Summary of Contents for Kucht KUCHTNAPOLI
- Page 1 BE A IN YOUR KITCHEN Outdoor Kitchen | Gas Pizza Oven KUCHTNAPOLI INSTALLATION GUIDE AND USER MANUAL APPLICABLE MODEL: KUCHTNAPOLI...
-
Page 2: Safety Information
Read appliance. the installation, operation and maintenance instructions thoroughly before installing or servicing this equipment. WARNING For Outdoor Use Only. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... - Page 3 Turn off propane when not in use. oven in areas with high dust content. Minimum pizza oven clearances from combustible materials: 36 inches from the sides and back. SAFETY INFORMATION FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
-
Page 4: Carbon Monoxide Hazard
Don’t burn solid fuels in this fresh air immediately! For outdoor use only. appliance. Never use inside house, or other unventilated or enclosed areas. This pizza oven consumes air (oxygen). FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... -
Page 5: Important Safety Warnings
Wash hands a�er handling. When used, this product emits fuel combus�on chemicals that are known to the State of California to cause cancer, and birth defects or other reproduc�ve harm. Follow all instruc�ons in this manual and use only in well ven�lated, outdoor area. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... -
Page 6: General Warnings
GENERAL WARNINGS: Leak test all connec�ons before first use, even if pizza oven was purchased fully assembled and a�er each tank refill. Check the propane tank rubber seal for damage. Always check the pizza oven and propane tank prior to each use as indicated in the‘Checking for Leaks’ &‘Pre start Check List’ sec�ons of this manual. -
Page 7: Exploded View
EXPLODED VIEW PART LIST Description Pizza oven chimney Pizza stone Pizza oven Door handle Door handle connector Pizza oven door Grease tray LPG regulator and hose hook FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... - Page 8 Turn both burner control knobs to ‘OFF’ posi�on. Loading capacity Maximum loading weight of side tables: less or equal to 15 lbs (6.8kg) Maximum loading weight of warming rack: less or equal to 8.8 lbs (4kg) Assembly FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 9 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 10 10,000BTU 10,000BTU (NOT INCLUDED) NG hose assembly LP hose assembly (NOT INCLUDED) Coversion Kit label (NOT INCLUDED) Inlet manifold pressure For Propane-----11 inch water column For NG-----7 inch water column FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 11 Caution: Before proceeding with the conversion, shut off the gas supply to the appliance prior to disconnecting the electrical power." Step 1 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 12 ASSEMBLY INSTRUCTIONS FOR NG Step 2 Step 3 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 13 ASSEMBLY INSTRUCTIONS FOR NG Step 4 Step 5 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 14 ASSEMBLY INSTRUCTIONS FOR NG Step 6 Step 7 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 15 ASSEMBLY INSTRUCTIONS FOR NG Step 8 Step 9 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 16 ASSEMBLY INSTRUCTIONS FOR NG Step 10 Step 11 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 17 ASSEMBLY INSTRUCTIONS FOR NG Step 12 Step 13 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 18 ASSEMBLY INSTRUCTIONS FOR NG Step 14 LIGHTING ROD INSTRUCTION Step 1 FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 19 A damaged rubber seal can cause a gas leak, possibly resul�ng in explosion, fire, severe bodily harm, or death. Inspect rubber seal for cracks, wear or deteriora�on prior to use. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 20 If you exchange a cylinder with a qualified exchange program, the new cylinder must have a Type 1 valve and an over filling preven�on device(OPD). Inspect the propane tank valve rubber seal for cracks, wear or deteriora�on prior to use. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 21 5. Visually inspect the hose assembly prior to each use for evidence of damage, excess wear, or deteriora�on. If found, replace the assembly before using your pizza oven. Only the manufacturer’s supplied replacement should be used. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
-
Page 22: Leak Testing
Every me the LP gas cylinder is re lled, exchanged or if any of the gas components are disconnected or replaced. Any me your pizza oven has been moved. At least once per year or if your pizza oven has not been used for more than 60 days. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... - Page 23 16. Turn off gas supply at cylinder valve un�l you are ready to use your pizza oven. 17. Wash off soapy residue with cold water and towel dry. 18. Wait 5 minutes to allow all gas to evacuate the area before ligh�ng pizza oven. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 24 Maintain at least 36 inches of clearances from sides and back and do not use under overhead combus�ble construc�on. The cylinder should maintain at least 8 inches from the appliance. The distance between the desktop and the ground should be more than 18 inches. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
-
Page 25: Lighting Instructions
DO NOT a�empt to operate the pizza oven un�l the problem is found and corrected. Note: Observe flame height when lit: Flame should be a Blue/Yellow color between 1” 2” when burner is on ‘HI’. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... -
Page 26: Proper Care And Maintenance
Rust spots on the interior surface can be buffed, cleaned, and then lightly coated with vegetable oil or vegetable oil spray to minimize rus�ng,. Never use cleaners containing chlorine as chlorine promotes rust. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... - Page 27 Indirect cooking is the process of cooking your food without the heat source being directly under you food. You can sear meats over a high flame on one side of the pizza oven while slow cooking a roast on the other (unlit) side of the pizza oven. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
- Page 28 9. Replace bolts and nuts to each burner and crossover channel. Note: Follow the ‘Gas Leak Tes�ng’ sec�on of this manual. Relight burners to verify proper opera�on. 10. Replace heat tents and pizza stones. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...
-
Page 29: Burner Adjustment
Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of duct cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane. FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM... - Page 30 WE TRANSFORM A SIMPLE KITCHEN INTO A PRO ONE. THIS IS WHY WE CARE ABOUT MAKING VERY HIGH PERFORMANCE RANGES AND HOODS, TO MAKE YOU FEEL LIKE A PRO AND STYLISH COOKER. DESIGN: LONDON DC - WWW.LONDON-DC.COM FOR MORE DETAILS AND INFORMATION, PLEASE VISIT OUR WEBSITE WWW.KUCHT.COM...