.4.4.1 Removing the rear axle brakes ....... 6-79 MF 6700 S series tractors ACT0025630 Find manuals at https://best-manuals.com...
-
Page 9: Table Of Contents
6.9.3.4 Removing the differential assembly ......6-138 6.9.3.5 Disassembling the differential assembly and the crown wheel ..6-139 MF 6700 S series tractors ACT0025630... -
Page 10: Removing/Refitting The Assisted-Brake Master Cylinders
6.12.5 Adjustments, bleeding and calibrations ......6-210 MF 6700 S series tractors ACT0025630 Find manuals at https://best-manuals.com... -
Page 11: Layout Of Components
6.16.1 General ........... . . 6-282 MF 6700 S series tractors... - Page 12 7.4.4.4 Adjustment of the control (4-speed version) ..... . 7-53 ..... . . 7-55 7.5 GPA20/Output shaft without speed selection MF 6700 S series tractors ACT0025630...
- Page 13 8.1.1 General ............8-3 MF 6700 S series tractors...
- Page 14 8.5.5 Service tools ........... 8-69 MF 6700 S series tractors...
- Page 15 9.3.1 General ............9-61 MF 6700 S series tractors...
- Page 16 ..........9-127 9.8 GPA20/Open Center MF 6700 S series tractors ACT0025630...
- Page 17 9.14.4.4 Final steps ..........9-203 MF 6700 S series tractors...
- Page 18 10.3.3.2 Removing and refitting the fuse box ......1 0-17 MF 6700 S series tractors...
- Page 19 12.1.3.1 Air conditioning tests - General ......12-13 MF 6700 S series tractors...
- Page 20 12.4.3 Schematic diagram ..........12-63 MF 6700 S series tractors...
- Page 21 14.8.2 GPA20/Hydraulic Load Sensing system ......14-44 14.8.2.1 Load Sensing/Right-hand cover plate - Service tools ....14-44 MF 6700 S series tractors ACT0025630...
- Page 22 14.11.1 Belt - Service tools ..........14-56 MF 6700 S series tractors...
- Page 23 1.2.4.3 Forward speed calibration ........1-79 MF 6700 S series tractors...
- Page 24 1.2.4.17 Calibrate the suspended front axle....... . . 1-96 1.2.4.18 Calibrations to be carried out using the diagnostic tool ....1-98 MF 6700 S series tractors ACT0025630...
- Page 25 The purpose of this manual is to assist Dealers and Agents in the installation, servicing and repair of Massey Ferguson equipment. It is important to follow the methods shown and to use special tools in order to perform the operations within the times stated in the repair time schedule.
- Page 26 Low-pressure system pressure at 0,5 bar to 1 bar minimum speed Low-pressure system pressure at 0,5 bar to 1 bar maximum speed Recommended oil: API-CJ4 or ACEA-E9 Maximum operating tilt 25° pitch (precautions) 20° roll MF 6700 S series tractors ACT0025630...
- Page 27 SCR Technology with 1 ceramic substrate (exhaust fumes treatment) Safety system NOx sensors at exhaust inlet and outlet Device brand Bosch Denox 2.2+ Type of control Engine controller EEM4 Urea solidification temperature -11 °C Oil vapor recirculation system Closed system breather (CCV) MF 6700 S series tractors ACT0025630...
- Page 28 66 - 70 bar Parking brake type Hand brake Trailer brake type Hydraulic and pneumatic with built-in antifreeze pump Pneumatic trailer braking pressure 6,9 bar to 8,3 bar Hydraulic trailer braking pressure 0 to 150 bar MF 6700 S series tractors ACT0025630...
- Page 29 Ratio for fixed and suspended axle final drive Number of pinion/crown wheel 12/31 12/34 teeth Maximum steering angle 55° Oscillation angle ± 9° Type of oscillation stop Mechanical Suspension type Hydraulics MF 6700 S series tractors ACT0025630...
- Page 30 57 l/min or 100 l/min (OC) 110 l/min (CCLS) High-pressure pump maximum pressure 205 bar Maximum quantity of oil to add for heavy 10 l implements Maximum exportable oil quantity (without adding 32 l oil) MF 6700 S series tractors ACT0025630...
- Page 31 According to MF CMS M1145 specification Rear linkage Model All models Lift ram diameter 75 mm Linkage travel OC: 702 mm CCLS: 701 mm Maximum lifting capacity at ball joints GPA 22, GPA 22+, GPA 23: 7100 kg MF 6700 S series tractors ACT0025630...
- Page 32 Engine speed for 540 PTO 1980 rpm Engine speed for 540E PTO 1533 rpm Engine speed for 1000E PTO 1572 rpm Engine speed for 1000 PTO 2030 rpm Rotational direction Clockwise Clutch type Multidisc hydraulic 1-10 MF 6700 S series tractors ACT0025630...
- Page 33 12 V - 66AH L3 Maximum current at start-up (SAE standard) 420 A Starter type 12 V Iskra AZF Starter power 3 kW Alternator type 1 x 120 A SG10B Current available on ISOBUS connector 60 A MF 6700 S series tractors 1-11 ACT0025630...
- Page 34 MF 6716 S MF 6718 S Model Brand AGCO Power Type 49 AWF 115 (85) 130 (96) 140 (103) 150 (110) 165 (121) Nominal power hp ISO (kW) at an engine speed of 2100 1-12 MF 6700 S series tractors ACT0025630...
- Page 35 Fuel prefilter filtration 10 µ capacity Main fuel filter filtration 5 µ capacity Low-pressure system 0,5 bar to 1 bar pressure at minimum speed Low-pressure system 0,5 bar to 1 bar pressure at maximum speed MF 6700 S series tractors 1-13 ACT0025630...
- Page 36 DOC with metal substrate (exhaust fumes oxidation catalyzer) AdBlue ™ injection) SCR Technology with 1 ceramic substrate (exhaust fumes treatment) Safety system NOx sensors at exhaust inlet and outlet Device brand Bosch Denox 2.2+ 1-14 MF 6700 S series tractors ACT0025630...
- Page 37 Super Heavy Duty (SHD) Final drive reduction ratio (53+13)/13 (64+14)/14 Maximum 4WD clutch torque 180 daNm 206 daNm Number of 4WD disks 6 disks Main brake type Disk Number of disks per side 1 disk MF 6700 S series tractors 1-15 ACT0025630...
- Page 38 15.5 axle Total loaded weight supported by front 6000 kg axle Rotational direction Anti-clockwise Recommended oil type (beam and final SAE85W90 (API GL5-MIL 2105B) drive) Ratio for fixed and suspended axle final drive 1-16 MF 6700 S series tractors ACT0025630...
- Page 39 19 cm3 (OC 57 l/min) 19 cm3 + 14 cm3 (OC 100 l/min) 45 cm3 (CCLS) High-pressure pump rotational speed 2980 rpm (OC) 2532 rpm (CCLS) High-pressure pump maximum flow rate 57 l/min or 100 l/min (OC) MF 6700 S series tractors 1-17 ACT0025630...
- Page 40 175 bar ± 5 bar Pressure relief valve adjustment pressure 175 bar ± 5 bar Shock valve adjustment pressure 240 bar ± 5 bar Oil recommended for steering According to MF CMS M1145 specification 1-18 MF 6700 S series tractors ACT0025630...
- Page 41 Maximum permissible power 1000/1000E in 1"3/4 55 (40) (20 splines) Engine speed for 540 PTO 1980 rpm Engine speed for 540E PTO 1533 rpm Engine speed for 1000E PTO 1572 rpm Engine speed for 1000 PTO 2030 rpm MF 6700 S series tractors 1-19 ACT0025630...
- Page 42 12 V - 66AH L3 Maximum current at start-up (SAE standard) 420 A Starter type 12 V Iskra AZF Starter power 3 kW Alternator type 1 x 120 A SG10B Current available on ISOBUS connector 60 A 1-20 MF 6700 S series tractors ACT0025630...
- Page 43 MF 6716 S MF 6718 S Model Brand AGCO Power Type 49 AWF 115 (85) 130 (96) 140 (103) 150 (110) 165 (121) Nominal power hp ISO (kW) at an engine speed of 2100 MF 6700 S series tractors 1-21 ACT0025630...
- Page 44 Fuel prefilter filtration 10 µ capacity Main fuel filter filtration 5 µ capacity Low-pressure system 0,5 bar to 1 bar pressure at minimum speed Low-pressure system 0,5 bar to 1 bar pressure at maximum speed 1-22 MF 6700 S series tractors ACT0025630...
- Page 45 DOC with metal substrate (exhaust fumes oxidation catalyzer) AdBlue ™ injection) SCR Technology with 1 ceramic substrate (exhaust fumes treatment) Safety system NOx sensors at exhaust inlet and outlet Device brand Bosch Denox 2.2+ MF 6700 S series tractors 1-23 ACT0025630...
- Page 46 7 disks Main brake type 8"3/4 oil-immersed disk Number of disks per side 5 disks Braking pressure 80 bar Parking brake type Hand brake Trailer brake type Hydraulic and pneumatic with built-in antifreeze pump 1-24 MF 6700 S series tractors ACT0025630...
- Page 47 Ratio for fixed and suspended axle final drive Number of pinion/crown wheel 12/30 12/34 teeth Maximum steering angle 55° Oscillation angle ± 9° Type of oscillation stop Mechanical Suspension type Hydraulics MF 6700 S series tractors 1-25 ACT0025630...
- Page 48 Main relief valve adjustment pressure 230 bar ± 5 bar Number of spool valves (maximum) Number of front "push-pull" connectors Number of rear "push-pull" connectors Maximum flow rate per spool valve 100 l/min ± 10 1-26 MF 6700 S series tractors ACT0025630...
- Page 49 According to MF CMS M1145 specification Rear linkage Model All models Lift ram diameter 100 mm/40 mm Linkage travel 800 mm Maximum lifting capacity at ball joints 9600 kg Working pressure 180 bar 3-point linkage category MF 6700 S series tractors 1-27 ACT0025630...
- Page 50 6 and 21 in 1"3/8 and 20 in 1"3/4 Front power take-off Model All models Number of selections possible for front PTO 1000 rpm Maximum permissible power Clockwise: 136 hp Anti-clockwise: 150 hp 1-28 MF 6700 S series tractors ACT0025630...
- Page 51 This as a preview PDF file from best-manuals.com Download full PDF manual at best-manuals.com...